I purchased a used Mercedes-Benz from Freehold Mitsubishi in early 2024. Within hours, serious safety issues appeared, including a check engine light, cylinder misfire, EVAP leak, traction control failure, and blind spot assist malfunction. The vehicle’s ECM and wiring harness were later found damaged due to oil leaks and electrical shorts. Despite multiple repair attempts, the vehicle was returned in worse condition and remains unsafe to drive. I am reporting these issues due to their potential risk to vehicle safety.
Mercedes-Benz ML350 check engine light comes on
29 of the 454 owner complaints about the Mercedes-Benz ML350 describe check engine light, most of them for the 2014 model year.
- owner complaints
- 29
- worst model year
- 2014
- typical repair cost reported
- $9,300
- typical mileage
- 88,000
Is there a fix? No recall or service bulletin covers this area of the car yet.
By model year
Often reported together
What owners say
The contact owns a 2014 Mercedes-Benz ML350. The contact stated while the vehicle was idling in the driveway, the vehicle stalled. The contact stated that AAA added fuel to the vehicle, and the vehicle was able to restart and operated as needed. The contact stated that the vehicle was taken to the dealer for the recall repair of the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline), and the dealer installed a water drain plug on the vehicle. The contact stated that the check engine warning light was later intermittently illuminated. The vehicle was taken to Complete Performance, where it was diagnosed with fuel pressure failure. The contact replaced the gas cap; however, the failure persisted. Additionally, the contact stated while driving 45 MPH, the vehicle stalled while there was sufficient fuel in the fuel tank. The contact was able to pull over to the side of the road. The vehicle was able to restart after fuel was added to the vehicle. An unknown dealer was notified of the failure and informed the contact that the fuel pump was not previously replaced during the recall repair of the federal safety agency Campaign Number: 22V955000( Fuel System, Diesel, Fuel System, Gasoline). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.
I purchased my car used at the Mercedes dealership in Tyler Texas June 2023. I took all my savings and paid cash and was told that the car was impeccable shape and there were no current issues and all the service records were up to date. November 2023 is when everything started happening and my engine light came on. It was revealed to me by a service tech that I was sold the vehicle with an existing major oil leak /seals broke. Etc. SEE Attached invoices. I have endured driving down the road and my car just giving out and losing power steering. The car has been sputtering and there have been misfires, fauled fuel injectors, coils, s and spark plugs, oil leaks, fuel pump leaking gasoline in the engine and smoke coming from the hood. I thought my car was going to start on fire it smelled like a hot electrical wires and gasoline. My nerves are frayed from this car because of how many times it has broke down. I have missed work because of the car, I'm behind on my home bills, I missed my airline flight to see my sick father, I have had to pay for rental cars, all due to this vehicle. I am very concerned for my safety in this vehicle and I would like the vehicle fixed at the expense of Mercedes or my money back. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2015 Mercedes-Benz ML350. The contact stated that while driving at various speeds, the vehicle shook abnormally before the vehicle lost automotive power. The contact was able to restart the vehicle and take the vehicle to a local dealer. The contact stated that the vehicle was repaired under the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline); however, the repair failed to prevent the failure. The contact stated that two weeks after the recall repair, the failure reoccurred. The check engine warning light was illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The vehicle was scanned by a local independent mechanic who retrieved DTC: P035413, A10D, P072102, U016886, V1FBD04, 94C3, V1DAV54, V1DBD31, P030085, and V142E31. The manufacturer was made aware of the failure. The failure mileage was approximately 88,000.
