2017 Nissan Titan engine problems

Filed Aug 27, 2026 · Electrical, Engine · GA

See attached document

Filed May 25, 2026 · Engine · NY

Engine is knocking at only 83k miles. No. 7 cylinder issue. Nissan won’t cover repairs even though they’re aware of the design flaw.

Filed Apr 29, 2026 · Engine, Fuel system · NC

I am submitting this complaint on behalf of the vehicle owner. On March 31, 2025 (136,962 miles), the vehicle was brought to Fred Anderson Nissan of [XXX] for Voluntary Emission Recall PD128 (NTB24-061), which required a new Particulate Matter Sensor and ECM reprogramming. One day later, the Check Engine Light illuminated. On April 2, 2025 (137,083 miles), the dealer diagnosed code P2002-00 (DPF Efficiency Below Specs). Repair Order #XXX states: "The new sensor that is now monitoring DPF is able to see this and is setting the code as designed." The dealer's own documentation confirms the fault code was triggered by the recall — not a pre-existing failure. The vehicle had no warning lights before the recall was performed. Nissan Consumer Affairs (Case #XXX) declined goodwill assistance citing mileage, without addressing the documented causal link between the recall and the fault code. The owner now faces a DPF replacement costing several thousand dollars as a direct result of complying with a manufacturer recall. Safety concern: A DPF in confirmed fault condition can trigger unexpected limp mode, including at highway speeds. If other PD128 recipients are experiencing the same recall-induced fault and cannot absorb the repair cost, those vehicles may be operating in a compromised condition. We request the federal safety agency investigate whether Recall PD128 is creating safety and repair liability for consumers who complied in good faith. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 10, 2026 · Engine · TN

Premature turbocharger failure

Filed Nov 21, 2025 · Engine · MI

I live in [XXX] . Went on vacation to visit our son outside of Nashville Tennessee. Vehicle had approximately 80,000 miles at the time. While driving in traffic and sitting still at lights and odor was coming in the cab. When I got home, I called the dealer about Catalytic converter failure possibly they told me that it was not covered that I should take it to a reputable exhaust repair shop. I took it to Callahan’s auto repair in Pontiac Michigan. They put it on the Hoist and came and told me it had a cracked exhaust manifold which the catalytic converter was attached to and that’s where the odor was coming from. When I purchased the vehicle, I have a lifetime drive caring warranty from infinity through the dealership. I called the dealership and talked to Service and they told me to bring it in while waiting for an appointment. I was due for an oil change and canceled it and looked on Google For problems with the 2017 V8 engine and found a nine page technical service report on the failure of that particular line of engine, I was never notified at any time that my engine was subject to failure, and it had been to the dealership within the last 30 days to have a new transmission pan put underneath the vehicle which Nissan paid 60% of on their own and I paid 40. Upon taking it to the dealership and leaving it, I have to pay $181 for them to analyze the problem they have verbally told me on the phone That my truck needs a new engine because there’s a lifetime warranty on the drivetrain. I don’t feel this problem should be covered under that this is a problem Nissan should put a brand new engine in my vehicle. I would like a response to this. My email is [XXX] . My telephone number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 16, 2025 · Engine · GA

My vehicle lost power driving down the road while pulling my horse trailer. The engine began to vibrate and knock then shut down completely. I did not make it off the road entirely so the police had to assist with lights to ensure other motorists would avoid collision with me. The engine will not turn over, it makes a single click and is locked up completely.

Filed Nov 4, 2025 · Engine · 30,000 miles · CO

The contact owns a 2017 Nissan Titan. The contact stated that while driving at various speeds, there was an exhaust odor entering the cabin of the vehicle. The contact was forced to lower the windows to escape the foul odor. The contact stated that the failure occurred while the vehicle was performing the DEF (Diesel Exhaust Fluid) system operation. The vehicle was taken to a dealer, where the failure was related to the windshield cowl system not properly filtering the air. The contact was provided an estimate for the repair, and declined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

Filed Sep 18, 2025 · Engine, Tires · 80,100 miles · SC

The contact owns a 2017 Nissan Titan. The contact stated that while driving at 65 MPH, the vehicle lost motive power. There was an abnormally loud sound coming from the engine. Additionally, the TPMS warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was contacted, and a case was opened. The failure mileage was approximately 80,100.

Filed Aug 17, 2025 · Engine · ND

V8 endurance engine has a known defect with scaring of cylinder 7 causing knocking in the engines and engines replacements. I purchased this Titan brand new in 2017. It required a brand new engine at 18,000 miles that was covered by the warranty. That engine developed another knock that required another engine replacement at 89,000 miles. Initially Nissan refused to cover as the truck was more than 5 years old even though the miles were well below 100,000 manufacturer warranty. I have found that these are bad engines that dealership is continue to install in these trucks even knowing that it could develop another knock. Other engine manufacturers refused to work on these engines due to this known defect. Nissan has thus far refused to recall this engine. The replacement cost is $18,000 without warranty.

Filed Jul 28, 2025 · Engine · ND

I was droving down the road with the cruise control set at 70MPH, when all of the sudden the engine lost power and stopped. It did not have a check engine light or anything on the dash to indicate that there was a problem. I coasted to the edge of the road where i attempted to restart the vehicle, but it would not even turn over. I had the vehicle towed to a repair shop where I was informed that they engine was locked solid. The mechanic suspects that they crankshaft is broken, but the entire engine will need to be replaced.