Pontiac Montana recalls

What is wrong

The braun corporation has notified the federal safety agency about a defect in certain model year 2005-2008 general motors mobility conversion, handicapped accessible low floor minivans. During conversion, the driver or passenger side trailing arm modification may not have been adequately welded.

Risk

A squeaking or clunking noise may develop. The trailing arm bushings may prematurely wear and the trailing arm may fracture or separate, allowing the rear axle to become partially separated from the chassis increasing the risk of a crash.

Remedy

Dealers will inspect and will have a supply of retrofit parts available to remedy the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun at 1‑800‑488‑0359.

Recall number 10V110000 · Recall details

What is wrong

On certain vehicles, variations in the manufacturing process or exposure to high ambient temperatures may lead to fracture of the fuel tank inlet check valve (icv).

Risk

A fracture may allow fuel vapors to pass through and allow droplets of fuel to accumulate on the side of the fuel tank. Fuel leakage, in the presence of an ignition source, could result in a fire.

Remedy

Dealers will replace the fuel tank. The recall will be mailed in two phases with the first phase beginning on december 4, 2007. The second phase will be mailed on december 13, 2007. Owners may contact buick at 1‑866‑608‑8080; chevrolet at 1‑800‑630‑2438; or pontiac at 1‑800‑620‑7668. The vehicle population includes buick rendezvous and pontiac aztek vehicle built in may 2003; chevrolet venture and pontiac montana vehicles built from june through august 2002; and all vehicles registered in nevada, arizona, virgin islands, puerto rico, and hawaii.

Recall number 07V349000 · Recall details

What is wrong

Certain vehicles originally built with cloth seats that were equipped with an automatic air bag passenger sensing system and later reupholstered with aftermarket leather seat cover kits are involved. Testing has indicated that the aftermarket leather seat covers can cause the passenger sensing system to malfunction.

Risk

If the passenger sensing system malfunctions, the front air bag on the passenger side may be disabled when it should be enabled, or enabled when it should be disabled. In either case, in the event of a crash that requires air bag deployment, a front passenger's level of injury may be increased.

Remedy

Because a replacement leather seat cover that is compatible with the passenger sensing system is not available, general motors (gm) will repurchase these vehicles in accordance with the terms stated in gm's letter to owners. The recall began on november 6, 2006. Owners should contact gm at 1‑877‑477‑1022 to begin the process of repurchasing their vehicle.

Recall number 06V417000 · Recall details

What is wrong

Certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight.

Risk

A misprinted label could lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash.

Remedy

Owners will be provided with corrected labels and installation instructions. At the customer's option, a dealer can install the label for them. The recall began on march 31, 2006. Owners may contact buick at 1‑866‑608‑8080, cadillac at 1‑866‑982‑2339, chevrolet at 1‑800‑630‑2438, gmc at 1‑866‑996‑9463, hummer at 1‑800‑732‑5493, pontiac at 1‑800‑620‑7668, saturn at 1‑800‑972‑8876, or isuzu at 1‑800‑255‑6727.

Recall number 05V552000 · Recall details

What is wrong

Certain sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 135, 'passenger car brake systems.' to meet the standard, the vehicle must not move for five minutes when stopped on a steep hill with the parking brake applied and the vehicle in neutral (n). Some of these vehicles failed this test.

Risk

When the parking brake is released, the driver may notice unintended braking when accelerating, decelerating, or coasting, and a noise coming from the rear of the vehicle. Unintended vehicle movement could occur increasing the risk of a crash.

Remedy

Dealers will inspect for parking brake lever slippage at each rear brake caliper and replace the caliper if lever slippage is identified. The recall began on november 14, 2005. Owners may contact buick at 1‑866‑608‑8080, chevrolet at 1‑800‑630‑2438, pontiac at 1‑800‑620‑7668, or saturn at 1‑800‑972‑8876.

Recall number 05V287000 · Recall details

What is wrong

On certain minivans, the outboard release handle on the impact-side second-row bucket seat may be actuated and the rear latches may unlatch early in a side impact crash. This was discovered in a side impact test run by gm, under conditions similar to the federal safety agency's new car assessment program (ncap) side impact test.

Risk

If the rear latches of the seat release early in a severe side impact, the front outboard latch may disengage and increase the potential for injury to the occupant of the seat.

Remedy

Dealers will remove the seat latch release handle and install a black plastic cap over the exposed metal stud to eliminate the side impact safety concern free of charge. The recall began on april 5, 2005. Owners may contact saturn at 1‑800‑972‑8876, chevrolet at 1‑800‑630‑2438, and pontiac at 1‑800‑620‑7668.

