2017 Nissan Titan: engine knocking or ticking

Filed May 25, 2026 · Engine · NY

Engine is knocking at only 83k miles. No. 7 cylinder issue. Nissan won’t cover repairs even though they’re aware of the design flaw.

Filed Nov 16, 2025 · Engine · GA

My vehicle lost power driving down the road while pulling my horse trailer. The engine began to vibrate and knock then shut down completely. I did not make it off the road entirely so the police had to assist with lights to ensure other motorists would avoid collision with me. The engine will not turn over, it makes a single click and is locked up completely.

Filed Aug 17, 2025 · Engine · ND

V8 endurance engine has a known defect with scaring of cylinder 7 causing knocking in the engines and engines replacements. I purchased this Titan brand new in 2017. It required a brand new engine at 18,000 miles that was covered by the warranty. That engine developed another knock that required another engine replacement at 89,000 miles. Initially Nissan refused to cover as the truck was more than 5 years old even though the miles were well below 100,000 manufacturer warranty. I have found that these are bad engines that dealership is continue to install in these trucks even knowing that it could develop another knock. Other engine manufacturers refused to work on these engines due to this known defect. Nissan has thus far refused to recall this engine. The replacement cost is $18,000 without warranty.

Filed Jun 29, 2025 · Engine · OH

Spun rod bearing/broken crank shaft - major vibration, loss off power, dangerous

Filed Jun 6, 2025 · Electrical, Fuel system · TX

Purchased a used 2017 Nissan Titan XD Pro-4X 5.0L diesel on 3/8/25. Left the dealership and only made it ~10 miles down the road before the check engine light came on and there was a loud knocking noise. Immediately turned around and went back to the dealership. After diagnosing it I was told it was a fuel injector and that they were replacing it. Received the truck back ~3/20/25. This truck is not my daily driver but the few times I have attempted to drive it the check engine light keeps coming on and I'm getting a message about the REGEN. On 5/28/25 I had the truck towed to my local Nissan dealership. They diagnosed it and although there is still a code for the same injector coming up they said the issue is the wiring harness and quoted me $7000 to repair and it's not covered under my powertrain warranty. After research it seems like this is a common issue in 2017-2019 Nissan Titan 5.0L diesel trucks which will cause the crankshaft to break if not fixed. I am super frustrated that after less than 3 months of ownership I have an undrivable truck requiring thousands of dollars in repairs.

Filed Jun 26, 2024 · Engine, Transmission · MO

2017 nissan titan with 5.6ltr endurance motor started knocking at or around 71k miles as with the service bulletin was taken to dealership where it was inspected and found cylinder 7 with scaring as per bulletin with replacement required to fix the cylinder issues is well known down to the years and Vin series affected with out of pocket expense of 11,500.00 for replacement. Had I been traveling I could of gotten stranded with family somewhere who knows where waiting for repairs this is such a well known issue wheres the recal

Filed Jun 10, 2024 · Engine · AL

I was going down the interstate at 70 mph pulling a 6' x 10' enclosed utility trailer with furniture, when my oil pressure started to fluctuate and motor started to knock. Before I was able to stop, the motor quit and I lost all power. When I towed it to the dealer, they found crank damage and lots of bearing material along with other metal in the oil pan. The estimate to repair was almost $31,000.

Filed Mar 17, 2024 · Engine · GA

I took my Titan into the dealership due to a knocking sound in the motor. The same day Nissan service called me and said the motor has to be replaced, that the know is coming from the Crankshaft. I have 112,000 miles on my truck and have completed every service required without question at the dealership purchased from. There is no way a diesel motor crank should brake at 112,000 miles. I have contacted Nissan customer Affairs and am awaiting a reply, however after reading several forums concerning the same failure problem, I decided to voice my complaint at a higher level. I have also have had the power steering system replaced twice under warranty due to power steering Failure. Nissan has stated the repair cost under warranty would be approximately $33,000. I might as well as purchase two of these at the price it will cost me to fix.

Filed Feb 29, 2024 · Engine · CA

I was driving down the Freeway at 70mph, My truck lost power, I was in the fast lane I nearly missed a car due to my truck losing power, I pulled off to the shoulder. I noticed a knocking sound coming from my engine bay, no check engine messages appeared on my dashboard. I turned my engine off because of the noise, and had my car towed home. I have a friend who is a diesel mechanic at a Nissan dealership look at my truck and was told the engine needs to be replaced.

Filed Jan 29, 2024 · Engine · KS

Was driving down the highway at 65 mph truck started shaking I was stopping for a red light. As soon as I came to.a stop the truck started knocking shaking even worse I was barely able to get it off the road.Had truck towed to a Nissan dealer they said crankshaft broke.

Filed Nov 18, 2023 · Engine · OR

Broken crankshaft at 64000 miles. Vehicle is equipped 5.0 Cummins turbo diesel. Problem diagnosed and confirmed at dealership. No warning indicators came on just loud knock followed by immediate loss of engine power while on the highway traveling at 60 mph leaving me stranded on the side of the road with little cell reception. I have been made aware that this an ongoing problem regarding this engine and that there is an open investigation being done by Robert Caple case # pe23020

Filed Oct 17, 2023 · Engine · SC

On Friday, Oct. 6, 2023 I was driving my 2017 Nissan Titan Turbo XD that I just purchased in December 2022, it just lost power and stopped on the highway in the dark. I was able to get it to the shoulder and waited 3 hours for a tow truck. This happened on a deserted road in Washington state. I was able to get a rental car for the weekend, but the only technician qualified to look at my truck couldn't do so until Wednesday the 11th. The diagnosis was metal shavings in my engine oil, meaning I needed a complete new engine. The cost is $31,400 - and the truck cost me $37,000. Upon doing some research, I have found that the diesel fuel pump, the cp4, that comes in the Cummins diesel engine that was put into the Nissan Titans from 2016-2019 was not mean to have US diesel run through it. Only European diesel, which is more lubricated than diesel in the US. This cp4 need for lubrication makes it break apart and seize your engine up when used with US diesel. This is a known issue with the Nissan titan XD Turbo, and Nissan stopped making the truck in 2019 partly because of this issue. There has been no recall on the engine or the truck, and I could have easily been killed or seriously injured when my truck just stopped in the middle of the dark with no warning. No lights came on, nothing. I take meticulous care of my vehicles and as an Army Captain stationed at Fort Lewis, am well aware that routine maintenance is imperative. There was nothing that alerted my previous service technicians nor myself as to the danger that this truck contains. It's a ticking time bomb and needs to be taken out of use by Nissan, and their consumers compensated. How long until someone is killed due to the defect?