2021 Ram Promaster engine problems

Filed Jul 24, 2026 · Engine · NE

The specific issue you are dealing with is Chrysler Recall 67C (the federal safety agency Campaign 25V720). This recall impacts nearly 300,000 Ram ProMaster vans (model years 2018–2026) due to an overheating radiator cooling fan circuit that poses a significant vehicle fire risk. More than 200 of these are from the VA. Edwards Auto Group In Council Bluffs, IA is trying to make the Veterans Health Administration pay labor for a safety recall that is stated above. I am reporting them because it is a safety recall and we should not have to pay for extra cost such as a 2x4. Please see below. It is my understanding that the Dealer is in the wrong here. •Absolute Free Labor: Dealerships enter franchise contracts with the manufacturer requiring them to execute recall repairs for free. Chrysler (FCA US LLC) is legally obligated to provide the instructions and billable labor hours to the dealership. •The "2x4" Tool Excuse: If a manufacturer's official technical service bulletin specifies a specific physical manipulation or tool—even a makeshift one like a 2x4—to complete the repair, that labor time is factored into the flat-rate time Chrysler pays the dealer. The dealer cannot pass "difficult labor" or tool costs onto you. •No Deductibles or Add-ons: A dealer cannot apply any separate fees or surcharges to offset their operational challenges while resolving a safety defect.

Filed Jun 23, 2026 · Driver assistance, Engine · AL

The contact owns a 2021 Ram Promaster 1500. The contact received notifications of the federal safety agency Campaign Number: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, the parts for the recall repairs were unavailable. The dealer was contacted, and the contact was informed that parts were not yet available. The manufacturer was contacted, and the contact was informed that parts were not yet available. The contact had not experienced a failure.

Filed Mar 25, 2026 · Engine, Transmission · TN

On [XXX], while driving my 2021 Ram ProMaster 2500 at highway speed in Florida, the van suddenly lost all power and came to a near stop, then re-engaged. Vehicles were in front and behind me, creating an immediate risk of serious collision, injury, or death. I pulled over ~30 minutes, restarted, but it could not exceed 20 mph while RPMs were high. AutoZone confirmed limp mode and advised a dealer. I drove it home to Port Charlotte, then had it towed to Gettel Dodge Chrysler Jeep Ram, Punta Gorda, FL, where after two weeks it was diagnosed with a failed transmission requiring replacement. The transmission can be inspected at the dealership. No warning lamps appeared before failure. Problem confirmed by AutoZone and the dealer. I contacted Stellantis (Case #[XXXX], contact Regina Knox; dealership contact Noel), but repair assistance was denied. The van also has two active recalls, including risk of rolling out of park, unremedied. This transmission failure constitutes a serious and imminent safety defect, creating a hazard to myself and the public. I request the federal safety agency investigate this defect, compel Stellantis to repair it at their cost, and consider any further regulatory action necessary to prevent injury or death. Vehicle info: 2021 Ram ProMaster 2500, 130,000 miles, VIN [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 11, 2026 · Driver assistance, Engine · TX

The contact owns a 2021 Ram Promaster 3500. The contact received notifications of the federal safety agency Campaign Number: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, parts for the recall repairs were not yet available. The dealer was contacted, and the contact was informed that parts were not yet available. The manufacturer was contacted, but provided no assistance. The contact was informed that the recalls were not associated with the VIN. The contact had not experienced a failure.

Filed Mar 3, 2026 · Driver assistance, Engine · 64,000 miles · NC · fire

The contact owned a 2021 Ram Promaster 1500. The contact had stopped at a house that the contact worked on and parked the vehicle on the side of the house. The contact turned off the engine and entered the house, and after twenty minutes, when the contact stepped outside, the vehicle was engulfed in flames. The flames spread to the house and caused damage to the property. Some of the paint melted; the garage door, driveway, side door, and some of the landscape were damaged. The fire department was called and extinguished the fire. No police report was filed. The contact was informed by the fire department that the fire started due to a mechanical issue in the engine area. Afterwards, the contact was informed by the fire department that the investigation into the origin of the fire was inconclusive. The insurance company was notified and towed the vehicle to an unknown location. The insurance company declared the vehicle a total loss. The manufacturer was notified of the fire. The manufacturer advised the contact that a field inspector would be sent to inspect the vehicle. The field inspector had inspected the vehicle. The contact received an email from the manufacturer stating that the damage was not their responsibility and the claim had been closed. The contact stated that two weeks prior to the fire, a message saying "rear camera not available" was displayed, and an unknown warning code was illuminated on the instrument panel. Upon further investigation, the contact discovered that the federal safety agency Campaign Number: 25V552000 (BACK OVER PREVENTION) was associated with the VIN. The failure mileage was approximately 64,000.

Filed Feb 26, 2026 · Driver assistance, Engine · 100,000 miles · FL

The contact owns a 2021 Ram Promaster 2500. The contact received notifications of the federal safety agency Campaign Numbers: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, the parts to do the recall repairs were not yet available. The contact stated while shifted in reverse(R), the rearview camera failed to display a clear image of the rear of the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Filed Jan 27, 2026 · Electrical, Engine · MD

The 2021 Ram ProMaster 2500 I purchased from a dealer on 12/6/25 now has a serious safety defect. The transmission began grinding when shifting into Drive on 1/27/26. Immediately after, the vehicle started rolling backwards while fully in Park with the engine running. This indicates a failure of the parking pawl or internal gearset. The backup camera also does not function, there are coolant and power steering leaks, and the axle/wheel bearing is failing. The dealer claimed the van passed a “120-point inspection,” but it is clearly unsafe and unfit for operation. This defect poses a risk of rollaway injury, crash, and property damage.

Filed Jan 20, 2026 · Driver assistance, Engine · NC

The contact owns a 2021 Ram ProMaster 2500. The contact received notifications of the federal safety agency Campaign Numbers: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that he lost income because the parts were not currently available. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Filed Jan 6, 2026 · Driver assistance, Engine · 59,000 miles · MN

The contact owns a 2021 Ram Promaster 3500. The contact received notification of the federal safety agency Campaign Number: 25V552000 (Back Over Prevention). The contact stated that the camera had stopped operating in 2024. Additionally, the contact had stopped driving the vehicle due to a recent recall letter received for the federal safety agency Campaign Number: 25V720000 (Engine and Engine Cooling). The contact made several calls to the local dealer but was advised that the parts for the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not informed of the failure. The failure mileage was approximately 59,000.

Filed Jan 5, 2026 · Driver assistance, Engine · CA

The contact owns a 2021 Ram Promaster 1500. The contact received notifications of the federal safety agency Campaign Numbers: 25V720000 (Engine and Engine Cooling) and 25V552000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.