2020 Mercedes-Benz GLE 350 engine problems

Filed Jul 29, 2026 · Driver assistance, Engine · CA

I keep getting coolant level low. I add coolant fluid into the tank and the warning message comes up again. I see no leaks under my vehicle so not sure if there’s a leak inside the tank itself or air leak somewhere but I’ve gotten that warning message about 10 or more times. Also as im driving the blind spot sensor just randomly goes off without a car or anything being next to me.

Filed Jun 26, 2026 · Electrical, Engine · IL

Water pool in passenger side of vehicle all into carpet and glovebox area

Filed May 28, 2026 · Engine · CA

The engine in my 2020 Mercedes-Benz GLE 350 experienced catastrophic internal failure while driving. No warning lights or check engine indicators came on. Prior to failure, the vehicle began making a loud metallic knocking/rattling sound during acceleration, similar to “rocks shaking in a box.” Shortly afterward, the engine suddenly stalled while driving and would no longer run. The vehicle still had electrical power but the engine would not restart. The vehicle was towed to Mercedes-Benz of Las Vegas for inspection. The dealer diagnosed the engine as seized and documented metal debris in the oil filter and oil/metal debris underneath the vehicle, indicating catastrophic internal engine damage. The dealer stated that the engine replacement was required.The failed engine and vehicle are currently located at Mercedes-Benz of Las Vegas and are available for inspection upon request.The vehicle stalled unexpectedly while being driven on a public roadway, causing sudden loss of engine power and creating a potentially dangerous traffic situation. The violent shaking and knocking before failure also caused concern that the vehicle could lose control or stop operating completely in traffic, which it ultimately did. A sudden engine seizure and stall while driving creates a significant safety hazard because the driver may lose the ability to accelerate, maneuver safely, or clear traffic. This could increase the risk of collision, especially at highway speeds or in heavy traffic conditions. Mercedes-Benz of Las Vegas inspected the vehicle and confirmed catastrophic engine failure. The dealer documented that the engine was seized and that metal debris was found in the oil filter and underneath the vehicle. The dealer advised that the engine required replacement and provided an estimated repair cost exceeding $27,000. The dealer has not yet identified the root cause of the failure. No dashboard warning lights, oil pressure warnings, or check engine lights illuminated.

Filed May 23, 2026 · Electrical, Engine · VA

We were traveling to our son’s college graduation, driving on a rural interstate and suddenly all of the vehicle’s warning lights lit on the dash and the car started losing, and then completely lost power. The car was no longer operational. We were stranded on the roadside of a remote but busy 2-lane interstate for 2 hours until a tow truck could arrive and take the car to the closest car repair shop which was 45 minutes away. This was an incredibly dangerous situation and we were fortunate to be alongside the shoulder, although we were still close to the tractor trailers and cars on the interstate. (Because we were stranded in such a remote place, we had no other options to get to our son’s graduation. We were unable to attend because of this.) The rural repair shop the car was initially towed to could not determine the problem. A few days later we found a 2nd tow truck that agreed to bring the vehicle several hundreds of miles back to our home city. This car is a 2020 model, and has around 55,000 miles. It has been meticulously maintained by a certified Mercedes mechanic. There were no issues with the car and no indication that there might be a problem. Our mechanic has thoroughly inspected the vehicle and said that the engine has completely seized and the only option is to replace it. We have no idea why this happened. If requested, the vehicle is available for inspection.

Filed Feb 12, 2026 · Engine · FL

Cooling system failure due to cracked coolant line beneath intake manifold at 57,000 miles. Part # 264-200-42-01. Sudden coolant loss can cause engine overheating and potential engine stall while driving, posing safety risks. The original part was plastic and has been superseded by manufacturer to metal, suggesting design inadequacy. This was confirmed by Mercedes Benz dealership and also by MB USA. There have been multiple reports by other owners online, indicating this has been a common problem on a 2020 GLE 350. There was also an article in Jan 2022 stating that Mercedes had sent a letter to 800,000 owners informing them of a defect, but no there was no recall due to part shortage. https://www.insurancejournal.com/news/international/2022/01/05/648140.htm Yes, dealership has diagnosed it and confirmed this is the problem. There was a warning lamp/message stating low coolant level, which prompted me to take the vehicle to the dealership. Car has been serviced regularly at the Mercedes dealership. Strong risk of overheating.

