1998 Plymouth Voyager technical service bulletins
120 technical service bulletins and manufacturer communications cover the 1998 Plymouth Voyager.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number
- Charging System, Battery Diagnostic Tools and Warranty
- Repair Parts Used For Structural Repairs
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- Valve Body
- Snow/water ingestion into rear brake drum
- Snow/water ingestion into rear brake drum
- Pop/tick sound in steering wheel area
- Cosmetic corrosion or perforation at upper strut tower/s usually between the strut and upper load path...
- Snow/water ingestion into rear brake drum
- Concerns with the air bag warning indicator lamp on intermittently or constantly
- Flash programming failure recovery
- Subject regarding outside rearview mirror glass replacement
- Experiencing a pop/tick sound heard coming from the steering wheel area while the vehicle is in motion
- Subject regarding transmission oil cooler line hose clamp service
- Subject regarding camshaft / bearing service
- Subject regarding outside rearview mirror glass replacement
- Experiencing a squawk / creak / groan sound from front suspension while driving over rough / bumpy roads
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty
- Subject regarding generic scan tool (GST), publication no
- A condition may exist where a low frequency howl / moan noise is heard from the rear brake area during low...
- On some vehicles, while driving through deep or blowing snow / water, the snow / water may enter the rear...
- This bulletin involves installation of a new component to assist cam seal retention
- Subject regarding wire splice repairs
- Subject regarding outside mirror glass replacement
- Subject regarding child seat tether anchors
- Experiencing a chatter sound coming from the sliding door power lock actuator(s) when the power lock...
- Information regarding updates to the fuel system service procedures
- Subject regarding non-deployed airbag handling procedures
- A condition exist where the roof panel surface exhibits waviness or depression(s) near the front of the...
- This bulletin contains procecures to remove waviness or depressions from the roof panel surface
- This bulletin provides a revised wire splice procedure and related parts
- A condition where a click / rattle sound may be heard coming from the area of the steering wheel while the...
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes P1494, P0442...
- Concerns with the pcv valve freezing under extremely cold conditions
- Information regarding snow / water entering the rear brake drums
- Vehicle operator may complain of poor AM radio reception
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles
- Information on rear wheel park brake actuator / lever service
- Subject on the child seat tether anchors
- Technical service bulletin regarding multi-layer steel (MLS) head gasket installation procedures
- Intermittent malfunction indicator light (MIL) illumination with hex code $1B (P0123) throttle position...
- Information regarding the ignition switch housing service
- This bulletin announces the availability and installation of a resuable automatic transmission oil pan gasket
- Information on child seat tether anchors
- Concerns with speed control which does not maintain set speed while climbing a grade
- Experiencing vibration / buzz in the accelerator pedal at 2200 - 2500 RPM and above 3500 RPM
- This bulletin explains the operation and application of the leak detection pump (LDP) monitor test
- Experiencing tick type noise at top of left b-pillar
- Concerns with serpentine belt slipping off idler pulley
- Subject pertaining to smooth road high-speed vibration or shake condition
- Customer may complain of low speed tire wobble
- Conditions with intermittent loss of speed control
- Subject regarding reusable automatic transmission oil pan gasket
- Concerns with sags / hesitation / stumble / start & stall, a/c bump improvements, addition of leak...
- Service and parts information on 1999 running changes to transmission range sensor (TRS) tt
- Concerns with front and / or sliding door power lock motors making a whirling noise
- Emissions recall -- vehicle emission control information (VECI) label replacement
- Subject pertaining to a ticking type noise at top of left b-pillar
- Subject regarding airbag on - off switches
- Subject regarding oil seepage at cam position sensor / misinterpreted head gasket leak
- Windnoise around fron door glass, especially at top of the b pillar
- Vehicle experiencing a ticking noise while at idle from engine
- A new multi-layer steel ( mls ) head gasket has been developed and is being implemented into production...
- Subject regarding i/m ( inspection maintenance ) testing - OBD II "carb" readiness monitor information
- A squeaking / chirping noise is heard ( inside or outside the vehicle ) from the strut tower area( s )
- Subject regarding body control module auto headlamp sensor/ signal circuit diagnostic trouble code (DTC)
- Subject on flash programming failure recovery
- Subject regarding the airbag on-off switches
- A "honk" or squeal noise during parking lot maneuvers
- Rattle noise from rear of the vehicle when driving over road bumps
- Condition with a/c compressor lock-up at low mileage
- Exhibiting a moaning and groaning sound accociated with a/c compressor operation
- The front door body mounted weaterstrip falls off mounting flange, usually along the top of the door opening
- Subject regarding a/c suction and / or discharge line requires replacement due to cracking at or near...
- Symptoms with roof rack rattles at highway speeds
- Perceived loss or cahnge of radio station presets
- Subject on labor operation time change for domestic 2.OL dohc and 2.4L head gasket replacement
- Conditions with a/c compressor lock-up at low mileage
- Information on body control module (BCM) replacement
- During low speed vehicle experiences side to side oscillation/wobble while driving between 10-45MPH
- Subject on delayed transaxle engagement
- Information on installation of radio transmitting equipment
- Some vehicles may produce a high pitched whistle noise during wide open throttle acceleration
- Some vehicles may experience a condition where the valve train makes a tapping noise
- Information on removal of the exhaust drone
- Subject on tip-in sags/hesitations or rough idle after a hot soak restart
- Condition with the software within the powertrain (PCM) may not operate the solid state relay for the...
- Information on vehicle aluminum wheels having a unique balance weight retention flange
- Subject on transaxle desensitization to intermittent faults / driveability improvements
- Discussion: containing after market steering column mounted anti-theft devices
- Subject regarding improper cooling fan relay actuation
- Information on gasket surface preparation on aluminum engine components
- This bulletin involves intermittent popping on front end
- This bulletin involves seat back creak noise - drivers side
- Information on body control module auto headlamp sensor/signal circuit diagnostic trouble code (DTC)
- Creak sound heard upon acceleration and/or deceleration- sound seems to come from floorpan/dash area
- Concerns with "honk" noise during parking lot maneuvers
- Test
- Vehicle may experience remote keyless entry transmitter batteries discharge prematurely
- Information on poor drivability with high di (drivability index) fuel
- Concerns of thumping noise from the rear jounce bumpers when driving over small bumps after the vehicle...
- Concerns with thumping noise at rear of vehicle during cold operation
- Exhibiting a periodic bump in power train when the a/c is operating
- Some vehicles experience a momentary loss of power assist for the steering when turning corners with the...
- Owner's manual addendum providing additional information on how to identify thos eminivans that CAN be...
- Some vehicles may have a marginal or partial bond of the backlight to the liftgate that may develop into a...
- Authorized airbag deactivation for medical necessity
- INFORMATION REGARDING the federal safety agency AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. NLM
- Water leaks onto the passenger side floor from the HVAC housing
- Concern with water leak onto the passenger side floor from the HVAC housing
- Concerns with a/c evaporator odor
- During high humidity climate conditions, some vehicles may experience a momentary loss of power assist for...
VIN decoder
See the problems and recalls for an exact car
Buying a used 1998 Plymouth Voyager?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history