Subaru Forester won't shift problems

Filed Sep 10, 2026 · Engine, Transmission · MI

Component/System Defect: Failed Thermo Control Valve (TCV) leading to sudden vehicle power loss / limp mode. Description of Safety Incident: While operating my vehicle at highway speeds late at night, the Thermo Control Valve (TCV) failed catastrophically without warning. The vehicle instantly experienced a massive loss of engine power and entered an aggressive "limp mode," causing a drastic, uncommanded deceleration in active traffic lanes.Due to the sudden reduction in speed and the low-visibility night conditions, a commercial semi-truck traveling directly behind my vehicle was nearly unable to brake in time and narrowly avoided rear-ending us. My family—including an elderly senior and a [XXX] child—was trapped inside the vehicle during this near-miss collision. The vehicle became an immediate hazard on a high-speed highway. The authorized dealership subsequently confirmed a failed Thermo Control Valve (TCV) and replaced the unit under Subaru's extended warranty program. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 3, 2026 · Engine · OR

Vehicle entered limp mode at highway speed (approximately 70 mph) on [XXX] freeway in Washington State, it felt like I had rear ended a vehicle it shut down so hard. This was due to mis diagnosed inspection and service repair from a local Subaru Dealer. Vehicle lost power rapidly, creating a dangerous safety situation. Root cause traced to TCV/PCV system defects previously documented by authorized Subaru dealers. Previous Subaru authorized dealer replaced a torn PCV hose but did not diagnose the problem causing the tear. The dash warning lights were still illuminated after the diagnostic and repair when vehicle was picked up after service. I have attached a more detailed overview of the dangerous situation. The car finally lost power on the freeway while I was in the fast lane pushing 70 miles an hour. I was in the fast lane and with no power I had to cut across both lanes of traffic and get to the shoulder. I was 45 minutes from my home and it was dark, raining and the Subaru would not start. I called a mobile mechanic I found online who came out to the freeway, roadside, where I was stranded. He worked on the car for a couple of hours in the rain. He got the car to start but it would not stay running. I had the car towed to a friend's house in Vancouver, WA about 6 miles from where it had broken down. The same mobile mechanic came out and changed out one of the oil actuators and cleaned and replaced two of the OCVs then flushed the oil system and put new oil in the car. Cleared all the codes. The car starts, idles and will drive up to about 1500 rpm’s but any more than 1500 rpm’s and it dies. It's in limp mode and will move past those rpm’s. The warning lights and the PCV house splitting must have been signs of something else being wrong. That is the discussion I had with Wilsonville Subaru. They diagnosed the vehicle and let me know the PCV hose was the problem. Car was towed to [XXX] in Vancouver, WA sitting since April 15th, 2026 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF IN

Filed Dec 30, 2025 · Engine · OH

While driving my 2020 Subaru Forester at approximately 15 mph, the engine unexpectedly shut off, resulting in an immediate loss of propulsion (vehicle stall while in motion). This created a safety risk because the vehicle was in traffic and could have been struck from behind or lost the ability to accelerate out of danger. No crash occurred and there were no injuries. There were no warning lamps, warning messages, check engine light, or limp mode before, during, or after the stall event. The vehicle later experienced catastrophic engine failure, also without any warning indicators. The vehicle has been inspected by an authorized Subaru dealership. The dealership confirmed the failure and diagnosed crankshaft bearing failure on cylinder 3, and recommended short block replacement along with related engine component replacement (including cam phasers and gaskets/seals). The engine/vehicle remains available for inspection upon request. Manufacturer has been notified through Subaru of America Customer Advocacy. Subaru has offered partial goodwill assistance but has declined further escalation or full remedy. Note: I have video of this showing no engine lights however unable to upload it below. Can send via email if required. Thank you. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 19, 2024 · Engine · NY

Check engine light came on roughly 3 days prior to incident. Temperature control/coolant bypass valve failed (replaced by dealer at my expense with now updated design), caused the car to unexpectedly lose power rapidly and enter limp mode, dropping from 55 MPH down to 5 MPH in seconds. The incident occurred on a rural road. I had been on an interstate during rush hour roughly 15 minutes prior and could have caused a crash if the incident happened there.

Filed Mar 2, 2024 · Engine, Transmission · MA

While driving on a highway outside Milford, CT my vehicle is check engine light suddenly illuminated. I had a sudden loss of power, no heat, and the engine temperature was unable to read. Engine temperature was not accurately reporting and showed it as being cold as indicated by blue light warmup light. My eyesight, pre-collision system, and sport mode was disabled due to the engine light being illuminated. The vehicle was seen at a Subaru dealer, who diagnosed the issue to be the thermo control valve. Dealership informed me that it was unsafe to drive and I risk complete engine failure, overheating, and or fire if I continue to operate without required repair. As a result, I was stranded overnight, three hours away from home. Repair was completed on [XXX] at cost of $1830. I learned at the dealership that this is a known issue, in 2021 Subaru replace the plastic components of this part with aluminum due to similar issues experience by many customers. Customers are reporting vehicles going into “limp mode” and even engine damage. I learn that there is a class action lawsuit regarding the same issue, which can be reviewed here: [XXX] Please help to recall vehicles and push Subaru to repair/refund. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 2, 2024 · Wheels · PA

vehicle feels like it is always stuck in first gear. the Subaru dealership says its a rear hub bearing, drivers side. Cost to repair over $500. The vehicle has less than 60k miles on it.

Filed Sep 20, 2023 · Electrical, Engine · TX

2019 subaru forester failed thermo control valve. There are literally 1000s of complaints on this issue and SOA refuses to issue a recall. Subaru has issued a bulletin to replace the faulty design with redesigned part. When this fails the car goes into limp mode and all lights come on. Very dangerous and quote frankly completely irresponsible that subaru refuses to recall this failure. I am out of warranty and it's minimum 2k to fix. I have a 2019 vehicle parked that I can't get Inspected and can't afford to fix because Subaru of America is trying to save money. Just a matter of time before this causes a tragic accident before they own up to recall.

Filed Jun 16, 2021 · Engine · 67,574 miles · MD

The contact owns a 2014 Subaru Forester. The contact stated while driving 60 mph, the vehicle went into limp mode and failed to accelerate while the accelerator pedal was being depressed. The contact stated no warning light was illuminated. The vehicle was not taken to a local dealer nor an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 67,574.

Filed Feb 11, 2021 · Engine, Transmission · 87,000 miles · OH

Engine using to much oil between oil changes. Transmission will not shift into final gear until driven for 10-15 miles

Filed Apr 16, 2019 · Acceleration, Transmission · 3,774 miles · NY · crash

When stopped in traffic car hesitates, stalls and stumbles to accelerate for a few seconds. Unable to shift from 1st to 2nd smoothly (stuck in 1st gear?). Was rear ended when unable to accelerate at light. Dealer did software update that did not fix problem, still ongoing