Mercedes-Benz ML350 stalling problems

Filed Jul 22, 2026 · Brakes, Engine · 88,000 miles · PA

The contact owns a 2011 Mercedes-Benz ML350. The contact stated that while driving approximately 60–65 MPH, the brake pedal was depressed and the vehicle started sliding. The contact stated that the vehicle stalled. The brake warning light was illuminated. The vehicle was towed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 88,000.

Filed May 22, 2026 · Fuel system · NH

The failed/malfunctioning component appears to be the fuel pump controller / fuel pump control unit, and possibly the fuel pump system. The Mercedes-Benz dealer identified water/moisture-related damage and corrosion at the fuel pump controller area. The failed component should be available for inspection if the dealer preserves the part during repair. I have requested that the dealer not discard the damaged component. My safety and the safety of others were put at risk because the fuel pump controller is related to fuel delivery. If it fails, the vehicle may not start, may lose fuel supply, or may stall while driving. This creates a safety risk, especially if the vehicle stalls in traffic, at an intersection, on a highway, or during normal driving. The problem has been confirmed by a Mercedes-Benz dealership. The dealership diagnosed water/moisture damage to the fuel pump controller area and provided an estimate of $768.22 for fuel pump controller replacement, plus $244.88 for the inspection fee. The dealer also indicated that this was the first inspection and that the fuel pump itself may also need further inspection or may have related damage. The vehicle/component has been inspected by a Mercedes-Benz dealership. Mercedes-Benz USA / the manufacturer’s representative has also reviewed the case through its goodwill process, but they refused to treat it as recall-related coverage. To my knowledge, the vehicle has not been inspected by police or insurance representatives. Prior to the current failure, the vehicle had starting/no-start related symptoms beginning around the middle of 2023. The engine could not start successfully at times. I do not recall receiving a clear warning lamp or message specifically identifying the fuel pump controller before the failure. However, the symptoms were consistent with a fuel delivery problem, and the dealer later confirmed water/moisture corrosion damage in the fuel pump controller area.

Filed Apr 14, 2026 · Fuel system · NM

Engine stalled driving on interstate highway at 70mph. Mechanic diagnostic indicated to be faulty fuel pump and/or fuel pump control unit. This issue has been recognized by mercedes benz as a faulty issue and subject to recall. Upon calling mercedes benz dealer was told there was no recall on this matter for my vehicle contradicting this issue previously recognized by mercedes benz.

Filed Jan 15, 2026 · Engine, Fuel system · 96,000 miles · FL

The contact owns a 2013 Mercedes-Benz ML350. The contact stated that while driving approximately 40 - 45 MPH, the vehicle stalled in the middle lane. The driver was able to push the vehicle safely to the roadside. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed, and determined that the fuel pump needed to be replaced. The vehicle was repaired. The following day, it took two minutes to start the vehicle. The vehicle was drivable, but the vehicle eventually stalled while driving. The vehicle was towed to another local dealer, Mercedes-Benz of South Orlando (4301 Millenia Blvd, Orlando, FL 32839), where it was diagnosed with a faulty fuel sensor and control valve. The parts were replaced. The contact stated that the fuel pump was replaced four times, but the failure persisted. The manufacturer was contacted and escalated the failure was escalated to an engineer for assistance. The failure mileage was approximately 96,000.

Filed Nov 20, 2025 · Fuel system · CA

As we were driving 50mph, the car stalled and lost all power. The dashboard lights all lit up and the car wouldn't start. I don't get unnerved easily and it was fairly intense not being able to move your car out of traffic. After about 5 mins, the car would start again only to stop a minute or so later. After taking the car to the dealer, the issue stemmed from the fuel pump electronics board getting wet in the spare tire wheel well where water was accumulating. This was part of the recall and the dealer installed a drain and replaced the board. HOWEVER, this issue again happened nearly one year later in our next rainy season. After taking it to the dealer, they said WE would need to replace the electronics board ourselves. We asked about the recall and they said they fixed the issue by installing the drain plug and there was nothing else they could do for us. Even the service adjuster was upset and very sympathetic to our plight as the car was obviously not fixed. Even though the drain plug was installed, the water was still acumulating in the wheel well. It seems apparent to me, and several others who have complained about the same issue, that the recall fix has not addressed the main issue of why the water is coming in and why it's still not draining. Unfortunately we're going to have to fork over $1200 to have it fixed. My ask to the federal safety agency is that this issue be readdressed with Mercedes. I would like them to be notified that the recall does not address the underlying issues and the solution they provided does not fix the problem. I appreciate your time in considering this.

