The worst 2016 New Flyer XD60 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
Recalls 3
Fuel system, diesel: fuel injection system: fuel rail
- What is wrong
- New Flyer of America, Inc. (New Flyer) is recalling certain 2017-2021 XD40, XD35, 2016-2021 XD60, 2017 XDE35, 2016-2020 XDE40, XDE60 vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
- Risk
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- New Flyer will inspect the rail threads, and replace the rail as necessary, free of charge. Owner notification letters were mailed on June 28, 2021. Owners may contact New Flyer customer service at 1‑204‑224‑6706. New Flyer's number for this recall is R21-008.
Recall number 21V365000 · Recall details
Service brakes, air: disc: caliper
- What is wrong
- New Flyer of America, Inc. (New Flyer) is recalling certain 2014-2016 New Flyer XT60, 2014-2017 New Flyer XN60 and XD60, and 2015-2017 New Flyer XDE60 urban transit buses equipped with ZF Axles that have radial air disk brakes. Surface roughness of a guide pin in the radial brake calipers may cause the brake carriage guide pin support bolt to break. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
- Risk
- Breakage of the guide pin can cause a reduction of braking ability and an increase in stopping distances, or a loss of tire pressure, increasing the risk of a crash.
- Remedy
- New Flyer will notify owners, and dealers will install a bushing kit and reinstall the brake calipers, free of charge. The recall began June 29, 2018. Owners may contact New Flyer customer service at 1‑204‑224‑6706. New Flyer's number for this recall is R18-010.
Recall number 18V394000 · Recall details
Electrical system: software
- What is wrong
- New Flyer Industries Ltd. (New Flyer) is recalling certain model year 2013 C40LFR, XN35, 2014-2016 XD35, XD60, XDE40, 2015-2016 XD40, XDE60, 2014 XDE35, 2013-2015 XE40, 2013-2016 XN40, XN60, and 2014-2015 XT40, and XT60 transit buses. These buses have an Electric Transit Operator (ETO) controller that controls the bus door motor function which may have a software defect which can cause failure of the rear door guide roller linkage resulting in a bus' rear door opening unexpectedly while the bus is in motion.
- Risk
- If the rear bus door opens unexpectedly while the bus is in motion, there is an increased risk of injury for the passengers.
- Remedy
- New Flyer will notify owners, and dealers will install a firmware upgrade, and replace the roller bracket plates, free of charge. The recall began on May 4, 2016. Owners may contact New Flyer customer service at 1‑204‑224‑6706. New Flyer's number for this recall is R16-005.
Recall number 16V223000 · Recall details
Technical service bulletins for the 2016 New Flyer XD60 25
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Thermo-King has issued a Service Bulletin (SB866-1) related to the clutch bearing maintenance on their...
- Instructions to Service to remove bypassed engine calibration from ECM and replace DEF sensor as required.
- Instructions to Service to incorporate a PLC Update to prevent interlock activation when CAN speed...
- This Instruction to Service (ITS) decribes the inspection procedure required to inspect the upper bulkhead...
- Technical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support...
- This Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support...
- This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather...
- This Maintenance Instruction Describes How to Install the Optional Wheelchair Ramp Manual Extension Tool
- This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg...
- This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation...
Compare the 2016 New Flyer XD60
Other model years
Questions about the 2016 New Flyer XD60
Is the 2016 New Flyer XD60 reliable?
Owners have filed 0 complaints about the 2016 New Flyer XD60.
What is the most common problem with the 2016 New Flyer XD60?
There are not enough complaints to tell.
How many recalls does the 2016 New Flyer XD60 have?
3 recalls, covering fuel system, diesel, service brakes, air and electrical system.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 New Flyer XD60?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history