To who may this concerned, I have a 2003 Mercedes SL500 and recently found my battery control module caught on fire and burnt a section of my car. I have tried reaching out to Mercedes directly first and they said the car is 20 years ago and it could have not be a manufactured defect. Please I need help this problem could’ve burn down my house or while I was driving. Mercedes requested I send them a letter in writing if I have to get the car inspected. Please setup and date so I can write them this is 100% liability on their brand as there is no schedule maintenance for a battery control module.
The worst 2003 Mercedes Benz SL500 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Suspension34
- Fuel system20
- Brakes14
- Electrical10
- Engine6
- Steering6
- Driver assistance5
- Airbags4
- Transmission4
- Body3
- Seat belts1
Specific symptoms reported on the 2003 Mercedes Benz SL500
Recalls
No recalls on record for this model year.
Defect investigations
Air suspension system failure
The subject s-class vehicles contain a compressed air suspension system that uses air struts on each of the four wheels in lieu of traditional springs and shock absorbers.these air struts use compressed air to support the weight of the vehicle and control ride height.in the event of the loss of air from the system, an alert will flash on the instrument cluster warning the driver to either drive carefully or to stop the vehicle.the vehicle ride height can be reduced by as much as 105 mm below normal ride height before the full load of the vehicle for that wheel comes to rest on a steel rod, with a rubber stop on the end, located in the shock absorber.this rest-stop condition is designed such that there is no impact on vehicle control.mercedes-benz (mbusa) supplied video showing a vehicle in this condition operating under several different situations including evasive maneuvers demonstrating the ability of the vehicle to be controlled effectively with a ride height reduced to the minimum.only those complaints to odi and mbusa that alleged a steering interference during a reduced ride height condition were counted in this resume failure report.some complaints alleged that with a reduced ride height and a stop now warning message there was a rubbing noise when turning, but the ability to steer the vehicle was not compromised.a sampling of warranty claims submitted by mbusa did not reveal any indicating a loss of control due to an airmatic system failure.there was one crash reported by mbusa to odi but the information available indicated that it related to suspension systems and it was not possible to verify that the incident was related to an airmatic system failure. Further use of agency resources in this matter does not appear to be warranted.the agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and will take further action in the future if warranted.this preliminary evaluation is closed.
PE07042
Technical service bulletins for the 2003 Mercedes Benz SL500 48
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The warranty on the SBC Hydraulic Unit for MY 2003-2006 Model 211, MY 2006 Model 219, and Model Year...
- Repeat workshop visit for vehicle vibration while braking from 60MPH. NOTE: Although the symptom is...
- Clanking noise from the area of the speakers in the doors
- Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end)
- There are several types of complaint about noises or poor windshield wiper wiping performance: A: Wiper...
- Headlamp, front fog lamp leaky or fogged
- Headlamp, front fog lamp leaky or fogged
- Headlamps leaking or fogged
- Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end)
- Headlamp, front fog lamp leaky or fogged
2003 Mercedes Benz SL500 fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 5.0L 8‑cyl | RWD | 14 | 20 | 16 |
What 2003 Mercedes Benz SL500 owners say
Most recent owner complaints, unedited.
I am concerned with the battery control module. I have noticed there has been a lot of incidents out there where the battery control module in the SL 500s have caught fire! I am concerned for my safety due to this defect!
The contact owns a 2003 Mercedes-Benz SL500. The contact stated while driving at various speeds, the ABC warning light illuminated. Additionally, the message "Drive Carefully" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed that the ABC tandem pump, struts, and hoses needed to be replaced. The dealer was notified of the failure and informed the contact that they did not provide service for older vehicles. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 88,000.
ABC (Active Body Control) light keeps coming on and body goes up and down when I drove car. Light says do not drive. Mercedes would not take responsibility for this in spite there are so many complaints about this. Really irresponsible by Mercedes.
I was driving my car at 45 mph and suddenly, unexpectedly a red light flashed ABC do not drive. Smoke was coming from under the car and the front end of the vehicle collapsed downwardly. I had to call for a tow truck to take my vehicle to the MB dealership. I'm I am waiting for the prognosis. I've had numerous issues with the All Body Control system. Expensive repairs in the $3000-$8000 range. This is a safety issue the breakdown happens abruptly and I was fortunate other cars weren't on the parkway with me. Otherwise a crash could gave occurred.
The contact owns a 2003 Mercedes-Benz SL500. The contact stated while driving 40 MPH, the brake pedal was depressed however, the vehicle failed to respond as needed. The contact depressed the brake pedal firmly however, the vehicle failed to respond. The parking brake was activated however, the vehicle failed to respond as designed. The contact was however able to pull over and eventually the vehicle came to a complete stop. The vehicle was towed. The dealer and the manufacturer were contacted and stated that the VIN was not included in the federal safety agency Campaign Number: 05V133000 (Service Brakes, Hydraulic). The failure mileage was 126,000. The consumer stated the part put on the vehicle for the recall was a defective part and not installed correctly.
