I was driving and the truck shut off causing me to stop in the middle of an intersection. I had to steer the the truck with no power steering. If I was going faster I would have crashed. This is what the dealership found. Confirmed no start condition. Scanned vehicle and found dtc p0340-camshaft position sensor circuit - bank 1 sensor 1. Verified getting fuel and spark. Performed compression test. 0 psi. Has fast crank. Removed passenger valve cover and cranked engine. No movement. Removed timing cover to inspect. Found timing chain snapped. Tensioner in pieces. Chain guides destroyed. Engine overrotated. Bent valves. Damaged cylinder heads. Catastrophic failure. Recommending replacement of long block
2019 Ram 1500 engine complaints
Page 5 of 10: complaints 101 to 130 of 252, newest first, as owners wrote them.
The contact owns a 2019 Ram 1500. The contact received notifications of the federal safety agency Campaign Numbers: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for the federal safety agency Campaign Number: 23V411000. Parts distribution disconnect for the federal safety agency Campaign Number: 22V406000.
The contact owns a 2019 Ram 1500. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to restart however, the failure recurred. The vehicle was taken to the dealer where the vehicle was diagnosed with alternator, tension belt, torque sensor, and CV axle shaft failure. The contact was informed that the alternator, tension belt, torque sensor, and CV axle shaft needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 82,032.
Vehicle developed the infamous "hemi tick" chronicled in multiple news articles, bulletins & complaints. Defective exhaust manifold design causes it to trap heat, melting the bolts and cracking the manifolds. This leads to loud ticking when engine is started from cold and can eventually lead to engine failure. Had to have both manifolds replaced, along with gaskets.
Only 65000 miles I wash everytime all the truck undercarriage is rust easy especially the oil pan in the engine. And I check too many people make complaints about the oil pan. Now my oil pan is crack and rust and it's $3000 to fix its insane. 4 years and gone. Car value over $45000.
Driving the vehicle and out of no where the power steer failed and the steering wheel locked up. Had 3 young children in the car with me and was blocking traffic due to being unable to drive the vehicle. The dealer inspected the vehicle and said it would need a new power steering rack and that he has never heard of this problem before when it’s all over the internet. The part is not available and it will be a minimum of 30 days with no estimated date. Vehicle has only 62,500 miles and has never been involved in any crash. This issue put my children at risk with no indication it would happen.
The contact owns a 2019 Ram 1500. The contact received notifications of the federal safety agency Campaign Numbers: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
I started smelling exhaust fumes in the cab of my truck. I began inspecting the engine compartment and heard a noise from the left side of the engine. I also noticed reduced power from the engine and a puffing sound during hard acceleration. I researched online and found numerous complaints for the RAM 1500 truck with the 5.7 liter hemi engine manifold exhaust bolt shearing and manifold cracking. I took my vehicle to a RAM dealership. The left (driver) exhaust manifold was replaced due to a sheared center bolt and a cracked exhaust manifold. The crack went almost completely around the center of the part. Technical Service Bulletin (TSB) 09-011-22, dated September 3, 2022 was issued for this defect for 2019-2021 RAMs with 5.7 liter engine. The dealership bill was $833.06, including $260 ($217 MSRP on MOPAR.com) for the kit and $525 for labor (2.5 hours per the service representative, so $210 per hour). This known defect is a serious safety issue due to exhaust fumes entering the vehicle cab and being breathed by the driver. A recall should be issued for this defect.
Upon acceleration from stop, and even while driving at speeds between 30 & 40 mph, the vehicle shifts from Drive to Neutral and displays "Shift to P..." on the display. This occurs repeatedly. You have to stop the vehicle and shift to Park then back to Drive. But it keeps occurring, over and over. It first occurred when I pulled out into traffic, the vehicle shifted to N and I had absolutely NO EXCELLERATION with oncoming traffic behind me. I immediately put on my hazard lights and steered towards the curb to attempt to get out of the way... traffic behind me was able to slow and avoid collision but this is an extremely dangerous issue.
