1. Fuel Leak 2. Fuel leaking in driveway, car has potential to catch fire if driven 3. Suspected leak and odor was reported 4 years ago. Dealer said the recall did not apply to my car. After receiving an email reply back from GMLegalUpdate department indicating they would cover the "fuel line" under special coverage, the dealer looked at the car. Dealer said they couldn't find any leak. Now the leak is very apparent when you start the car. Significant gas leaks onto the ground. After speaking to GM at 866‑790‑5600, GM says that my VIN No does not apply to the special coverage. Now they won't honor the letter. A service bulletin 12191B has been issued for this problem "regardless of the vehicle's age or mileage" but it seems from numerous posts GM pawns this problem off as the car's Vin No does not apply to their vehicle.
Pontiac G5 fuel leak problems
67 of the 381 owner complaints about the Pontiac G5 describe fuel leak, most of them for the 2007 model year.
- owner complaints
- 67
- worst model year
- 2007
- typical repair cost reported
- $700
- typical mileage
- 89,000
By model year
Often reported together
What owners say
Fuel leaking which appears to be on top of fuel tank. Smell of gas is present inside and outside of vehicle.
My 2009 Pontiac G5 was driven to work this morning 6-10-21and parked in a Michigan State vehicle garage. Security notified me at work that my vehicle had a puddle of gas under and near a rear tire. I removed vehicle frome parking garage and parked it in a remote open parking lot. A gas leak in a car is dangerous, and a safety issue for me and others , especially in a parking garage!!! The vehicle has always been maintained as I am the original owner of the car. The car will be delivered to the dealer for inspection on 6/14/21. There are no recalls on this car . Opon my own investigation after the incident, there are numerous complaints logged into the federal safety agency of a rust issue of the fuel line where it is clamped near the fuel tank. There is also reports of crack developing at the intank fuel pump connection. ALL Cobalts,G5 's and other variations of this vehicle should be recalled immediately and inspections of the fuel system be reported back to the federal safety agency. Was there a fire? My answer is "NOT YET".
Fuel line leakage - gas leaks out quickly until the tank is empty. The car is undrivable in this condition, which seems to be a hugely common problem with the 2009 pontiac g5. A massive gas leak is a safety concern.
Leaky fuel lines toward the left rear wheel well. Large puddles of gasoline under the car when parked. Visible gas leak
Fuel leaking from fuel lines on driver side just in front of rear wheel well.
Fuel leaking from the fuel line on the driver side.
Fuel lines corroded at left rear wheel causing a major fuel leak.
Fuel leak. Over drivers side rear wheel . Fuel feed line in area covered with moon tape behind heat shield. Previously reported a fuel leak on feed line just beyond the fuel filter. Now have two fuel leaks. Fuel return line also looks corroded .
Fuel line is leaking over drivers rear wheel ( forward of fuel filter) fuel leaks when car is running and continues to leak until fuel line is empty.
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
- Risk
- Fuel leakage in the presence of an ignition source may result in a fire.
- Remedy
- GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1‑800‑521‑7300.
Recall number 12V459000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General motors is recalling certain model year 2006 chevrolet cobalt and saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 chevrolet cobalt, pontiac g5 and saturn ion vehicles originally sold in or currently registered in the states of arizona, california, florida, nevada and texas. The plastic supply or return port on the modular reservoir assembly may crack. If either of these ports develops a crack, fuel will leak from the area. If the crack becomes large enough, fuel may be observed dripping onto the ground and vehicle performance may be affected.
- Risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina, tennessee and texas and model year 2007 vehicles registered in: alabama, arkansas, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina and tennessee. The safety recall is expected to begin on or before february 4, 2010. Owners may contact chevrolet at 1‑800‑630‑2438, saturn at 1‑800‑972‑8876 and pontiac at 1‑800‑620‑7668 or at the owner center at www.gmownercenter.com.
Recall number 09V419000 · Recall details
Questions about the Pontiac G5 fuel leak
Which Pontiac G5 years have fuel leak problems?
The model years with the most reports are 2007 (33 complaints), 2009 (19 complaints) and 2008 (15 complaints).
How much does it cost to fix fuel leak on the Pontiac G5?
Owners who mentioned a price put the repair at about $700 (median of 5 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Pontiac G5?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history