Filed Jun 20, 2025 · Fuel system · 60,000 miles · CA

The contact owns a 2014 Mercedes-Benz ML350. The contact stated while the vehicle was idling in the driveway, the vehicle stalled. The contact stated that AAA added fuel to the vehicle, and the vehicle was able to restart and operated as needed. The contact stated that the vehicle was taken to the dealer for the recall repair of the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline), and the dealer installed a water drain plug on the vehicle. The contact stated that the check engine warning light was later intermittently illuminated. The vehicle was taken to Complete Performance, where it was diagnosed with fuel pressure failure. The contact replaced the gas cap; however, the failure persisted. Additionally, the contact stated while driving 45 MPH, the vehicle stalled while there was sufficient fuel in the fuel tank. The contact was able to pull over to the side of the road. The vehicle was able to restart after fuel was added to the vehicle. An unknown dealer was notified of the failure and informed the contact that the fuel pump was not previously replaced during the recall repair of the federal safety agency Campaign Number: 22V955000( Fuel System, Diesel, Fuel System, Gasoline). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.

Filed Jan 6, 2025 · Fuel system · SC

Vehicle stalled without warning, and I was advised by a mechanic that the fuel pump control unit was reporting a fault through the onboard diagnostics port and the check engine light on the dashboard. It was necessary to replace the fuel pump control unit as the defect was intermittent and subject to occur at any time the vehicle was being driven. There is no available solution save the replacement. I had the fuel pump control unit replaced at my cost and after replacing it found information concerning the federal safety agency recall campaign online. The defective fuel pump control unit was discarded upon replacement and is not available for inspection. I believe the failure of this fuel pump control unit is a direct result of the recall not being complied with. I believe the manufacturer; Mercedes Benz USA is responsible for my costs expended in repairing this defect under the recall campaign because they did not notify me of the recall. I purchased this vehicle from an authorized Mercedes Benz USA dealer, my personal contact information is a matter of record of the sale, and I believe Mercedes Benz USA had a duty to contact me concerning the federal safety agency recall campaign #2023010002 concerning this vehicle.

Filed Dec 25, 2024 · Fuel system · OH

On [XXX], while driving on the highway about 30 miles from Columbus, Ohio my 2013 Mercedez Benz ML350 suddenly stalled and lost power. There was no prior warning. Luckily, we were in the outer lane with no car close behind us so my husband slowly guided the car to the side road. The car has since been towed and is currently at the Service Department at Mercedez Benz of North Olmsted, Ohio, 44070, for repairs. I have been informed by the Service Manager that they have identified the fuel pump to the problem and that it needs to be replaced. Coincidentally, this vehicle went for Maintenance Servicing at the same dealership and was returned to me on Monday December 16th. No problem with the fuel pump was identified or reported to me. This vehicle is available for inspection About 4 years ago, the exact same incident happened with this same vehicle where it suddenly stalled and completely lost power on the highway in the middle of nowhere on our way from Ohio to Iowa. There was no prior warning. Similarly, the car was towed to Mercedez Benz North Olmsted but per the same service manager their inspection revealed no problem and the car restarted on its own so nothing needed to be fixed. I am reporting this recurring problem with my vehicle because of the obvious safety risk of sudden stalling and power loss on the highway, the fact that 4 years ago when this happened Mercedez Benz should have recognized what the issue was and replaced the fuel pump but did nothing about it, and also due to the fact that many Mercedez Benz vehicles have experienced this same problem leading to multiple recalls including many 2013 ML 350s. I believe my vehicle has a defective fuel pump from the manufacturer just like the recalled vehicles and that my vehicle and many more need to be recalled INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 2, 2024 · Electrical, Fuel system · IL

ML350 engine stalled while driving on an expressway and would not turn back on. ML350 needed to be towed where it was determined that water accumulated in the spare tire wheel well, leading to the fuel pump short circuiting. This is directly related to the federal safety agency campaign 22V955000. That recall repair was completed prior to this incident. Per the technician, the recall repair installed a water drain plug to prevent the water accumulation. This repair effectively failed - the drain plugs malfunctioned and were not allowing water to drain. MBUSA deny’s responsibility for the failing drain plug - stating that the trunk weatherstripping is the root cause, not the failing drain plug. This is an unacceptable response and worth of the recall being expanded. The fuel pump control unit can still short out if MBUSA’s poor excuse of a recall fix fails as it did with mine.

Filed May 20, 2024 · Fuel system · 120,000 miles · NJ

The contact owns a 2015 Mercedes-Benz ML350. The contact stated while reversing, the vehicle stalled and failed to restart. The vehicle was towed to the local mechanic who determined that the fuel pump was faulty and needed to be replaced. The fuel pump was replaced, and the vehicle was repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was included in the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 120,000.