After 27 years the rubber fuel filler pipe on the car cracked and began leaking fuel. The fuel filler pipe was replaced with a new fuel filler pipe from ford motorcraft, part #kfl-22, focz-9324-aa. The new fuel filler pipe lasted only 6 months before cracking and spilling gas on my driveway creating a hazardous situation. The car was repaired with a new third party [not ford] fuel filler pipe. I'm bringing this to your attention because numerous auto repair web sites have hundreds of complaints regarding defective replacement ford fuel filler pipes [all ford models]. Fuel filler pipes should last more then 6 months. Ford's replacement fuel filler pipes are defective and should be recalled for replacement by ford to prevent a very hazardous situation should a vehicle be parked in a garage, I.e., near a water heater or other ignition source, creating a life-threatening situation. The leak from the fuel filler pipe occurs whether or not the vehicle is parked or moving when the fuel tank is more then 3/4's full. The pipe deteriorates from the outside with cracks running the length of the pipe. The nylon webbing on the inside of the pipe does not prevent it from leaking. The attached photo shows the defective pipe, but the hundreds of hairline cracks in the pipe cannot be seen in the photo because of photo resolution. The pipe has only been in use on the car for just six months. I use 91 octane gasoline in the car.
The worst 1992 Mercury Tracer problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical7
- Fuel system4
- Seat belts4
- Steering2
- Tires2
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical7
- Fuel system4
- Seat belts4
- Steering2
- Tires2
- Acceleration1
- Engine1
- Lights1
- Suspension1
- Transmission1
Recalls 1
Exterior lighting: brake lights: switch
- What is wrong
- The stop lamp switches could intermittently malfunction resulting in the stop lamps not illuminating when the brakes are applied.
- Risk
- This could result in following motorists not beingsignaled that the vehicle is braking, and could result in a collision.
- Remedy
- Replace the faulty stop lamp switches.
Recall number 92V103000 · Recall details
See all 1 recalls for the 1992 Mercury Tracer
Defect investigations
Fuel pump wiring shortage
There is no summary currently available
EA94002
Technical service bulletins for the 1992 Mercury Tracer 63
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- New transmission cooler flusher - service tips
- Climate control a/c service tech tips
- Lamp-brake-invadvertent disabling of brake shift interlock
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant...
- This aritlce is to provide information on replacement of old style hood lamp switch to the rvised...
- Brake shift interlock
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Some vehicles produced through july 1999 may exhibit rear suspension spring failure with no resulting...
- Subject pertaining to revised door latch switch service procedure
1992 Mercury Tracer fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 1.9L 4‑cyl | FWD | 22-26 | 32-33 | 26-29 |
| 1.8L 4‑cyl | FWD | 21-23 | 27-29 | 23-25 |
What 1992 Mercury Tracer owners say
Most recent owner complaints, unedited.
On my daughters 1992 mercury tracer, the ignition switch engaged the engine starter and began smoking without the key in the ignition and when no-one was in the car. I am now faced with $800.00 in repair bills for a defective ford motor company part that could have caused a serious injury or death.
Tread separation discovered accidentally per inspection for driveabiity concern. *ak (dot number: w2r4 tiresize: p195/60r14)
Fuel pump failed resulting in an electrical fire in the car. Nlm
The shoulder harness pulled from track on impact , the driver's head struck the windsheild and recevied contusions to neck and head from the loose end of the harness
Starter shorted out, causing a fire in the engine compartment. Dealer has not been contacted.
Exhaust valve broke every year, causing rear end to overheat and burn the trunk. Please provide further information.
Three occasions of sudden acceleration.
Transmission failed to engage into appropiate gear and "slipped" into neutral almost causing an accident.
There was a gas smell around the car and in the garage, dealer contacted and stated a hole found in the gas tank. Repair work done at consumer's expense.
Compare the 1992 Mercury Tracer
Other model years
Questions about the 1992 Mercury Tracer
Is the 1992 Mercury Tracer reliable?
Owners have filed 24 complaints about the 1992 Mercury Tracer, fewer than a typical Tracer model year.
What is the most common problem with the 1992 Mercury Tracer?
Electrical system, with 7 complaints. Next is fuel system (4).
How many recalls does the 1992 Mercury Tracer have?
1 recall, covering exterior lighting.
What year does the Mercury Tracer have the most electrical problems?
The Mercury Tracer model years with the most electrical complaints are 1997 (22 complaints) and 1991 (17 complaints).
What gas mileage does the 1992 Mercury Tracer get?
Official estimates for the 1992 Mercury Tracer range from 23 to 29 mpg combined. The most efficient version (1.9L 4-cyl, FWD) gets 22-26 city and 32-33 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1992 Mercury Tracer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history