Mercedes-Benz GLE 350 misfire problems

Filed Nov 3, 2026 · Engine · FL

The engine light warning or indicator light failed to appear when engine began misfiring and shaking causing connecting rod to put a hole in the engine. My safety and the safety of others was put at risk because engine failure can produce the following safety hazards: The primary safety hazards to others include: • Sudden Oil Slick on the Highway: The engine block holds the vehicle's motor oil under pressure. When the rod punctures the block, gallons of hot oil can instantly dump onto the road surface. This creates an immediate, highly slippery oil slick, causing trailing vehicles to lose traction, skid, or crash. • Engine Bay Fire: The expelled motor oil and fuel vapors/spreading vehicle fire • Flying Shrapnel: Metal fragments from the piston, rod, or engine block can be violently ejected from underneath the car. • Immediate Loss of Vehicle Control The problem has been confirmed by the dealer and inspected by others. There were no warning lamps, messages, or lights prior to the failure.

Filed Jun 3, 2026 · Engine · CA

At approximately 87,000 miles, my 2021 GLE350 (M264 2.0T engine) experienced a severe engine misfire resulting in a flashing check engine light, rough idle, engine shaking, significant loss of power, and near-stall condition. The vehicle was taken to Speedhaus Automotive (Newbury Park, CA) where all four ignition coils and spark plugs were replaced. Total repair cost was approximately $635. This failure pattern is consistent with the documented M264 exhaust valve seat wear issue acknowledged by Mercedes-Benz technicians. A Mercedes dealer service report on an identical 2021 GLE350 explicitly states: "COMMON ISSUE FOR EXHAUST VALVE SEATS TO WEAR — KNOWN ISSUE WITH 260 AND 264 MOTORS." Mercedes-Benz has extended the warranty on the M260 engine (transverse variant) for this identical failure mode but has not extended it for the longitudinally-mounted M264 despite the same defect being present. Repair costs for full cylinder head failure on the M264 are being quoted at $6,000–$13,000. I am requesting the federal safety agency investigate whether a safety recall is warranted for the M264 engine across all affected GLE350, GLC300, C300, and E350 vehicles.

Filed Jan 8, 2026 · Engine · FL

There is a known issue with the Cylinder Heads on specific models of Mercedes vehicles. Symptoms of M264 Cylinder Head Failure If your GLE 350 is experiencing these symptoms, it may be covered under the extension: Check Engine Light (MIL): Often triggered by misfire codes. Rough Idle: Noticeable shaking or uneven idling when stopped. Loss of Power: Potential stalling or significant power reduction during acceleration. Low Compression: Diagnostic tests often reveal low pressure in one or more cylinders. This is not being addressed my Mercedes USA where Mercedes Canada has offered an extended warranty. Using social media I have comprised a list of over a hundred impacted owners. Many more exist. What this does is cost catastrophic failure of the engine leaving the driver stranded in whatever lanes they were traveling in. I am disabled and for me this created a life threatening situation. When reaching out to MBUSA the answer is simply "not warranty exists" where MB Canada has extended the warranty to an additional 15k miles from notice. My engine blew. The replacement cost is near $20,000 dollars. The mileage on my engine was 65k. Many others are impacted and a class action lawsuit is the only other course of action it seems. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 12, 2025 · Engine · 100,000 miles · SC

The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that while driving at various speeds, the vehicle failed to accelerate as intended while the accelerator pedal was depressed. The check engine warning light was illuminated. In addition, the contact stated that while the vehicle was stopped, the vehicle was idling low. The vehicle was taken to a local dealer, where it was diagnosed with a misfire in cylinder #4. The vehicle was not repaired. Upon further investigation, the contact related the failure to a the federal safety agency recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Filed Nov 24, 2025 · Engine · FL

Cylinder head is defective and needs replacing. It is at the dealer for service at the tune of $7700. The car will not accelerate and sounds like it is in the wrong gear. Upon searching the Internet it seems like there are tons as in 1000’s of 2020, 2021 and 2023 Mercedes GLE 350s all having the same problem. There should be a recall as most cars are seeing this problem at 20,000 to 30,000 miles and at times when it is replaced, it turns around and happens again. Starting misfiring in October and continued to get worse.

