The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed a thousand miles away from home, the vehicle stalled and lost motive power in the middle of the freeway. The vehicle was towed to a local dealer where it was diagnosed with a failed tone wheel generator and failed fuel pump. The contact was informed that the tone wheel generator and fuel pump needed to be replaced. The vehicle was repaired. The vehicle was picked up by a family friend on two occasions however, the failure persisted. The vehicle was not repaired. The contact stated that the vehicle had been at the dealer for 90-days or more. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 65,000. VIN tool confirms parts not available.
2019 Ram 1500 fuel system complaints
Page 3 of 5: complaints 41 to 70 of 105, newest first, as owners wrote them.
Hard to fuel the vehicle. Takes 15 minutes or more to fill the gas tank. Ram's fix is to replace the gas tank on a 4 year old truck with under 60,000 miles. Filling up using a funnel at a gas station is not safe for me or other drivers. The local dealer said the cost would about $2000. A service notice was issued over a year ago.
There is an issue with putting gas into this truck. Seems there is a defect in the filler tube which Ram will not at this point recognize
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated while driving at slower speeds with a trailer attached to the vehicle, the vehicle shut off as several warning lights appeared on the instrument panel. Due to the failure, the vehicle was towed to the dealer where the contact was informed that the part for the high-pressure fuel pump was not available for another two months. Once the fuel pump was finally replaced, the dealer informed the contact that contamination was found in the fuel system which rendered the repair ineffective. The contact was given an estimate for the repair. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was approximately 50,000. VIN tool confirms parts not available.
I have an oil cooler leak, a radiator leaking coolant , transmission running high. I have 110k miles on my truck and do routine maintenance. I’m worried about an engine fire or cracked block soon.
The contact owns 2019 Ram 1500. The contact stated that on numerous occasions while refueling the vehicle, the fuel overflowed from the filler neck. The contact then stated that water had leaked into the fuel tank. The check engine warning light illuminated. A message displayed on the instrument panel “catastrophic failure to the vehicle if failed to stop”. The vehicle was inspected by an independent mechanic using an OBD code reader and retrieved codes: P0300, P0456, P0455 and P1DF3 and diagnosed that the fuel pump failed and needed to be replaced. The vehicle was repaired. An undisclosed dealer was notified of the failure and the contact was informed that the vehicle was not covered under warranty. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.
Due to a known but unaddressed defect in the steep-angled fuel filler neck, it’s almost impossible to fill my tank with gas because the defect causes the gas pump to stop the flow of gasoline every few seconds. Also, the gas pump handle can sometimes become stuck while trying to refill the truck. This cause a very dangerous situation in trying to remove the stuck handle due to the possibility of creating a spark which could ignite the gasoline vapors from trying to forcefully dislodge the pump handle. the federal safety agency, to my knowledge, has not requested the manufacturer to initiate a recall to replace the defective part. This problem has been widely discussed online in different forums. My truck has been at the dealership all week and the service department just called me saying I need to order a new fuel tank at the cost of $1925.00!
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Numbers: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and a case was opened. The contact had not experienced a failure. VIN tool confirms parts not available. The contact stated on 1/15/24 the engine blew up (hole in engine) and axles broke while driving on the freeway. The vehicle was towed to the dealer to fix and they will not cover it.
The contact owns a 2019 Ram 1500. The contact stated while driving from a complete stop and while making turns, the accelerator pedal was depressed, but the vehicle hesitated to respond. There was no warning light illuminated. The contact stated that the failure had been recurring while driving. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer, where it was diagnosed that the high-pressure fuel pump (HPFP) had failed and needed to be replaced, and the failure was related to the recall. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 33,000. VIN tool confirms parts not available.
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed and depressing the accelerator pedal, the vehicle hesitated while responding. The contact stated that the failure had been recurring while driving and had nearly caused a crash. There was no warning light illuminated. The vehicle was taken to the local dealer, but the failure could not be duplicated. Additionally, several unknown dealers were contacted. The vehicle was not diagnosed nor repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was unknown. VIN tool confirms parts not available.
