2019 Subaru Outback visibility problems

Filed Aug 3, 2026 · Visibility · 40,250 miles · WI

The contact owns a 2019 Subaru Outback. The contact stated that while driving at 70 MPH the front windshield cracked approximately 6 inches from the heat sensor, no warning lights were illuminated. The local dealer was contacted however the vehicle was not diagnosed as the contact was advised that the vehicles VIN was not included in a recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 40,250.

Filed Mar 11, 2026 · Visibility · CA

Windshield window crack without any reason couple month ago and it keep crack bigger

Filed May 21, 2025 · Visibility · GA

I have experienced two separate incidents of spontaneous windshield cracking on my 2019 Subaru Outback, with no external impact or road debris involved. The first windshield crack occurred, and Subaru replaced it under warranty after inspection showed no signs of impact. The second crack occurred again without any collision or impact. However, Subaru has now refused to cover the second incident, even though it clearly follows the same pattern. There is no visible point of impact. The cracks appear to originate near the bottom edge of the windshield and spread rapidly. I park the vehicle in a safe residential area and have not driven over rough terrain or been involved in any accidents. I have also referenced a known class action lawsuit involving similar spontaneous cracking issues with windshields in Subaru vehicles, including the 2017–2020 Outback and Legacy models. This suggests a manufacturing or design defect affecting structural integrity. This issue creates a serious visibility and safety hazard for drivers and passengers, especially if the windshield fails further while the vehicle is in motion. Subaru’s failure to cover a known defect and repeated issue puts drivers at risk. I am requesting that the federal safety agency investigate this recurring defect in Subaru windshields to determine whether a recall or broader corrective action is necessary.

Filed Apr 24, 2025 · Visibility · FL

On April 14, 2025, I experienced my fourth windshield break- others- 2 that were 3 months apart in 2023 and another in 2024. I do not know how this most recent crack occurred as I noticed it when I went to drive my car, which was parked inside my garage. I had driven 2 places earlier in the day with no signs of a crack and there were no noted strikes to the windshield during that time. I did ride on a highway the day prior, but did not hear any strikes to the windshield. The prior incidences I did hear something hit the windshield. I have been a car owner for decades and this is the first car I have ever had with any windshield crack. This complaint seems typical for this vehicle as many of the same issues were recently included in a class action lawsuit regarding a defect in the glass. Wile the 2019 model was not included for some reason, many the federal safety agency complaints from people with this model were included in this lawsuit so I certainly hope that the federal safety agency will seriously look into why these are a common occurrence for this vehicle.

Filed Mar 25, 2025 · Visibility · WA

Noticed a huge crack in my windshield this morning before leaving for work. Definitely some sort of stress fracture. Not from any kind of impact or rock chip. It was not there yesterday. This is a huge safety issue due to the suddenness and size of the crack right down the center of the windshield and then branching off to both the driver side view and the passenger side. Difficult to see while driving to work and very worried that the crack will continue to expand. I’m contacting the dealership where I purchased the car in June of 2024.

Filed Dec 10, 2024 · Visibility · 116,000 miles · CO

The contact owns a 2019 Subaru Outback. The contact stated while driving at undisclosed speeds, the front windshield cracked without impact during colder temperatures. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 116,000.

Filed Dec 4, 2024 · Driver assistance, Visibility · 85,000 miles · ID

The contact owns a 2019 Subaru Outback. The contact stated that while operating the vehicle, the display screen malfunctioned and flashed off and on. During the failure, the back-up camera became inoperable and created a visibility hazard for the driver. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 18V935000 (Visibility). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not contacted. The failure mileage was 85,000.

Filed Sep 27, 2024 · Visibility · AR

A crack in the windshield suddenly appeared with no apparent cause starting at the very upper edge about a third of the way across from the driver side and traveled about half way down and then turned to the right for about eight inches. It is available for inspection upon request. As of this date it has not been reproduced or confirmed by a dealer or independent service center. It has been reported to insurance representatives, but not inspected by the manufacturer, police, or insurance representatives. There was no warning lamps, messages or other symptoms of the problem prior to the failure.

Filed Jul 22, 2024 · Visibility · IL

Another for the list of many, many windshield cracking complaints. My 2019 Outback 2.5i Limited has had 3 replacements since I purchased it new in late 2018. The cost to replace each has certainly increased each time and is very expensive as it has to include the eyesight calibration. I'm told this is not covered in my extended warranty I purchased when the vehicle was new. Subaru needs to take ownership of the quality issue and compensate the countless owners who have had this same issue, multiple times! I've read the glass is too thin, may be intentional because of the eyesight feature. Mileage and date below are from the most recent crack I had to repair. Please let me know if you'd like more details on the first two occurances as well.

Filed Jul 18, 2024 · Visibility · KS

Severe windshield cracking requiring replacement. 2 in 6 month period. 1st was November 2023. Extremely cold temperatures. Cracked directly above heater vents on both sides same time. I watched it go from outer lower edges and move all the way to the center, entire length of the shield. I did not see anything hit the windshield, but they were iced and snow covered. I felt the temperature difference outside compared to in the cabin may have caused the crack. 2nd occurred July 12 2024. Extreme heat ( 100 plus) air-conditioning blasting cold air. Low traffic, at least 4 car lengths between mine and the car ahead. I did not see any debris. I did hear a noise, and then watched the windshield crack from the same location (lower outside edge) this time only the passenger side. The crack started approximately 6 inches. The following morning that crack had moved past midway of the windshield. This is not normal for any other vehicle I have driven. I have been driving 45 years. I have had a rock hit the windshield, some large rocks. In only one case I suffered a chip that was fixed with resin. There is a problem (safety) with this windshield. Installation, glass, design flaw?? I don't know the cause, but It is hazardous. The dealer's mechanic that replaced the 1st one told me "it is a KNOWN issue for my model" someone needs to address and correct an issue that is known which could be catastrophic. I was driving 35 mph in November incident, and 70 mph in July. I can provide documentation re: 1st replacement. I did not take pictures of that one. I can provide photos of 2nd one. I have not done 2nd replacement. I may just trade it out. That is how concerning this issue is to me.