Recall number 05V061000 · Recall details

What is wrong

On certain minivans equipped with second-row bucket seats or captain's chairs and a power sliding door on the passenger side of the vehicle, a passenger using the interior handle to open the power sliding door could be injured.

Risk

If a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm may be pushed into the seat back or armrest and a wrist or lower arm injury may result.

Remedy

Dealers will replace the power sliding door interior handle on the passenger-side. If the vehicle is equipped with a power or manual sliding door on the driver-side, the interior handle will also be replaced for appearance reasons. Note: before the vehicle is serviced, gm advises owners to not use the interior door handle to open the door. The driver can open and close the door from switches at the driver's position or by using the remote key fob. The driver should tell passengers to use the switch located in front of the door to open or close it. The driver should use the override switch to prevent operation of the power door by children or by others who are not familiar with its use. The owner notification letter mailing will be conducted in phases with the first phase beginning on may 31, 2005. The second phase mailing began on july 18, 2005. The recall began on may 31, 2005. Phase 2 began on july 18, 2005. Phase 3 (final phase) began on august 24, 2005, to all remaining customers. Owners should contact chevrolet at 1‑800‑630‑2438; pontiac at 1‑800‑620‑7668; or oldsmobile at 1‑800‑630‑6537.

Recall number 04V597000 · Recall details

What is wrong

Certain minivans fail to conform to the requirements of federal motor vehicle safety standard no. 213, "child restraint systems." these vehicles do not have text and formatting on the warning label attached to the available second-row integral child restraint as specified by amendments to the standard.

Remedy

Owners will be provided with replacement labels and installation instructions. Owner notification began on july 23, 2004. Owners should contact chevrolet at 1‑800‑630‑2438 or pontiac at 1‑800‑620‑7668.

Recall number 04V177000 · Recall details

What is wrong

Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system.

Risk

This does not meet the requirements of the standard.

Remedy

Owners will be provided with a supplement for their owner's manual. This supplement describes and shows the location symbols for the child restraint anchors that are located in the vehicle and on the child restraint or booster cushion. Owner notification began august 18, 2003. Owners should contact buick at 1‑866‑608‑8080, cadillac at 1‑866‑982‑2339, chevrolet at 1‑800‑630‑2438, gmc at 1‑866‑996‑9463, pontiac at 1‑800‑620‑7668, or oldsmobile at 1‑800‑630‑6537.

Recall number 03V250000 · Recall details

What is wrong

On certain mini vans, passenger and sport utility vehicles, some of these vehicles have a driver's side air bag that may not deploy as designed. In addition, the air bag inflator could rupture.

Risk

This could result in reduced capability of the air bag to protect the driver. Also if the air bag inflator ruptured, pieces of the inflator could strike and injure the vehicle occupants.

Remedy

Dealers will inspect, and if necessary, install a new driver's air bag. Owner notification began on march 11, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1‑800‑521‑7300, cadillac at 1‑800‑458‑8006, chevrolet at 1‑800‑222‑1020, gmc at 1‑800‑462‑8782, or pontiac at 1‑800‑762‑2737.

Recall number 03V051000 · Recall details

What is wrong

On certain passenger, sport utility vehicles and mini vans, some of these vehicles have a passenger air bag that was manufactured without a check valve pin. An air bag without the check valve pin could produce increased pressure at the onset of the air bag deployment and reduced pressure afterward.

Risk

This could increase the severity of injury to a person who was not properly restrained and who was close to the passenger air bag at the time of deployment. It could also reduce the ab8ility of the air bag to protect a restrained front seat passenger.

Remedy

Dealers will inspect and, if necessary, replace the passenger air bag. Owner notification began december 16, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1‑800‑222‑1020, pontiac at 1‑800‑762‑2737, oldsmobile at 1‑800‑442‑6537, or saturn at 1‑800‑553‑6000, prompt #3.

Recall number 02V329000 · Recall details

What is wrong

Certain passenger, mini vans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment.

Risk

Pieces of the inflator could strike and injure vehicle occupants and the air bag cushion would not inflate fully, reducing the capability of the bag to protect the driver.

Remedy

Dealers will inspect, and replace, if necessary, the air bag module assembly on the driver's side. Owner notification began august 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1‑800‑521‑7300, cadillac at 1‑800‑458‑8006, chevrolet at 1‑800‑222‑1020, gmc at 1‑800‑462‑8782, oldsmobile at 1‑800‑442‑6537, or pontiac at 1‑800‑762‑2737.