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Numbers: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling) however, parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
When Filling the truck up with fuel, after 1-2 gallons the pump would shut off and I would have to repeat this process to fill up my 32-gallon tank. When I took it to the mechanic, it was found that the tank and filler neck was not properly preventing the pressure, causing the pump to think the tank was full and shut off. By the time we figured out the issue Stellantis had already developed an updated tank and filler neck and were putting it into their new trucks, but they never informed the public of the error nor issued any kind of recall to fix the existing issue.
Having trouble putting fuel into the tank. While attempting the refuel the vehicle the nozzle will constantly shut off and sometimes fuel will pour out of the filler neck onto the ground. I have to VERY slowly fill up the tank. Not sure if this is related but the fuel nozzle does not fit into the neck properly. Thank you
My 2019 Ram 1500 will not take more than a few ounces of fuel at a time. It takes well over a half hour to refuel my tank. The pump constantly shuts off and the tank constantly spits gasoline back at me when trying to refuel, it is not safe to have gasoline spilled on you. I have a toddler, and I do not want her exposed to the fumes after I am doused with gasoline trying to refill my Ram 1500. No warning lights are illuminated on the dashboard. I have scheduled an appointment for a dealer to examine the issue.
Truck had check engine light and sever loss of power Intermittently. Brought to dealer to have it checked. Dealer said they cannot clear the code or fix the issue as the recall in effect does not have the parts out to fix. Recall z46 has been in effect since June of 22 and there is still no solution. I called manufacturer to ask about it and they all they said was quote "I'm sorry there's nothing we can do about it".
Fuel pump failure resulted in the loss of propulsion on the Highway.
2019 Ram Ecodiesel 3.0. I was Driving back to work on Easter Sunday 2023 after visiting family. It was a 5 hour trip, I was halfway through when the engine started making a loud banging sound. I pulled over & the engine died and would not turn over. I am sure the engine threw a rod, two other driver stopped & asked if everything was ok because they could hear the engine noise from their cars when it happened. There were no check engine lights or messages before or during the engine failing. I had to get a tow truck & tow it to the nearest dealer. It has been at the dealer for 2 weeks, they still have not diagnosed a problem but said if it is the engine it is on backorder & they don't know when it will be fixed & they refuse to give me a loaner. The truck is still under powertrain warranty. Where is my consumer protection? It is beyond frustrating to pay big money for something & not have what you paid for. I bought the truck for reliable transportation & Ram refuses to give me another vehicle. I am still having to pay insurance & car tag fees for my truck while I wait for an answer from the dealer, I have no idea if they will warranty it or when the truck will be repaired. On a separate note there is also an open fuel pump recall on my truck that is close to a year old with no ETA on a fix. I did not purchase a vehicle with plans to never have the recall fixed, I had one RAM dealer in Laurel, MS tell me it was an unrepairable recall & they were not even interested in purchasing my truck or a trade in due to the recall before my engine failed.
Problem refueling. nozzle/pump keeps shutting off after every 3-5 seconds causing gas to splash back. Truck was fine until 2022 problem getting worse.
The contact owns a 2019 RAM 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact's husband owns a 2019 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was notified of the issue and confirmed that parts were not yet available. The manufacturer was not notified of the issue. The contact stated that the check engine warning light was illuminated. The failure mileage was unknown. VIN tool confirms parts not available.
Rear window seal is leaking which cracked the window frame allowing water to enter behind rear seat leaking onto the wireless control Module making it in operable. The vehicle would not start. This will become a safety issue when driving down the highway/local areas and you loose the module it shuts down the car no power at all. Power steering goes down breaks become more difficult to push. Chrysler knows about the leak but will not do anything. The suggested repair is to replace the rear window at $1600.00 and the Wireless Control Module. My vehicle had 26k miles on it and warranty ran out. I do have an extended Warranty but because the rear window was leaking the wireless control Module is not covered.
