2020 Subaru Forester: engine overheating

Filed Jun 28, 2024 · Engine · CO

P2682 Engine overheating and engine gauge flashing red due to a recall related to the engine coolant bypass valve. The vehicle stopped and required a tow for $417 to the nearest Subaru dealership to repair. After towing to the dealership they charged 31% of parts to labor and would not eliminate or discount the invoice.

Filed Apr 29, 2024 · Electrical, Engine · WI

The thermo valve leaked into connector, causing engine to shut down abruptly to prevent overheating. This happened at 70 mph on interstate highway in traffic. Part was replaced with modified thermo valve later. Barely able to coast to narrow shoulder flanked by deep ditch, with vehicle very close to interstate traffic, so much so that exit from vehicle ill-advised. After towing, vehicle was serviced by Subaru dealer. At time of part failure many warning lights & messages appeared, but not before the event.

Filed Mar 20, 2024 · Transmission · NY

Thermo control sensor failed which will damage the motor if overheating dealer says it's going to cost me $1500 and it isn't covered under drivetrain warranty which is 5 years 60000 miles I have 27000 miles

Filed Mar 8, 2024 · Driver assistance, Engine · MN

On Sunday, [XXX] we were traveling in our 2020 Subaru Forester on a trip from Minnesota to Florida for a vacation. Not long into cross country trip we found ourselves stranded on the side of the highway uncertain about the ability of our vehicle to continue to due to a defective Thermo Control Valve failure. About 200 miles into our trip, while driving at highway speeds south of Rochester, MN the dashboard lit up. The check engine light was on, and other safety features were lit up on the dash as disabled (Eye-sight technology, lane assist, automatic vehicle collision braking). The heat would not work after this incident. We checked the owners manual, and then drove to an Auto-parts store to have a scan done to determine the error code. The code "P26A3 - Engine coolant bypass valve A Range/Performance" was indicated. In checking online we discovered that a Thermo Control Valve replacement was needed ASAP and to continue driving the vehicle could risk severe engine damage. Since it was a Sunday, and we were essentially stranded if we couldn't use the vehicle. We continued on, stopping and checking the engine periodically for overheating. We were able to get an appointment at Lou Fusz Subaru in St. Peters, MO on Monday afternoon and they replaced the Thermo Control Valve at a cost of $1,961.51. We were told that this wasn't under warranty due to the mileage on the vehicle (76,358 miles). In researching this issue online, we found that the Thermo Control Valve failure to be a common issue and certain year/model vehicles and Subaru should have recalled this part a long time ago (in our opinion). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 6, 2023 · Transmission · OR

Engine check light came on and after running a test it seemed as though the thermo control valve thermostat was not working properly which means the valve that lets coolant into the engine doesn't know what the temp is and when to release coolant. That ended up being the issue and we were barely under the 60k mile warranty for the powertrain so it was covered but I've been reading that it is a common issue and others are surprised it hadn't been recalled yet as it could cause the engine to overheat. The part is so defective that subaru has already designed a better part which means they know its a common issue.

Filed Jun 10, 2023 · Transmission · TX

The thermo-valve controller gives out on this vehicle. Through searches and discussions with two separate dealerships, this seems to be an incredibly common issue. It's enough that Subaru has actually completely replaced the design of this piece for whenever it gets replaced. This triggers a check engine light which already removes many features on the Subaru. My understanding is that this part controls and measures the engine temperature which means that drivers have no clue if their engine is overheating or not when it goes out. Subaru has gotten away with covering this part over their Powertrain warranty since the vast majority of their vehicles are having this part break within 3 years. Most drivers are happy with this because the major ($1500-2000) repair is covered. The issue is that people that drive more often, like myself, are stuck footing the bill for a part that Subaru has admitted doesn't work properly just because we've now fallen out of this 60k mileage warranty. From my research, it's not a part that is greatly affected by mileage, so much as time since the dealerships have noted that every replacement they've seen has fallen within 3 years, regardless of the mileage. For that, I'm asking that there be a true recall put in place for this part. This is a major expense for almost anyone and isn't fair for Subaru to hide behind a warranty that won't apply to everyone when they know they created this improperly. Even the reps at the dealership mentioned that they see this far too often for it not to be a recall, but that most people are still under 60k miles, so there aren't normally issues.

Filed Nov 1, 2022 · Transmission · CA

The other day, the check engine light came on & Eyesight was disabled. I take it to the nearest mechanic who tells me that the cooling fans are running too long at idle & this could drain the battery. He also tells me to watch for the engine overheating. The recently checked coolant level had dropped lower than the minimum. I take it to dealer who keeps it for day. Similar to the 2 other complaints, the fault is related to TSB-09-80-21R calling for replacement parts to be installed. Subaru did not do any recall but instead waited for the parts to fail. I have minimal heat & the engine runs cool a lot of the time which affects emissions. My gas mileage is getting worse. The part is on backorder with no estimated time of arrival. I was told to just keep driving it & to let them know if it starts to run rough. The dealer said there are a lot of other cars & drivers in this situation at the dealer’s service department.