Vehicle stalled without warning, and I was advised by a mechanic that the fuel pump control unit was reporting a fault through the onboard diagnostics port and the check engine light on the dashboard. It was necessary to replace the fuel pump control unit as the defect was intermittent and subject to occur at any time the vehicle was being driven. There is no available solution save the replacement. I had the fuel pump control unit replaced at my cost and after replacing it found information concerning the federal safety agency recall campaign online. The defective fuel pump control unit was discarded upon replacement and is not available for inspection. I believe the failure of this fuel pump control unit is a direct result of the recall not being complied with. I believe the manufacturer; Mercedes Benz USA is responsible for my costs expended in repairing this defect under the recall campaign because they did not notify me of the recall. I purchased this vehicle from an authorized Mercedes Benz USA dealer, my personal contact information is a matter of record of the sale, and I believe Mercedes Benz USA had a duty to contact me concerning the federal safety agency recall campaign #2023010002 concerning this vehicle.
an Exhaust recycle hose cracked; causing cabin to fill with carbon dioxide. Driver, (me) became disorented.. ran off right shoulder, ran into center divider cement, before rearending truck. Engine light later came on indicating (HVOC?) ERROR Mechanic was able to locate leak and repair. Vehicle now performing properly. A DEFECT THAT ALLOWS CARBON DIOXIDE INTO THE PASSENGER CABIN, IS A SERIOUS AND LIFE THREATENING SITUATION.
The contact owns a 2015 Mercedes-Benz ML350. The contact stated while driving at undisclosed speeds, the vehicle temporarily lost motive power before returning to normal driving functionality. There was no warning light illuminated. The vehicle was taken to a dealer and the contact was informed that the check engine light displayed after repairing the vehicle under the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline). The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 79,000.
The contact owns a 2015 Mercedes-Benz ML350. The contact received notification of the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 40 MPH, the vehicle started to lose motive power and was making an abnormal sputtering sound as if the vehicle was running out of gasoline. The contact stated that the vehicle stalled with the check engine warning light illuminated. The contact pulled over and was able restart the vehicle. The failure had become a recurring failure. The manufacturer had not been made aware of the failure. The failure mileage was approximately 104,000. Parts distribution disconnect.
I am writing in regards to my 2014 ML 350 Suv. The check engine light came on and upon taking it to the mercedes dealership, I was told the issue is that the camshaft adjusters have failed and need to be replaced. The cost quoted is over $11,000 to repair. Upon further investigation I found reports on multiple lawsuits for the Mercedes C series for the same year (2012-2014) that resulted also in a recall whereby customers were given a recall to replace at no charge the camshaft adjusters up to 120k miles. My car only has 83k and I am told by two independent mechanics that the camshaft adjuster should not be failing like this and that this has been an ongoing issue with Mercedes. The safety issue is that I am told by independent mechanics that what could happen over time is that I could be driving and the entire engine/power just shuts off. This could even happen at high speeds on the highway. The mercedes dealer tells me there is no safety issues that could result from camshaft adjuster problems which doesn't appear to be true as per the other independent mechanics. I request further investigation into this issue because as per the independent mechanics its the "same engine" as the 2012-2014 that are under the recall . I'm requesting a recall on this for my car that Mercedes pays for. This should not be failing especially in a car with only 83k on it . If the C series 2012-2014 received recall on this part then I also think my ML 350 should be covered. Mercedes customer service tells me they cannot pay for the repair, they said I could file complaint for recall through the federal safety agency Thank you .
The contact owns a 2011 Mercedes-Benz ML350. The contact stated while driving 45 MPH, the contact noticed that the check engine warning light was illuminated. The contact stated that the message indicating an EVAP leak was displayed. The contact checked and noticed that there was a leak underneath the vehicle coming from the fuel tank. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 114,000.
Related recalls
No recalls on record for this model year.
Questions about the Mercedes-Benz ML350 check engine light
Why does the check engine light come on in the Mercedes-Benz ML350?
Owners who report it most often also describe engine stalls while driving, fuel pump failure and sudden loss of power.
Which Mercedes-Benz ML350 years have check engine light problems?
The model years with the most reports are 2014 (8 complaints), 2011 (6 complaints) and 2012 (5 complaints).
How much does it cost to fix check engine light on the Mercedes-Benz ML350?
Owners who mentioned a price put the repair at about $9,300 (median of 7 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Mercedes-Benz ML350?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history