Broken crankshaft
2017 Nissan Titan engine complaints
Page 2 of 5: complaints 11 to 40 of 102, newest first, as owners wrote them.
Spun rod bearing/broken crank shaft - major vibration, loss off power, dangerous
Highway driving and lost power, started hearing engine rattle. 5.0L Cummins Diesel engine crankshaft is broken. Dealer verified it to be crankshaft. Insurance company denied a claim stating the crankshaft was manufacturer defect. Turns out that defective crankshaft was a known issue with the 2016 and 2017 Titan 5.0L engines that Cummins changed it for subsequent years. This should be a recall. I see daily the same issue on forums and groups in the USA. Thousands of us have a dead truck we are paying for in our yards.
Driving down the road, motor locked up due to crankshaft. Unable to control or restart vehicle.
Received a recall for my vehicle. Recall was pd128. Took vehicle to dealer to have recall serviced on vehicle which was for a pm sensor and reprogram the emissions control module. After recall, DEF system error code and reduce speed to 5mph showed up on truck. Went back to dealer to explain issue after the recall. They ran codes and thought it could be the DPF filter or EGR without thinking the recall could be to blame. Went to another mechanic and did a DEF system check and found no issue with system but a miscommunication with the NOx sensor. Had NOx sensor replaced and a week later had same DEF system error come on but was more intermittent and would clear on its own. Checked codes and found said miscommunication with the same NOx sensor that was replaced. Went back to the original dealer to explain the issue and believe it was due to the recall reprogram. They did a diagnostic and spoke with their own techs and said their campaign recall repair revealed a concern that was present before but did not have detection sensor or the logic to determine the issue and recommends DOC/DOF to to replaced. Contacted Nissan about the issue and if replacement would be covered due to it being tied to the recall and was told no that it is just a coincidence even though their campaign revealed there was an issue with the recall.
The truck has a broken crankshaft with only 80,000 miles on it an Nissan is aware of the defect in the engines an will not cover any repairs
Driving down the interstate at 65 mph out of the Blue Crankshaft broke. Massive steering wheel vibration hard to keep under control
Recently took the truck to get serviced a month ago. Two weeks ago I was coming back home and the motor let out and had a loud banging noise which I assumed to be a bearing or crank shaft failure. Upon getting it to a dealership they inspected it and pulled the oil pan to find metal shavings all in the turbos and oil.
The dealership said, my crankshaft broke in many places
2017 57,000 miles, Very well maintained truck with turbo actuator issues (replaced 3 times). I was driving down the highway taking my kid to practice, when the truck started to act up. I took the cruise control off and started slowing down to get to a safe place off of the highway, when the truck shut off and came to a complete stop. Oil changed every 5000 mi by myself a retired military mechanic. The engine is seized up with a broken crankshaft. =This happened while driving down a very busy highway which made pulling over almost impossible. My child could have been injured or even worse if i couldn't get to the side of the road to safety. This seems to be a very
Perfectly maintained vehicle, 68,000 mikes on the Nissan Titan XD Diesel- stock - drove it to work, then swapped with my son so he could barrow the truck as his was getting serviced- he owns a Lawncare company, he calls stating the truck lost power, started vibrating, and started banging while towing his equipment. No lights. We use a Banks Data monster- checked for codes, nothing, all temps normal - I monitor egr, engine, exhaust, and several others - all normal. Parked it - appears to be a broken crank. Just changed the oil the day prior. Been changing oil for 30+ years - always triple check levels - all correct. Use Shells best T6 fully synthetic, fleet guard filter and change every 6-7k.
Engine/Crankshaft/Main Bearing excessive noise, metal shavings in oil. Crank shaft cracked or broken. Similar to the federal safety agency PE23-020.
The bearing left go in the block causing crankshaft problems
The contact owns a 2017 Nissan Titan. The contact stated that the turbo stand, the liftgate latch, and the bolt had failed and were previously repaired. Additionally, the contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the Diesel Exhaust Fluid (DEF) system and the EGR cooler were leaking. The dealer determined that the DEF tank and the EGR cooler needed to be replaced. The vehicle was not repaired and remained at the dealer for over 6 months. The manufacturer was notified of the failure and offered to partially cover the cost of the repair. The failure mileage was approximately 109,000.
Engine locked up driving down the road. Broke crank driving 65 miles a hour.
