Battery disconnect failed while driving our 20,200 pound rv at highway speed. The failure resulted in total loss of chassis power (engine stopped, power steering ceased, power steering ceased, all dash indicators non-operational, emergency flasher non-operational, etc.). The failure caused us to coast to a stop as there was nothing else we could do. The failed part was later identified as: battery disconnect solenoid (intellitec 01-00055-002 04098 bcc relay (printed on sticker placed on top portion of unit), 612-12v 797 (printed on bottom of unit). The battery disconnect service manual, p/n 53-00066-100, rev b, 030905 fails to list total loss of power while in motion as a potential problem.
The worst 1999 Rexhall Aerbus problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Transmission3
- Brakes1
- Electrical1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Transmission3
- Brakes1
- Electrical1
Recalls 2
Equipment: recreational vehicle/trailer
- What is wrong
- On certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the refrigerator boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- Release of coolant under certain conditions could ignite and result in a fire.
- Remedy
- Rexhall will be working with dometic in order to repair these refrigerators (please see 06e076). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. The recall is expected to begin on or before july 4, 2008. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or rexhall at 1‑661‑726‑0565.
Recall number 07V417000 · Recall details
Power train: driveline: driveshaft
- What is wrong
- Vehicle description: motor homes. The drive shaft bolts can come loose at the transmission and fall off. When the drive shaft separates from the transmission, the forward end of the shaft can drop to the ground, or come through the floorboards of the motor home.
- Risk
- This could lead to loss of vehicle control and/or the drive shaft contacting a following vehicle.
- Remedy
- Dealers will replace the bolts. Owner notification began november 3, 2000. All vehicles have been repaired.
Recall number 01V163000 · Recall details
What 1999 Rexhall Aerbus owners say
Most recent owner complaints, unedited.
Anti-lock braking system has caught overheated and locked up a couple of times. Master cylinder was replaced, but did not stop the problems. Dealer has been contacted.
Driveshaft failed.
On ford chassis, bolt that hold the driveline which goes into the transmission, sheared off which may cause a crash.
Ford engineer inspection concluded that manufacturer did not follow ford specifications for extending chasis/ driveshaft was 3 inches too long and not at the proper angle. Also parts that should have been bolted were welded. I have proof of all these all. The driveshaft fell off on three separate occasions due to this defect.
Compare the 1999 Rexhall Aerbus
Other model years
Questions about the 1999 Rexhall Aerbus
Is the 1999 Rexhall Aerbus reliable?
Owners have filed 5 complaints about the 1999 Rexhall Aerbus, 2.5 times a typical Aerbus model year.
What is the most common problem with the 1999 Rexhall Aerbus?
Transmission and drivetrain, with 3 complaints. Next is brakes (1).
How many recalls does the 1999 Rexhall Aerbus have?
2 recalls, covering equipment and power train.
Was there a recall on the 1999 Rexhall Aerbus transmission?
Yes, 1 recall: 01V163000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Rexhall Aerbus?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history