The 2003 SL500 with seemingly no instigating incident or event had the gas tank baffle come apart due to the poor and faulty design of this component. This baffle now is loose and floats on the gas in the gas tank, banging around when there is acceleration or deceleration, even turning sometimes causes it to bang around. Speed bumps are another source of loud banging from the baffle bumping into the sides of the tank. The issue with 2003 SL500's is ubiquitous, it is not a question of what percentage of them will experience as it appears it will happen to this vehicle at some point due to the poor design and implementation of the baffle. This wouldn't be such a big problem if this was a minor repair and was a reasonable price to have a shop perform or for the more mechanically inclined owner to perform themselves, but it is a ridiculously complex and time-consuming job just to get to the gas tank and take it off. My mechanic told me it is akin to taking the transmission or engine out and as such labor is outstandingly and outrageously expensive with this job requiring approximately $2000-$2500 to perform according to my mechanic and other SL500 owners who have also had to deal with this issue. This is an issue that you may not experience if you don't own one of these vehicles for long enough, but the vehicle will have this problem during it's lifetime and Mercedes should be responsible for allowing such a design to make it into production.
The contact owns a 2003 Mercedes-Benz SL500. The contact stated that after parking the vehicle, the following day he noticed that the front of the vehicle was lowered down. The contact stated that the car was too low a warning light was illuminated. The contact stated while starting the vehicle and taking his foot off the brake pedal, the vehicle would raise up independently and would be able to drive to his destination. The contact took the vehicle to the local dealer, where it was diagnosed with needing the front strap suspension to be replaced. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 52,500.
It has been nearly two years I have stopped driving my 2003 Mercedes SL500, although I only have about 80,000 miles on the car. This is due to ABC warning light(red display: please drive carefully)comes on intermittently and the car drives very bouncy and it feels the car has no shocks, definitely feeling it would be unsafe to drive. The diagnostic message comes up saying "visit workshop". This is the third time this ABC pump issue is stopping me from driving the car, since it first appeared when I had 29,000 miles on the car which was under manufacturer warranty (50,000 miles or four years) and the dealership replaced the ABC pump and also replaced the engine mounts. The ABC red light appeared again when I had about 51,000 miles on the car. It happened also the engine mounts were in need of replacement again. As the Warranty was only for 50,000 miles, Mercedes refused to repair the ABC pump and the engine mounts under warranty and finally I agreed to a 50% cost to me to have repairs done. I expressed my opinion that the ABC pump and the engine mounts had engineering and manufacturing defect and they should have 50,000 miles warranty as the original warranty, from the time of replacement. Regrettably, same ABC malfunction and engine mounts became an issue at 78,000 miles and now the dealer and Mercedes refuse to replace the ABC pump and engine mounts under warranty and have given an estimate of $7336.36 for the necessary replacement of parts, including labor, but excluding taxes. To divert attention from ABC pump, the dealer is now referring to the problem as "power Steering pump"I have extensively researched the issues and it appears the mentioned problems with my car are prevailing issues with other Mercedes 2003 SL 500, and there are 100's of owners who feel Mercedes is not taking responsibility for replacement and repair of these defective parts under warranty. My car is unsafe to drive. There should be a recall by Mercedes to fix these dangerous to drive cars.
Tl* the contact owns a 2003 mercedes benz sl500. The contact stated while driving 45 MPH, the active body control (abc) warning light illuminated and the steering wheel became difficult to turn. The contact parked the vehicle on the side of the road. The vehicle was not drivable. The vehicle was towed to an unknown mercedes-benz dealer to be diagnosed. The contact was informed that the active body control (abc) needed to be replaced. The vehicle was repaired however, the failure persisted. The manufacturer was not informed of the failure. The failure mileage was approximately 95,000. The VIN was not available.
Compare the 2003 Mercedes Benz SL500
Other model years
199219931994199519961997199819992000200120032004200520062009
Questions about the 2003 Mercedes Benz SL500
Is the 2003 Mercedes Benz SL500 reliable?
Owners have filed 80 complaints about the 2003 Mercedes Benz SL500, 4.2 times a typical SL500 model year. It is one of the years we flag to avoid.
What is the 2003 Mercedes Benz SL500 year score?
The 2003 Mercedes Benz SL500 scores 23 out of 100 (poor). The score compares it with the other model years of the Mercedes Benz SL500: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2003 Mercedes Benz SL500?
Suspension, with 34 complaints, typically around 64,000 miles. Next is fuel system (20).
How many recalls does the 2003 Mercedes Benz SL500 have?
No recalls on record.
What year does the Mercedes Benz SL500 have bad suspension?
The Mercedes Benz SL500 model years with the most suspension complaints are 2003 (34 complaints) and 2004 (21 complaints).
What gas mileage does the 2003 Mercedes Benz SL500 get?
Official estimates for the 2003 Mercedes Benz SL500 range from 16 mpg combined. The most efficient version (5.0L 8-cyl, RWD) gets 14 city and 20 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2003 Mercedes Benz SL500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history