My 2009 Pontiac G5 was driven to work this morning 6-10-21and parked in a Michigan State vehicle garage. Security notified me at work that my vehicle had a puddle of gas under and near a rear tire. I removed vehicle frome parking garage and parked it in a remote open parking lot. A gas leak in a car is dangerous, and a safety issue for me and others , especially in a parking garage!!! The vehicle has always been maintained as I am the original owner of the car. The car will be delivered to the dealer for inspection on 6/14/21. There are no recalls on this car . Opon my own investigation after the incident, there are numerous complaints logged into the federal safety agency of a rust issue of the fuel line where it is clamped near the fuel tank. There is also reports of crack developing at the intank fuel pump connection. ALL Cobalts,G5 's and other variations of this vehicle should be recalled immediately and inspections of the fuel system be reported back to the federal safety agency. Was there a fire? My answer is "NOT YET".
Pontiac G5 fuel pump problems
56 of the 381 owner complaints about the Pontiac G5 describe fuel pump failure, most of them for the 2007 model year.
- owner complaints
- 56
- worst model year
- 2007
- typical repair cost reported
- $630
- typical mileage
- 90,000
By model year
Often reported together
What owners say
Around 127000 miles I noticed a strong smell of gasoline, and a small drip from under my car, after taking a closer look I noticed that it was gas, and it was coming from the retaining clip that holds the fuel/brake lines in place, I was not financially stable to have this repaired at the time, and it wasn't leaking to bad so I left it go, after about 2-3 more weeks I was driving and noticed that I could literally see my fuel gauge dropping, I immediately pulled over and inspected the problem area and see that the car was dumping fuel and a very high pressurized rate, I also took note that the gas was being sprayed onto the hot exhaust that is about 4-6? Away from the fuel lines, I got the car home and parked it, after doing hours of research I seen that 95% of this year and model of gm have this issue due to the heat shielding on the fuel lines after searching my VIN it says that my vehicle has no active recalls but I've seen complaint after complaint about this issue, not only that it is extremely dangerous that gas is being stayed out under pressure which is causing it to vaporize and become even more of a fire hazard, not to mention it is inches away from the exhaust and directly below the fuel tank... This issue should defiantly be addressed with gm and be submitted for recall in my opinion, this issue only happens when the vehicle is on or the key is turned to the on position and the fuel pump is primed and running to charge the fuel lines, after the vehicle is turned off the leak stops after the fuel line has drained onto the ground causing another fire hazard and a environmental hazard making it an issue to start the car again due to no gas being in the lines, in my case I have to turn the key to on and give the fuel pump about 15 seconds to prime and pump gas into the lines, this issue has made it impossible to drive as I dump a gallon of fuel every 2-3 miles.
Leak at fuel line at holding clip right after gas tank. When key is turned on and fuel pump start to run. Had the same problem with a 2006 cobalt 2 years ago. It is like the same car
My 2008 g5 has a strong gas smell both inside and outside the car. I checked for recalls and saw that 2008 g5's have been recalled for a fuel leak due to a defective fuel pump module but only in hotter states. I'm in sc and we certainly should qualify as a hotter state with temps in the upper 90's in the spring. Gm recalled the '06 and '07 g5's in sc for fuel leaks so they should recall the '08 model too since it has the same problem (recall 09v‑419) my car has only 31,903 miles on it so I should not be stuck with the cost of repairing an ongoing fuel leak problem that gm has had with '06-'08 models. My mother bought this car new from the dealership and it has been garage kept and driven very little. Gm should repair all the 2008 g5's that are leaking fuel, not just the ones in a select few states. Fuel leaks are dangerous and could result in a fire in any state.
Tl* the contact owns a 2009 pontiac g5. The contact smelled a fuel odor after driving the vehicle and noticed fuel leaking from the fuel pump. The contact stated that the vehicle experienced the same symptoms as listed in the federal safety agency campaign number: 12v459000 (fuel system, gasoline). The vehicle was not taken to a dealer to be diagnosed or repaired. The manufacturer was notified and stated that nothing could be done. The failure mileage was approximately 140,000.
Tl* the contact owns a 2009 pontiac g5. While driving various speeds, a fuel odor emitted through the vents. An independent mechanic inspected the vehicle at the contact's residence and diagnosed that fuel was leaking from either the fuel pump or the fuel tank. The vehicle was not taken to a dealer. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 97,000.
Hi! I noticed very strong gas fumes after filling my car with gas. I took the car to the dealer on friday, september 22, 2017 and had the fuel pump replaced, after filling my car with a tank of gas, I noticed strong fumes in the car. I noticed the fuel needle went from 401 miles to 388. I drove home parked my car in the garage moments later my daughter arrived home and began complaining about the strong gas fumes in the garage and gas leaking underneath my car. I got out of bed went into the garage, then I smelt heavy gas fumes and saw the gas on my garage floor. I backed the car out of the garage and left the garage door open.
Cracked fuel return line at fuel pump. This issue was reported and recalled on the 2007, 2008, and some 2009 g5 models. Symptoms: when the car is shut off, fuel starts dripping onto the garage floor from the rear of the car.
Tl* the contact owns a 2007 pontiac g5. The contact noticed strong fumes of fuel and a fuel pump leak. The vehicle was excluded from the federal safety agency campaign numbers: 12v459000 (fuel system, gasoline) and 09v419000 (fuel system, gasoline). The manufacturer was notified of the failure and provided no solution. The failure mileage was not available.
Fuel line rusted out causing fuel leakage. The bracket that holds fuel lines also retains salt and brine deposits and is of poor design causing fuel lines to rust through one spot only. It is located a foot in front of rear driver side tire underneath. About a inch away from exhaust. Fuel pours out a steady drop and puddles underneath hot exhaust. This is not the fuel pump recall problem already listed. Repair costs $951.87 at dealership. Looking underneath car all the line was rust free except this fuel bracket area. This is very dangerous to have fuel leaking on to pavement and under hot exhaust. As gas evaporates its fumes could start a fire. A person may drive for many miles without noticing the fuel leaking. The gas fumes enter the inside of car. If a person smokes this could also cause explosion all from poor design and no recall to replace fuel line and bracket. The fuel leak is constant stationary, in motion on street and highway. This is very dangerous.
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
- Risk
- Fuel leakage in the presence of an ignition source may result in a fire.
- Remedy
- GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1‑800‑521‑7300.
Recall number 12V459000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General motors is recalling certain model year 2006 chevrolet cobalt and saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 chevrolet cobalt, pontiac g5 and saturn ion vehicles originally sold in or currently registered in the states of arizona, california, florida, nevada and texas. The plastic supply or return port on the modular reservoir assembly may crack. If either of these ports develops a crack, fuel will leak from the area. If the crack becomes large enough, fuel may be observed dripping onto the ground and vehicle performance may be affected.
- Risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina, tennessee and texas and model year 2007 vehicles registered in: alabama, arkansas, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina and tennessee. The safety recall is expected to begin on or before february 4, 2010. Owners may contact chevrolet at 1‑800‑630‑2438, saturn at 1‑800‑972‑8876 and pontiac at 1‑800‑620‑7668 or at the owner center at www.gmownercenter.com.
Recall number 09V419000 · Recall details
Questions about the Pontiac G5 fuel pump
Which Pontiac G5 years have fuel pump failure problems?
The model years with the most reports are 2007 (35 complaints), 2008 (13 complaints) and 2009 (8 complaints).
How much does it cost to fix fuel pump failure on the Pontiac G5?
Owners who mentioned a price put the repair at about $630 (median of 7 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Pontiac G5?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history