We bought this truck used around September of last year and it took a couple of months to start having issues. First, when we would turn the truck on and it would crank, we would hear an occasional knock in the rear end. Like something being reemed out. Recently, one two separate occasions, two separate days, we were going to town and all of a sudden the A/C stopped working and extremely hot air started blowing through the vents and we couldn't turn it off or anything. The knobs to turn off the AC didn't turn it off. The only solution was to pull over on the side of the road and kill the truck and then crank it again. I can only imagine if someone else has this truck and a baby or even elderly was sitting in the vehicle and it changed over like this, it would've suffocated them within minutes, the heat was hotter than heat on a vehicle ever thought about being. Also, our backup camera has had moisture in it after a rain and throws up green lines across the screen. It also has had electrical issues, the radio and whole display will sometimes cut off when the brake pedal is pressed. The radio sometimes cuts off on its own or won't turn off when the button is pushed and sometimes this causes distraction to the driver. There has been a rattle in the steering wheel since we have gotten it. Of course, we have taken it to the dealer from where we bought it because we paid for an extended warranty but they can never find an issue because it doesn't do it while in their presence, even though we have pictures of the malfunction. Also, recently we have noticed that the truck doesn't want to take the gas. It will click off the gas probably 3 or 4 times before we can get the truck filled.
Engine stopped running while driving on an active road due to fuel pump failures (only 26,000 miles). Truck will not start any longer and fuel pumps are on national back order.
While under warranty brought my vehicle to the dealer because I could not pump gas. The pump would continue to click off while fueling. Dealer told me that it may be the gas station that I'm going to and that they could not replicate the problem. Fast forward 6 months, the vehicle is now out of warranty and the problem has continued to the point where I can't put any fuel in. Brought it to another dealer and they said I need a new fuel pump and a new fuel tank at at cost of $2500. This should have been covered under the warranty but the first dealer was less than honest. I'm sure they knew what the issue was since there are numerous complaints similar to mine on this site. the federal safety agency should investigate and/or open a recall because RAM won't. This fuel issue isn't just related to the 2019 1500 but other years as well. Consumers are paying for repairs that RAM should be covering through the recall.
Our defrost system on windshield is only working on one side. First things first, the Vin number and the picture listed does not match our vehicle so I will be calling the the safety line to get it fixed. When googling the Dodge recalls. It popped up as a recall but I guess it’s not on our vin number dodge yet? Then the truck automatically started smelling like antifreeze. When driving it sometimes loses power to the gas pedal and starts to slow down! The back windshield started leaking the same day as the defrost malfunction. There is no dash signal when there’s low air in tires….. And depending on speed of the dodge started making like dying whale moaning sounds. When turning the truck off, it stops for a minute, but then it starts again. This truck only has 50,000 miles on it and it should not be tearing up this quick as it is. When pushing the push start on and off, it always goes into a cc mode instead of turning off Last but not least the gas tank is malfunctioning when you put the gas pump into the tank I think the gas is leaking out and you have to constantly reset the gas pump handle. Also, the tailgate is getting stuck and you cannot open it. I’m afraid it’s going to come open when driving. Thank you for your time. Hope to speak with you soon. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
When refueling, the fuel vapor recovery system causes the gas pump to shut off after only a couple seconds of pumping fuel. This happens continually while attempting to refuel. It takes 20-25 minutes to refill the tank. The dealership says they have to replace the whole fuel tank to fix this issue at a cost of over $1,800.
Purchased a 2019 Ram 1500 used, with 43k miles earlier this year. Twice, the trucks computer, and fuel gage said I had more then a quarter tank let in fuel. Twice, I have run completely out of gas, stalling the truck, and left no way to accelerate. Almost causing an accident.
2019 ram classic problem filling gas tank
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ram 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history