The radio wouldn’t come on and then the car rpm just go down while I am driving and the check light came on
I was driving on busy road and truck completely shut down with a warning message”shifter autocorrect active” all power to truck died out and truck cruised to a slow speed and then abruptly jumped into park.i would restart it, drive few feet and it did it again. A few times it drove for a relatively longer distance but same message would come up and truck shut down in motion. Police had me take it off the road as i was causing very unsafe situations for myself and for all others around me. Had truck towed home, Unhooked battery once car got home to help reset it, took it out again and exactly same thing. Called dealer they said never heard of it , yet there are hundreds of complaints regarding this situation online. Taking it into dealer to have a diagnosis done
The contact owns a 2019 Ram 1500. The contact stated that after starting the vehicle, or while driving at various speeds, there was an abnormal ticking sound coming from the engine compartment. The contact s also smelling exhaust odor in the cabin of the vehicle. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The contact researched online and found many similar failures with exhaust fumes entering the cabin of the vehicle. The failure mileage was approximately 75,500.
Passenger exhaust manifold is leaking fumes into the cab. The leak started in January of 2024 as a slight ticking and has become worse. The truck has 47k miles.
The contact owns a 2019 Ram 1500. The contact stated while driving 75-77 MPH, the vehicle stalled. The low oil pressure warning light was illuminated. The contact was able to pull to the side of the road. The vehicle failed to restart and was towed to the local dealer, where it was diagnosed that the intake manifold had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 122,335.
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 23V411000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
There is a ticking noise I hear when the truck is first started and it is very obvious until the engine warms up and then it is less noticeable. I also noticed a decrease in fuel mileage. I had a mechanic look at it and he told me that the right side exhaust manifold was cracked. I ordered the right side manifold and new bolts and had the mechanic install them for me. Once it was installed when we started the truck the noise was still present but not as loud. I had him look at it again thinking that maybe the install was not done correctly and he said the left one was cracked as well. He showed me the crack. I got online and tried to order the left manifold but it was backordered. I told him that I couldn't find one and that I was on a waitlist at one of the dealerships for it. He told me I needed to try to get it ordered as soon as possible because further cracking could cause issues in the engine and cause a catastrophic event and ruin the engine. A year and a half later there are still no parts available. Upon further investigation I have found that this is a common event for these engines and has been for a very long time. The reason the parts are on backorder is because it is happening to most of the trucks with these engines. Also there is not a replacement part that fixes this issue so there are lots of posts online about it happening a second time after replacing the cracked manifold. The only alternative is to change the OEM manifolds out for shorty headers, which is a lot more expensive, and from the looks of it they are on backorder as well now. It's also a safety hazard because all the exhaust fumes leaking out can get into the cabin and cause carbon monoxide poisoning, accidents, deaths, etc. This is unacceptable. A recall needs to be issued and these vehicles need to be repaired at Chrysler's expense no matter the mileage. The worst part is that people agreeing to repair it can't because the parts are on an extended backorder with no ETA.
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 23V411000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The local dealer was not yet contacted. VIN tool confirms parts not available.
Oil Pan is Rusting and thin. Oil Pan gasket leaking warranty will not cover parts/labor. Oil pan holds vital lubrication for engine operation. Read tailgate handle does not operate properly. Must push closed to keep rear tailgate door from opening when vehicle is in motion
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Numbers: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling) however, the parts to do the recalls repairs were not yet available. The contact stated that the vehicle hesitated to respond and jolted while driving from a complete stop and while driving at various speeds. The contact stated that the failure occurred intermittently. There was no warning light illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was approximately 36,000. VIN tool confirms parts not available.
Jun 09,2022 Manufacturer Recall NumberZ46 the federal safety agency Recall Number22V-406 Recall StatusRecall Incomplete It is almost two years since this recall came out.
This truck has a serious safety issue that FCA is ignoring. The exhaust manifolds/bolts are faulty and leak exhaust gas into the cabin of the vehicle causing all passengers to be subjected to high levels of carbon monoxide and exhaust gases. This poses a serious safety hazard for bother drivers and passengers of all vehicles on the road. The company has been aware of the exhaust manifold issue affecting Ram trucks for years yet when this truck experienced a known problem the consumer (me) is still burdened with paying over 900 per side to get each manifold repaired and replaced. This is absolutely unacceptable, especially when both sides just fail like my truck did at the same time. I can’t sell it it’s not safe to drive. I can’t afford to fix it and it ain’t worth anything to trade in due to this known issue. Please help!!
I have a 2019 Dodge Ram Rebel I have owned since new. Two months after I got it it had the tick. I have noticed every dodge ram on the road has this tick I mean every ram. I have always bought dodge since I have purchased vehicles. Is the anything that you can do for me on this issue there is fumes coming in the cab of the truck and it’s unsafe since there is a problem with all vehicles in the brand. I’m hoping so because this is starting to turn a lot of heads and people do get an upset stomach because of the noises and this is not what a 80,000 dollar vehicle should have happen.