My turbo actuator went out in 2022, paid $2,000 to get it fixed. A year later in 2023 it went out again and ruined both the low and high turbos, had to get them replaced again this time under warranty but Nissan of Dearborn in Dearborn, Michigan had my truck for 87 days before I got it back. They tried to tell me I needed a whole new engine block. I’m scared because if this happens again who is going to be held liable for it, me? Not to mention the damage it’s most likely caused on the engine block and crankshaft. The last thing I want is for that to break as I’m going down the highway.
Unknown
I have owned this vehicle since day one... this was meticulously maintained and serviced regularly. While sitting at an idle, with no prior warning, the vehicle just stopped running. After having diagnosed by a reputable diesel mechanic near me, it was determined that the CP4 fuel pump, known to be faulty in these and other trucks as well had failed. After extensive examination, it resulting in a catastrophic failure of the fuel system, ultimately requiring a $14, 000+ repair. (Unrealistic cost due to the current value of the truck being around $10k - $14k. Metal chards had been distributed all throughout the entire fuel system. This failure is unfortunately very common and Nissan or Cummins should be held accountable for this issue.
Pulled up to a stop light my truck turned off had got towed back and turner the truck on and the engine had rod nock and is over heating and not running smooth
Loss of Motive Power due to broken crankshaft with no ability to restart.
The crank shaft broke
Engine seized up on the highway in the fast lane. Broken crankshaft
Driving down the highway and the truck shut off. Pulled over and the engine will not crank. Suspect the engine is locked as the starter tries to turn over the engine but just starts to smoke due to engine not moving
2nd time this has happened.. the secondary fuel pump falls apart putting metal shavings into the engine.. therefor needing to have MAJOR REPLACEMENT OF PARTS.. unluckily I have 2 of these nissan titan xds.. and it has happened to both
The vehicle is available for inspection immediately by all parties. While driving down the highway, the truck started a vibration, without any warning indicators. The vehicle was taken to the next travel center truck shop. The writer acknowledged the vibration like a misfire, but no codes were present. He recommended another shop or dealer. A detour was made to the nearest Nissan dealership. On the way, the truck stumbled with a violent vibration and shut down on the road without warning lights. There was a complete loss of power from the engine on the highway, giving way to the risk of being hit by other motorists and blocking traffic. Since the engine shut down, there was also a loss of power steering, giving high risk to the possibility of an accident. The truck was unable to restart. The vehicle shut down in the middle of the desert, exposing my family to unsafe environmental conditions. The truck was towed the remaining way to the dealer. The next business day, the technician got the truck started and verified the concern. The tech requested additional time for teardown which was approved to remove the oil pan for inspection. I was quoted over $37,000 to repair “catastrophic engine failure.” There were metal shavings found in the oil pan “the size of a computer mouse” from somewhere on the crankshaft. The dealer found that the check engine light came on during service but did not provide the codes. Nissan refuses to assist with repair due to warranty time and secondhand ownership. Nissan was offered to inspect the vehicle but has declined.
The truck has a broken crankshaft with only 80 thousand miles on it an when it happen was driving an lost all power to everything including the power steering witch pulled me off the road without control an insurance will not cover because the same thing has happen too many other titans I added the only email the would send to us below they are trying to hide the fact they sold defective crankshafts in trucks an it coast as much to fix it as it does to buy a whole truck
My vehicle shut off mid u-turn and could have caused an accident. brought it to a nissan dealer and found that the timing chain had dropped and it needed an engine. the rest of the engine was not inspected for further damages since no matter what the engine was needed to be replaced. vehicle was very maintained and had no warning signs of engine failure.
2017 nissan titan with 5.6ltr endurance motor started knocking at or around 71k miles as with the service bulletin was taken to dealership where it was inspected and found cylinder 7 with scaring as per bulletin with replacement required to fix the cylinder issues is well known down to the years and Vin series affected with out of pocket expense of 11,500.00 for replacement. Had I been traveling I could of gotten stranded with family somewhere who knows where waiting for repairs this is such a well known issue wheres the recal
I was told by ORR Nissan in Shreveport, LA that my crankshaft failed and I need a new engine. No warnings lights, messages or symptoms. Truck just shut down at 115K miles. It was in great shape and serviced meticulously by the dealership.
Broken crank in engine
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Nissan Titan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history