2022 Ram 1500 transmission problems

Filed Oct 30, 2026 · Engine, Transmission · ME

Vehicle experienced an eTorque hybrid auto-start failure at a stoplight, leaving the vehicle stranded in traffic until a manual restart was performed. The electrical charging system dropped to 12V. The dealership pulled the codes, cleared them without providing a record to the owner, and attempted to charge out-of-pocket for an unneeded mechanical belt and tensioners, which an independent shop later confirmed are perfectly fine. The independent shop suspects an internal MGU failure, matching the federal safety agency investigation PE24018." (This adds your truck to the active federal data pool)

Filed Oct 29, 2026 · Electrical, Transmission · ID

Incident 2 of 2: I am filing two separate formal complaints regarding two incidents in which my 2022 Ram 1500 eTorque unexpectedly shut down while driving, posing serious safety risks and raising concerns about an unresolved vehicle defect. Second Incident: May 30–June 23, 2026-While traveling on a mountain road, my truck again shut down unexpectedly. Without cell service, I was unable to call for assistance. After approximately 15 minutes, I restarted the truck and drove home. The following day, the truck would not start, requiring a tow to another Ram service facility. Although the dealership again focused on the 48-volt battery, it could not confirm the cause of either shutdown. I was told a failed fuse prevented the truck from starting, but no underlying cause was identified. Repeated, unexplained failures present an unacceptable safety risk to me, my family, and other motorists. I continue to drive with the concern that my truck could shut down in traffic or in a remote location, potentially resulting in serious injury or loss of life. The approaching expiration of the 48-volt battery warranty further compounds my concerns, as I could face significant repair costs for a problem that remains unresolved. I respectfully urge the federal safety agency to investigate these incidents and determine whether they indicate a broader safety defect requiring corrective action. I believe repeated failures and inability to identify the cause warrants serious regulatory attention before another event occurs.

Filed Oct 29, 2026 · Electrical, Transmission · ID

Incident 1 or 2. I am filing two separate formal complaints regarding two incidents in which my 2022 Ram 1500 eTorque unexpectedly shut down while driving, posing serious safety risks and raising concerns about an unresolved vehicle defect. First Incident: XXX-During rush-hour traffic on a major [XXX] highway, my truck suddenly shut down while I was traveling in the far-left lane. I had to maneuver onto the left shoulder to avoid being struck by another vehicle. After waiting approximately 30 minutes for a tow truck, I was without my vehicle for nearly six weeks while the service center assessed the problem and awaited parts. Repairs included replacing the 12-volt battery at my expense and the 48-volt battery under warranty. Repeated, unexplained failures present an unacceptable safety risk to me, my family, and other motorists. I continue to drive with the concern that my truck could shut down in traffic or in a remote location, potentially resulting in serious injury or loss of life. The approaching expiration of the 48-volt battery warranty further compounds my concerns, as I could face significant repair costs for a problem that remains unresolved. I respectfully urge the federal safety agency to investigate these incidents and determine whether they indicate a broader safety defect requiring corrective action. I believe repeated failures and inability to identify the cause warrants serious regulatory attention before another event occurs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 22, 2026 · Electrical, Engine · GA

I am reporting a recurring engine defect involving the Multi-Displacement System (MDS) in my 2022 RAM 1500 Big Horn equipped with the 5.7L HEMI eTorque engine. Since purchasing the vehicle in March 2023 with approximately 4,555 miles, the truck has experienced four separate MDS-related failures despite multiple repair attempts by authorized RAM dealerships. On February 7, 2025, at approximately 38,115 miles, a RAM dealership diagnosed an MDS solenoid that had physically separated and required extraction and replacement. On May 1, 2026, at approximately 66,149 miles, another authorized dealership diagnosed an MDS failure involving cylinder No. 1 and performed repairs under warranty. Despite these repairs, the engine experienced another serious failure at approximately 73,000 miles. The most recent failure involved metal contamination and catastrophic internal engine damage, leaving the vehicle completely inoperable. I am concerned that the repeated MDS-related failures indicate a potential defect in the engine's cylinder-deactivation or valvetrain components. Failures involving these components may cause significant engine damage and potentially result in an unexpected loss of engine power while driving, creating a safety risk for the driver, passengers, and surrounding motorists. The vehicle has undergone multiple repairs for recurring MDS-related problems, but the issue has not been permanently resolved. I believe the final engine failure may be connected to the previously documented MDS failures, although the exact mechanical cause has not yet been independently confirmed. I am requesting that the federal safety agency review these recurring failures to determine whether they indicate a broader safety-related defect affecting RAM vehicles equipped with the 5.7L HEMI MDS engine.

Filed Oct 22, 2026 · Engine, Transmission · TX

The truck has stalled twice while in motion. Leaving me stopped suddenly in middle of the street. This has happened on 2 separate occasions. I did not think to save the dates. Initially I thought maybe I wasnt giving it enough throttle, but after reading more into it I see there was a recall for the previous year model and this may be considered problematic as well. The truck made me apply the brake to restart, and release the emergency brake since it applied on its own. The first stall I had to turn sharp and fast to try getting to the side of the road to make room for coming and going traffic and avoid being in a collision. The second stall I was luckily the only driver on the road at the time. I'm reading it could be the MGU system and I have also noticed my battery voltage starting to fluctuate more. I jave not taken to the dealer yet as this is my means of transportation for work and we are a 1 income family of 4. I do not get a rental if I have to leave the truck at the dealer.