This truck as well as multiple others I have seen complaints on multiple dodge ram forums where something is causing the battery to die then the stability control light comes on and the the truck will not change gears until the battery is completely disconnected to "reset" the computer and then it's like the battery never died. It works great with no issues for months then out of nowhere the exact same issue happens once again. We have spent thousands of dollars fixing this issue to no avail just keep replacing parts that apparently aren't the fix. So far we have replaced the torque converter, the battery as well as paying for multiple diagnostics to which they keep replacing the battery saying that is the issue but obviously it can't be the battery when it's getting replaced over and over SOMETHING is causing this draw making the battery die. PLEASE ADDRESS THIS AND ISSUE A RECALL SO WE AREN'T LEFT WITH THIS HORRIBLE TASTE IN OUR MOUTHS AND DON'T NOT WANT TO PURCHASE ANY MORE DODGE VEHICLES BECAUSE WE OWN ALL DODGE VEHICLES BUT NEVER HAVE WE HAD SUCH PROBLEMS AS WITH THIS 2019 RAM 1500 VIN [XXX] BECAUSE THIS IS BREAKING US. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Lifter and camshaft failure, Spark plug and coil issues.
I have had my Dodge Ram 1500 in the shop from November 2022 through September 2023 five different times for defective camshafts vvt solenoids oil control valves. Issues still persist due to faulty machined parts from the manufacturer.
When driving the vehicle on the roadway, the vehicle will turn off the engine and will not allow you to accelerate and will flash a message to put the car in park. When you pull on the side of the road and place the vehicle in park you can then restart the engine. Once the engine is on and you try to put the vehicle in drive the engine will turn off again and request that you put the vehicle in park. It does this over and over for about 5-6 times until it does eventually allow the vehicle to stay in Drive and you can start moving down the road. Once you are driving in the road way it will repeat the process again. During this process there are no warning lights or messages being displayed other than "place the vehicle in park". This is extremely dangerous especially if I was on the interstate or Highway and I lost all capability to move the vehicle. I took the vehicle to a dealership and they were unable to recreate the issue and so no active codes that would point them in the direction of the problem. The dealership told me there was nothing they could do unless they had a code or could recreate the issue.
The vehicles power steering goes out. The wipers turn on automatically. The lights on the dashboard flicker. The battery voltage keeps dying. The message dash starts to go crazy and everything starts to say something is wrong. I was driving on interstate 95 when all power steering went causing me to lose control of the truck. I almost crashed. A car shop did inspect it but could not figure out why this was happening when I showed him the footage I took of the truck when this happened.
Happened twice within the last three months. The first time I was driving at a speed between 45-50 mph and vehicle shutoff with instruments reading vehicle must be placed in park depress brake and start engine. After coasting to a safe area to stop the vehicle seemed to have shifted into park just before a full stop and abruptly and aggressively stopped. Depressed brake and restarted then vehicle displayed same message again and shutoff, this time it would not restart. Inspected under hood for an obvious problem, did not find anything. After about 20 minutes vehicle started and was able to continue on with no problems until weeks later when vehicle again shutoff while driving. This time while driving around 70 mph on highway. Was able to coast to stop in emergency lane. This time the instrument panel displayed a TPWS error with no input to all tires. Tried to restart after coming to abrupt stop. Push to start had no power nor did anything inside the vehicle. After about 45 minute the depress brake and push to start symbol illuminated and vehicle started. Was able to make it home about 4 miles away the vehicle shutoff pulling into driveway. Loosing power at 70 mph is not a good feeling.
Notorious exhaust manifold & mounting bolts failure affecting ALL Ram pickup trucks with the HEMI engine. Exhaust manifold bolts are breaking and/or becoming loose causing a major combustion leak, exhaust manifold damage & posing a great fire hazard. Manufacturer is well aware of the problem at hand & has grossly neglected to issue a safety recall to mitigate the hazardous conditions, risking the lives of unsuspecting occupants. I first addressed this issue with the selling dealership service advisor upon an oil change of a newly purchased vehicle & was told the noise I was hearing was a perfectly normal “HEMI Tick”. Gross Negligence to say the least!!
Broken exhaust manifold bolt warped the exhaust manifolds. Exhaust fumes can enter the engine compartment using the recirculation button. This is a known Hemi issue for years
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ram 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history