2004 Oldsmobile Bravada problems

What is wrong

On certain trucks and sport utility vehicles, the driver wishing to signal a turn by moving the directional signal lever, (up or down) may cause the front marker/turn lights and rear turn lights to flash in a manner similar to hazard warning, rather than flashing on the desired side only.

Risk

The driver may not be able to clearly signal their intentions to turn, change travel lanes, or potentially warn others of an impaired vehicle operating condition increasing the risk of a crash.

Remedy

Dealers will replace the suspect flasher modules with a new flasher module designed with sealed relays and more durable contact material inside of the relays free of charge. The recall began on august 4, 2005. Isuzu began mailing owner letters on august 4, 2005. Owners may contact chevrolet at 1‑800‑630‑2438, gmc at 1‑866‑996‑9463, isuzu at 1‑800‑255‑6727, buick at 1‑866‑608‑8080, and oldsmobile at 1‑800‑630‑6537.

Recall number 05V198000 · Recall details

What is wrong

On certain sport utility vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. If this occurs, the bulb may flicker and eventually become inoperative.

Risk

An inoperative brake lamp will not convey the driver's intention of stopping to drivers in following vehicles, and an inoperative rear turn signal lamp will not convey the driver's intention to turn to drivers in following vehicles. Both of these failures can increase the risk of a crash.

Remedy

Dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. The recall began on november 22, 2004. Owners should contact chevrolet at 1‑800‑630‑2438, oldsmobile at 1‑800‑630‑6537, buick at 1‑866‑608‑8080, or gmc at 1‑866‑996‑9463.

Recall number 04V527000 · Recall details

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at under the identification numbers in the attached document.

RQ17002

During the course of this ea investigation, odi observed that the majority of the complaints (88%) and warranty claims (94%) were reported for vehicles that are registered for use in the salt belt region of the us.this area includes 20 states in the northeast, mid atlantic and the midwest regions and the district of columbia.consumers in the salt belt region reported to odi that they could smell fuel vapors in their vehicles while driving.upon further examination of their vehicles, they discovered that fuel vapors were coming out of the top of the fuel tank. This condition is caused by corrosion of the return and sender lines of the fuel pump module.water and road salt collect on top of the fuel pump leading to small pinholes appearing on the fuel lines.fuel may leak and collect on top of the module and/or spill onto the ground.the data evaluated under this investigation reflect a relatively low frequency of occurrence that largely arises in salt belt states.gm has extended the warranty on the subject component to ten years or 120,000 miles.further use of agency resources does not appear to be warranted at this time; accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.for additional information select document search.

EA07009

Gm states that some brake/tail lamp bulbs can prematurely become inoperative due to malfunctioning brake/tail lamp sockets.on march 2, 2004, gm initiated a 6-year/72,000 mile special policy for 989,487 subject vehicles to inspect and replace the rear brake/tail lamp bulb socket assemblies.on april 4, 2004, the office of defects investigation (odi) opened a preliminary evaluation (pe04-032) based on consumer complaints alleging brake lights not operating when the brake pedal is depressed.on august 3, 2004 odi upgraded pe04-032 to an engineering analysis (ea04-021).by letter dated october 27, 2004 gm notified the federal safety agency that it will conduct a safety recall (the federal safety agency # 04v527) covering subject vehicles that were not already repaired under gm's special policy.my 2004 subject vehicles built after august 8, 2003 contain improved brake lamp assemblies and are not included in the recall.gm dealers will install the improved brake lamp assembly on subject vehicles built on august 8, 2003 and earlier.the action taken by gm is sufficient to resolve the issues raised by this investigation.accordingly, this investigation is closed.

EA04021