Filed Dec 12, 2025 · Engine · 100,000 miles · SC

The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that while driving at various speeds, the vehicle failed to accelerate as intended while the accelerator pedal was depressed. The check engine warning light was illuminated. In addition, the contact stated that while the vehicle was stopped, the vehicle was idling low. The vehicle was taken to a local dealer, where it was diagnosed with a misfire in cylinder #4. The vehicle was not repaired. Upon further investigation, the contact related the failure to a the federal safety agency recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Filed Nov 24, 2025 · Engine · FL

Cylinder head is defective and needs replacing. It is at the dealer for service at the tune of $7700. The car will not accelerate and sounds like it is in the wrong gear. Upon searching the Internet it seems like there are tons as in 1000’s of 2020, 2021 and 2023 Mercedes GLE 350s all having the same problem. There should be a recall as most cars are seeing this problem at 20,000 to 30,000 miles and at times when it is replaced, it turns around and happens again. Starting misfiring in October and continued to get worse.

Filed Oct 31, 2025 · Engine · GA

Engine Cylinder Head Failure on CPO Mercedes-Benz GLE 350 Vehicle Information: •Make: Mercedes-Benz •Model: GLE 350 •Year: 2020 •Mileage at time of issue: 90,000 Summary of Complaint: The vehicle experienced a premature cylinder head failure, resulting in significant engine damage and repair costs. There were no prior warning lights or diagnostic codes indicating a problem before the failure occurred. The malfunction caused sudden performance issues, including rough idling, misfiring, and loss of power. Details of the Incident: While operating the vehicle under normal driving conditions, the engine began to run roughly and lost power unexpectedly. Diagnostic testing revealed that the cylinder head had failed, which appears to be a mechanical or manufacturing defect rather than wear and tear. The repair estimate from the dealership was approximately $8,900, which is disproportionately high for a vehicle of this age and mileage. Safety Concerns: This type of failure could lead to sudden engine shutdown or loss of power while driving, posing a safety risk to occupants and other drivers on the road. Manufacturer Case Reference: This issue has also been reported to Mercedes-Benz under case number 18281587. Additional Information: After research, it appears that other Mercedes-Benz GLE owners have reported similar issues related to engine component failures, suggesting this may be a broader quality or manufacturing issue that warrants investigation. Requested Action: Requesting that the federal safety agency investigate potential defects in the engine or cylinder head assembly for the 2020 Mercedes-Benz GLE 350 and determine whether a recall or service bulletin is appropriate.

Filed Oct 20, 2025 · Engine · NY

I am writing to express serious concern regarding a potentially dangerous mechanical issue with my Mercedes GLE 350. The vehicle has experienced a complete cylinder head failure, requiring an estimated $7,000 repair. Both an independent service center and an authorized Mercedes service center have confirmed this diagnosis. During the inspection process, Mercedes conducted two diagnostic tests—one costing $250 and a second costing $700—before determining that the cylinder head must be replaced. I was informed by the Mercedes service advisor that the company is aware this issue has affected other GLE 350 vehicles; however, no recall has been issued to date. This failure presents a significant safety risk. The vehicle suddenly loses power without warning, and acceleration becomes severely limited, often not exceeding 20–40 mph even when pressing the accelerator fully. The check engine light illuminates at the time of power loss, leaving the driver unable to maintain safe highway speeds or merge with traffic—posing a serious hazard to both the driver and others on the road. Given that this appears to be a known issue, I am requesting immediate review and investigation by Mercedes-Benz. A recall or formal service campaign should be considered to address this potentially dangerous defect and to ensure the safety of all affected drivers. Thank you for your prompt attention to this matter.

Filed Sep 10, 2025 · Engine · NY

My 2020 Mercedes-Benz GLE 350 experienced a complete engine seizure at approximately 60,000 miles without any warning signs. The vehicle shut down and would not restart. The engine is completely inoperable. I am aware of recalls involving engine stalling and fuel system issues in this model, and I believe this may be related to a broader defect. Mercedes-Benz has not offered support as of this writing.