Filed Oct 21, 2026 · Electrical, Engine · ME

The vehicle experienced a sudden powertrain failure at a busy intersection failing to automatically restart during an auto start/stop cycle on October 6, 2026. Upon manual override, the mild hybrid motor generator unit (MGU failed to adequately charge the 48V/12V electrical systems. This failure leaves the driver highly vulnerable to a total high-speed vehicle stall in active traffic due to rapid battery depletion. The manufacturer and dealership is unlawfully denying federal coverage for this emissions/hybrid component. At the time of the incident the vehicle had approximately 59,248 miles on it. I called the dealership (as I believed this would be covered under the 60,000 mile powertrain warranty) that day describing the failure. The earliest appointment I could get was October 16th. By the time my truck went in for the appointment the mileage was 60,130 miles. The dealership Identified the failure as the charging system for the Ram Hemi E-Torques motor. Specifically the Serpentine Belt Tensioner Part #: 05281543AD, 05281956AA, and 68518738AA. Also prescribed a software update. The total quote for the repairs was 1534.80. The dealership denied warranty coverage under the powertrain stating the vehicle had exceeded 60,000 miles. I showed them a picture of my odometer at 59,248 miles dated for the day i reported the problem and scheduled the appointment. They then informed me that standard accessory parts (belts, tensioners, etc.) are not covered under the 60,000mile warranty. They also informed me they are not covered under the 80,000 mile emissions warranty either despite their failure resulting in a complete failure of the federally mandated emissions system. The dealership indicated approximately 30-40 codes were triggered during the incident including a system code for the MGU. I requested a record of these codes and the dealership is unable/unwilling to provide.

Filed Oct 13, 2026 · Electrical, Engine · FL

On three occasions over the last 6 months my truck has died completely. The first time all warning lights came on and there was no speed showing but the truck kept driving. When I finally parked and restarted everything was normal. The second time all warning lights came on the cool air turned hot and then it just died while driving. I was very close to parking so no danger there. This last time I was parked in a swamp hunting and when we got back to the truck it was completely dead. I was able to jump it thankfully as we were in the middle of nowhere and it was hard to get to, not sure help would have been able to get in there. When restarted it once again had all warning lights on, said I had no gas, and wouldn't provide my speed when driving.

Filed Oct 9, 2026 · Electrical, Engine · CO

My 2022 Ram 1500 Big Horn V6 eTorque stumbles and cuts out during hard acceleration, this issue, when it happens has caused a dangerous performance issue to the point that I have almost been struck from behind while attempting to join the flow of traffic, the actions of either the PCM or some other engine control system cuts all motor RPM to barely an idle while traffic around me are at speeds of 40+ MPH while I am attempting to accelerate, I get a brief warning message on the display screen that flickers for less then one second (I am unable to read the warning) this is extremely dangerous. I also have been getting UCONNECT ERROR - none of these are leaving error codes in the vehicles memory.

Filed Aug 25, 2026 · Electrical, Engine · TN

The vehicle has already had the generator replaced due to failure and shutting off while driving down the road and the speed limit. The truck was in the shop for almost 6 moths, then the front drive shaft broke while driving in 2-wheel drive. Now while my wife was driving going 40 mph on HWY 96 the car shut off and put itself in park in the middle of the highway. We were lucky no one hit us and after a few minutes it restarted and we were able to get it off the road and have it towed to the dealer where it is right now.

Filed Aug 10, 2026 · Transmission · FL

I own a 2022 Ram 1500 Limited 4x4 (5.7L HEMI eTorque, ZF 8-speed automatic), VIN [XXX], approximately 40,000 miles. For roughly two years, the transmission has produced a hard, jarring downshift and lurch during normal low-speed deceleration, consistently when slowing from ~20 mph to a stop. This occurs both when the engine is cold and fully warmed up, ruling out a cold-start explanation. It happens under normal city driving, not towing or aggressive driving. The jolt is forceful enough that passengers, including my spouse, are reluctant to ride in the vehicle. I brought the truck to an authorized Ram dealership (Greenway Dodge, Orlando, FL) and left it overnight. The service manager stated this was “normal” behavior and that his own vehicle did the same. When I noted it happens warm as well as cold, I was told nothing could be done. No diagnostic codes were pulled, no fluid inspected, and no TSBs checked during the visit. I later confirmed via the federal safety agency’s TSB lookup that a bulletin addressing rough downshifting on 5.7L eTorque Ram 1500 trucks (TSB 21-005-19 or superseding revisions) exists for this platform, and has NOT been applied to my VIN despite the dealership having full access to check. I’m filing this because: 1) the behavior involves unexpected, forceful lurching during low-speed deceleration that could startle a driver near intersections; 2) my dealership dismissed it without diagnostics or checking for applicable updates; 3) this appears to be a widely reported issue among other 2019-2022 Ram 1500 eTorque owners, suggesting a pattern rather than an isolated defect. I’m requesting the federal safety agency document this as part of its review of shift-quality/drivetrain behavior in eTorque-equipped Ram 1500 trucks of this model year INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)