The worst 2005 Orion V problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
Recalls 5
Electrical system
- What is wrong
- Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat.
- Risk
- Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
- Remedy
- DBNA will notify owners and Sure Power representatives will change out the equalizer and/or convertor, free of charge. The recall is expected to begin during November 2014. Owners may contact DBNA at 1‑905‑403‑1111.
Recall number 13V476000 · Recall details
Engine and engine cooling: engine: other fuel types: turbo/supercharger
- What is wrong
- Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.
- Risk
- Failure of the turbine or compressor wheel may result in smoke, fire, and stalling, increasing the risk of a crash.
- Remedy
- DBNA will notify owners. The remedy for this issue is still under development. The safety recall began on September 28, 2012. Owners may contact Daimler Buses North America at 1‑800‑882‑8054.
Recall number 12V447000 · Recall details
Power train: clutch assembly: pedal/hand lever(motorcycle)
- What is wrong
- Daimler buses is recalling certain orion transit buses equipped with the morse remote throttle control. The morse remote throttle control panel is located in the engine compartment and a switch on it is labeled, "throttle"; "off" or "front" and "on" or "rear" selecting the active engine control station. If a person operating the engine from the "rear" position (at the engine) fails to place the switch in the "off" or "front" position and the engine RPM was set to above idle during maintenance for example, when the bus is started from the driver's station the engine could change to the higher RPM resulting in unwanted engine power.
- Risk
- The bus could accelerate at a higher rate than anticipated increasing the risk of a crash.
- Remedy
- Daimler will provide instructions to modify the wiring to the morse throttle control switch. This service will be performed free of charge. The safety recall began on april 1, 2010. Owners may contact daimler buses at 1‑800‑716‑7466.
Recall number 10V015000 · Recall details
Equipment adaptive/mobility
- What is wrong
- Daimler buses is recalling certain model year 2000 through 2008 orion transit buses equipped with lift-u wheelchair lifts. The lifts are equipped with a logic board assembly for the wheelchair lift control box, p/nos. 373-0226 and 373-0265. The outboard ramp barrier could fold in toward a lift passenger and pinch, press, or crush the passenger's feet.
- Risk
- The lift passenger could be seriously injured.
- Remedy
- Orion will notify owners and the repairs will be made by lift-u free of charge. Please see lift-u's defect report 09e-051. The safety recall began on october 29, 2009. Owners may contact lift-u at 1‑209‑838‑2400 or orion at 1‑800‑716‑7466.
Recall number 09V412000 · Recall details
Interior lighting
- What is wrong
- Daimler buses of north america is recalling certain model year 2002 through 2009 orion transit buses equipped with luminator horizon LED side destination signs. The connector board can corrode due to an accumulation of moisture under the connector.
- Risk
- A short could occur, possibly causing smoke and a fire.
- Remedy
- Orion will notify owners and the buses will be repaired by luminator free of charge. Please see luminator's defect report 09e-054. The safety recall is expected to begin during november 2009. Owners may contact luminator at 1‑972‑516‑3033 or orion at 1‑800‑716‑7466.
Recall number 09V413000 · Recall details
Technical service bulletins for the 2005 Orion V 9
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
Compare the 2005 Orion V
Other model years
Questions about the 2005 Orion V
Is the 2005 Orion V reliable?
Owners have filed 0 complaints about the 2005 Orion V.
What is the most common problem with the 2005 Orion V?
There are not enough complaints to tell.
How many recalls does the 2005 Orion V have?
5 recalls, covering electrical system, engine and engine cooling and power train.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Orion V?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history