Filed Oct 31, 2025 · Engine · GA

Engine Cylinder Head Failure on CPO Mercedes-Benz GLE 350 Vehicle Information: •Make: Mercedes-Benz •Model: GLE 350 •Year: 2020 •Mileage at time of issue: 90,000 Summary of Complaint: The vehicle experienced a premature cylinder head failure, resulting in significant engine damage and repair costs. There were no prior warning lights or diagnostic codes indicating a problem before the failure occurred. The malfunction caused sudden performance issues, including rough idling, misfiring, and loss of power. Details of the Incident: While operating the vehicle under normal driving conditions, the engine began to run roughly and lost power unexpectedly. Diagnostic testing revealed that the cylinder head had failed, which appears to be a mechanical or manufacturing defect rather than wear and tear. The repair estimate from the dealership was approximately $8,900, which is disproportionately high for a vehicle of this age and mileage. Safety Concerns: This type of failure could lead to sudden engine shutdown or loss of power while driving, posing a safety risk to occupants and other drivers on the road. Manufacturer Case Reference: This issue has also been reported to Mercedes-Benz under case number 18281587. Additional Information: After research, it appears that other Mercedes-Benz GLE owners have reported similar issues related to engine component failures, suggesting this may be a broader quality or manufacturing issue that warrants investigation. Requested Action: Requesting that the federal safety agency investigate potential defects in the engine or cylinder head assembly for the 2020 Mercedes-Benz GLE 350 and determine whether a recall or service bulletin is appropriate.

Filed Sep 19, 2025 · Engine · IN

I am writing to document a recurring and serious issue with the Mercedes-Benz GLE equipped with the M264 engine, specifically relating to premature cylinder head failure. In my case, the vehicle began showing the following symptoms: Rough engine idle and noticeable vibration during startup Loss of power, especially when accelerating Check engine light with fault codes related to misfire or combustion issues Oil and/or coolant loss, with no external leaks Engine knocking or ticking noises near the top end of the engine After a professional inspection and diagnostic testing, I was informed that the issue is likely due to a defect or failure in the cylinder head, possibly involving warping, cracking, or failure of the valve seats or head gasket area. Upon further research, I discovered that this issue is not isolated. Multiple owners of vehicles with the M264 engine—including various GLE, C-Class, and E-Class models—have reported similar problems, often occurring well before 70,000 miles and despite regular maintenance. The pattern suggests a possible design flaw or quality issue with the engine’s cylinder head. As of now, it appears no formal recall or technical bulletin has been issued by Mercedes-Benz regarding this specific problem. However, the number of similar reports suggests the issue is widespread enough to merit formal investigation or at least acknowledgment by the manufacturer.

Filed Aug 11, 2025 · Engine · OR

The vehicle recently experienced a cylinder head failure, confirmed by a diagnotic code P0302 (Misfire in cylinder 2), resulting in rough idling, reduced power, and potential safety risks during opreration. This issue appears to be a known defect in the M264 engine, as evidenced by similar complains from owners of GLE 350, GLC 300, and other models on forums like [XXX] and [XXX] . The failure occurred just beyond the standard 4-year/50,000-mile warranty, and Mercedes-Benz USA denied my request for a goodwill repair despite acknowledging similar issues in related models under extended warranties. Repair costs are estimated $8,000 to $13,500. I believe this defect warrants investigation due to its prevalence and potential to cause sudden power loss, which could lead to hazardous driving conditions. I urge the federal safety agency to investigate the M264 engine in the 2020 GLE 350 for a possible recall to protect owners and ensure safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 11, 2025 · Engine · 71,000 miles · CA

The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that while driving at low speeds, the vehicle entered LIMP Mode but continued to operate with reduced motive power. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed the vehicle with engine control unit failure causing the engine to run lean, resulting in misfires in cylinders #1 and #2 and damage to the engine. The contact was informed that the engine had failed a pressure test and needed to be replaced. The contact was advised to take the vehicle to the dealer for assistance. The vehicle was towed to the dealer, who confirmed the diagnosis and determined that the failure could be resolved with a top end engine replacement of the cylinder head, valves, valve springs, rocker arms, camshaft, spark plugs, and valve cover. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 71,000.

Filed May 19, 2025 · Engine · DE

Bought a 2020 Gle 350 used with 55000 miles on it. Within 3 weeks the check engine light comes on and the car goes into limp mode. Cannot drive it. Took it to Mercedes of Wilmington. They said it was a misfire on 4. They replaced all spark plugs and the coil to cylinder 4. Another month later the same thing happens. Took it back to Mercedes. Stated the car needs a new cylinder head at the cost of 12000$. This seems to be a common problem on these vehicles. A recall is needed immediately