Recall number 02V222000 · Recall details

What is wrong

On certain passenger vehicles and mini vans, the driver's air bag inflator modules could produce excessive internal pressure. In the event of a crash that would trigger a driver's air bag deployment, the increased internal pressure can cause the inflator module to explode.

Risk

Metal and plastic debris could cause severe injury to vehicle occupants.

Remedy

Dealers will replace the driver air bag module. Owner notification began february 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact pontiac at 1‑800‑762‑2737.

Recall number 02V027000 · Recall details

What is wrong

Vehicle description: certain mini vans built with second row 50/50 split bench seats or captain's chairs, fail to comply with the requirements of fmvss no. 225, "child restraint anchorage systems." the seat latch anchor wire diameter is greater than 6.1 mm.

Risk

If the connector for a latch-type child restraint is not attached correctly to the anchorage points, the restraint will not properly protect a child in the event of a crash.

Remedy

Dealers will inspect the latch anchor wires and repair those with an improper diameter. Owner notification began april 10, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1‑800‑222‑1020, oldsmobile at 1‑800‑442‑6537, or pontiac at 1‑800‑762‑2737.

Recall number 01V383000 · Recall details

What is wrong

Vehicle description: 1997-2001 chevrolet venture, pontiac montana/transport, and oldsmobile silhouette mini vans equipped with passenger side power sliding doors that were serviced in campaign 01013 (01v‑067) from april to august 2001. Also 2001 chevrolet venture, pontiac montana, and oldsmobile silhouette mini vans equipped with passenger side power sliding doors assembled in january through april 2001. These vehicles have inadequate front welds. If a front weld fails, the actuator can jam in the unlatched position and, when the sliding door closes, it will not be latched.

Risk

If this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface. An unrestrained occupant could fall out of the van and be injured.

Remedy

Dealers will inspect and, if required, install a new power sliding door unlatch actuator assembly. Owner notification began on october 22, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1‑800‑222‑1020, pontiac at 1‑800‑762‑2737, or oldsmobile at 1‑800‑442‑6537.

Recall number 01V264000 · Recall details

What is wrong

Vehicle description: minivans equipped with passenger side power sliding doors. The door closes but may not be latched. If this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface.

Risk

An unrestrained occupant could fall out of the van and be injured.

Remedy

Dealers will install a new un-latch actuator assembly to the power sliding door. This recall has been continued under safety recall 01v‑264. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1‑800‑222‑1020, pontiac at 1‑800‑762‑2737, or oldsmobile at 1‑800‑442‑6537.

Recall number 01V067000 · Recall details

What is wrong

Vehicle description: passenger, sport utility vehicles and minivans. The passenger air bag inflator modules were built without the correct amount of generant, which produces the gas that fills the air bag. Some were built with a double load of generant and some were built without generant.

Risk

In the event of a crash that would trigger a passenger air bag deployment, a double load of generant can cause the inflator module to explode. If the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupant. A module with no generant would not inflate the air bag, and the occupants could receive more severe injuries.

Remedy

Dealers will replace the passenger air bag module. Telephone calls were made to owners on january 29, 2001. Follow up owner mailing began on april 17, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1‑800‑222‑1020, pontiac at 1‑800‑762‑2737, or saturn at 1‑800‑553‑6000.

Recall number 01V026000 · Recall details

What is wrong

Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."

Risk

In the event of a vehicle crash, the occupant may not be properly restrained.

Remedy

Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.

Recall number 00V228003 · Recall details

What is wrong

Vehicle description: mini vans with extended wheelbase. Some of these vehicles have inoperative fuel tank rollover valves and fuel leakage would exceed the permissible amount in a rollover test. This does not comply with the requirements of fmvss no. 301, "fuel system integrity."

Risk

In a vehicle rollover accident, if an ignition source is present, a fire could result.

Remedy

Dealers will inspect the vehicles to locate and replace those fuel tanks that could have inoperative rollover valves.

Recall number 99V268000 · Recall details

What is wrong

Vehicle description: passenger mini vans. The left and/or right front lower insulator to cradle center metal sleeve is collapsed, which can result in loss of clamp load in the joint. If the clamp load is reduced or lost, the bolt can be lost or broken and the joint can separate.

Risk

If not repaired, separation of the opposite side joint could occur resulting in steering shaft separation.

Remedy

Dealers will replace the left and right front lower cradle-to-suspension insulators and the attaching bolts.

Recall number 99V071000 · Recall details