Subaru Outback seat belt problems

Filed Jul 21, 2026 · Seat belts · CA

The back passenger seatbelt does not retract. It stays loose after use and there are safety concerns. I don't feel safe having any passengers in my car.

Filed Jul 8, 2026 · Seat belts · MO

The seat belts in the backseat get un-aligned when you sit in the seat buckled up. when this happens the seat belt will not retract. This happens every time I sit in the backseat and I have to remember to refeed the belt into the guide.

Filed Jun 15, 2026 · Airbags, Seat belts · PA · crash · 1 injury

The driver lost control of the vehicle, possibly due to a failure involving the rear driver's-side tire. The vehicle initially made contact with the guardrail, causing moderate damage to the driver's side. Following this impact, the vehicle began to fishtail, and the automatic braking system activated. The driver recalls being thrown about within the seat during the incident, as the seat belt's emergency locking retractor appeared to fail. The seat belt did not lock during the collision sequence, which is supported by the absence of visible bruising across the chest area. Prior to the vehicle's final impact with the embankment, the seat belt unexpectedly released and struck the driver on the right cheek, resulting in visible bruising. Upon the final impact, after the seat belt had released, the driver was lifted from the seat and struck her head against the door frame. The vehicle's airbags did not deploy at any point during the crash. There were no warning messages, alerts, or noticeable symptoms indicating a mechanical issue prior to the incident. The vehicle has since been towed to a local body shop for a damage assessment and further inspection.

Filed Jun 2, 2026 · Body, Seats · CA · 1 injury

I am reporting a severe saftey and crash-compatibility defect on the front passenger side of the 2026 Subaru Outback Premium trim. This vehicle is equipped with a fixed-height passenger seat that is positioned unsafely high relative to the headliner and sun visor assembly. Because the seat height cannot be lowered, an adult passenger of average height sits with their head in immediate proximity to the sun visor. Under standard deployment of the vehicle brakes, forward occupant kinematics cause the passenger’s forehead to travel collide into the rigid, unyielding lower edge of the sun visor, which act as a hard/sharp parts cut the forehead and twisting the neck seriously. During a recent braking event, this lack of structural clearance caused a direct head-strike incident. The occupant’s forehead collided with the sharp bottom edge of the visor, acting as a blunt knife edge that resulted in a laceration to the forehead and a hyper-extension strain injury to the neck. This is a critical design failure where occupant safety clearance envelope was poorly designed for this elevated fixed-seat configuration. In a high-speed collision, this layout poses an imminent risk of severe facial trauma, skull fractures, or catastrophic cervical spine injuries from the visor before the seatbelt pre-tensioner can fully lock. This requires immediate investigation and a mandatory safety recall to provide height-adjustable/lower seat frames to affected vehicles.

Filed May 12, 2026 · Seat belts · MA

The seatbelts in the back row when uses occasionally lock up, when driver is not hitting the breaks and it let go, then as you try to loosen the seat belt it, it retracts more and more tightening more and more to the point that it feels like there is a rope going through your neck, the only way to make seat belt loosen is to completely take it off let it fully go back to place then put it back on again. This is an intermittent issue and it does not happen every time. But it does happen often enough that once my back seat passengers had to ride without seatbelts because of it

Filed Oct 31, 2024 · Airbags, Seat belts · 80,000 miles · AZ · crash · 1 injury

The contact owned a 2013 Subaru Outback. The contact stated while driving at approximately 35 MPH, he lost control of the vehicle and crashed into a metal guard rail on the driver's side along the length of the vehicle. The contact stated that the vehicle had bounced off of the rail and the front end on the passenger side had crashed into a metal post on the right side of the road. The contact stated that the force of the crash ejected him through the windshield. The contact stated that EMS and firemen were on scene but there was no police. The contact stated he had not lost consciousness. The contact was transported by ambulance to the emergency room. The contact had lacerations on his forehead, scalp, nose and chin. The contact had bruises on his chest, shoulders, both arms, and both legs. The contact stated that he was diagnosed with a Traumatic Brain Injury. The contact stated that his insurance provider declared the vehicle a total loss. The contact was advised by his insurance provider that the air bags and the seat belt had failed to function. The vehicle was towed to an impound lot. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.

Filed Aug 8, 2022 · Seat belts · OH

No component failed or malfunction. It is working as designed but it is a serious safety concern that can not be addressed except by purposely bypassing the safety system or systems. For whatever reason Subaru added rear seat belt chime alarms to the rear seats. Three in total it appears. Driver, passenger, and center. The chimes will continue to grow louder until it blocks all radio and becomes a distraction. In theory this is not a bad idea. In practice it is a safety concern. Subaru markets their vehicles as being pet friendly. The issue is when I have my dog in the back seat the seat beat alarm continues to go of sporadically and she is not done growing yet. I don't use harness/restraints but even if I did there would be no way to keep her in the correct position to not make the adjacent seat chime. This is a major distraction while driving because I have to constantly take my eyes off the road and try to reposition her to stop the chime/alarm. It is also putting others at risk as I am not focused on driving. Problem confirmed by the dealer and Subaru (SOA) with no plan to fix except cut wires, buy seat belt buckles from Ebay to stick in holder, or clip seatbelts when not in use. Concern is this will cause passengers to not buckle up due to the hassle. Safety can't be an inconvenience or there is less chance it will be followed. No police have been involved. Dealer and SOA have confirmed it is a problem with no solution. Possible software update in the future. Not a failure but a design flaw.

Filed Nov 15, 2021 · Electrical, Transmission · ID

Battery corrosion on terminal post and drained for no reason, failed battery test and had to be replaced. Windshield has imperfections throughout and cracks easily. Shift mechanism will not release the vehicle key while in park. Squeaking sound emanating from passenger seat belt buckle. Excessive exhaust noise and odor from exhaust pipe. Rear hatch will not close completely unless slammed very forcefully. Belts under the hood squeak very loudly when started and subside when warmed up.

Filed Jul 13, 2021 · Seat belts · MI

Passenger side front seatbelt locked up and became non-functional, unable to be used. This left our passenger without a safe or legal way to ride in the vehicle with all other seats being used. The part was replaced by the dealer under warranty

Filed Jun 30, 2021 · Seat belts · IL

The passenger seat belt is not staying buckled in, it take about 3 tries before it clicks.