Brake line rotted away all brakes and fluid lost
The worst 1999 Suzuki Grand Vitara problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system24
- Engine20
- Brakes16
- Airbags12
- Transmission12
- Acceleration10
- Seat belts4
- Steering4
- Suspension4
- Visibility4
- Body3
- Electrical3
- Tires3
- Locks1
- Seats1
- Wheels1
Specific symptoms reported on the 1999 Suzuki Grand Vitara
Recalls 4
Service brakes, hydraulic: foundation components: disc: rotor
- What is wrong
- On certain sport utility vehicles equipped with 16-inch wheels, the front brake discs may break under severe driving conditions. The breakage can occur in conditions where the vehicle is driven on a regular basis on extremely steep paved down-slopes while continuously applying the brakes.
- Risk
- The front brakes may become inoperative and the vehicle may pull to one side. This could result in a crash without prior warning.
- Remedy
- Dealers will replace the front brake discs on these vehicles. The recall began on november 10, 2005. These vehicles are located on st. Thomas island (virgin islands). Owners may contact suzuki del caribe at 787‑622‑0600.
Recall number 05V452000 · Recall details
Fuel system, gasoline
- What is wrong
- On certain passenger vehicles, under ambient temperatures below -25 degrees celsius, moisture can freeze in the fuel pressure regulator. As a result, fuel system pressure may increase at the time of engine start up, causing fuel loss at the fuel pipe/fuel hose connection.
- Risk
- Fuel loss in the presence of an ignition source could result in a fire.
- Remedy
- Dealers will replace the fuel pressure regulator, the fuel deliver hose and replace the hose clamp with an improved clamp. The recall began on september 29, 2004. Owners should contact suzuki at 1‑800‑934‑0934.
Recall number 04V427000 · Recall details
Vehicle speed control: cables
- What is wrong
- On certain sport utility vehicles, the accelerator cable casing cap that is attached to the vehicle firewall can crack due to extended exposure to forces from the accelerator cable and insufficient long-term durability of the plastic casing cap. If the casing cap becomes cracked, movement of the inner accelerator cable through the cap can cause the inner accelerator cable to become frayed.
- Risk
- If the inner accelerator cable becomes frayed, it can stick during vehicle operation. In the case where an accelerator cable sticks, the driver could have difficulty controlling vehicle speed, which could result in a crash.
- Remedy
- Dealers will replace the accelerator cable, which includes the plastic casing cap. Owner notification began on january 5, 2004. Owners should contact suzuki at 1‑800‑934‑0934.
Recall number 03V512000 · Recall details
Fuel system, gasoline: fuel injection system
- What is wrong
- Vehicle description: sport utility vehicles. Under temperatures below -25 degrees, moisture can freeze in the fuel pressure regulator. Fuel system pressure could increase at the time of engine start up, causing fuel loss at the fuel pipe/fuel hose connection.
- Risk
- Fuel loss in the presence of an ignition source could result in a fire.
- Remedy
- Dealers will install a redesigned intake manifold vacuum union and a new fuel pressure regulator. Owner notification began june 4, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact suzuki at 1‑800‑934‑0934.
Recall number 01V146000 · Recall details
Technical service bulletins for the 1999 Suzuki Grand Vitara 13
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Reminder of the importance to conduct safety inspections for rust damage to suspension and related parts...
- This Service Bulletin was sent by Suzuki Motor Corporation to its authorized Suzuki automobile...
- Exhaust noise CAN be heard from under the vehicle
- Modification of main bearing oil clearance and the bearing selection procedure
- Modification of main bearing oil clearance and the bearing selection procedure
- Oil leaking from left front of engine
- Oil level reads at low mark on oil level dip stick
- Revised repair procedure for air conditioner evaporator freeze-up during use
- Diagnostic trouble code, B1026 flow table
- Oil weepage/seepage from left front of engine
1999 Suzuki Grand Vitara fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 2.5L 6‑cyl | RWD | 17 | 19-20 | 18 |
| 2.5L 6‑cyl | 4WD | 16-17 | 19-20 | 17-18 |
What 1999 Suzuki Grand Vitara owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 1999 suzuki grand vitara. While driving approximately 5 MPH, a fuel odor emitted inside the vehicle. When the vehicle was parked, the contact discovered fuel leaking from the vehicle. The vehicle was taken to a dealer where the technician stated that the vehicle was included in the federal safety agency campaign numbers: 01v146000 (fuel system, gasoline) and 04v427000 (fuel system, gasoline), but was not diagnosed or repaired to due the mileage of the vehicle. The manufacturer was notified of the failure. The failure mileage was 163,000.
The vehicle at highway speeds from 45 to 55 miles per hour will lose complete power dropping from 45 or 55 to 10 or 15 MPH very rapidly when this happens you have no control of acceleration or vehicle till it reaches the 10 to 15 MPH range leaving you in a very dangerous position if you are not close enough to the shoulder of the road to pull off leaving you the possibility of being in a collision with faster approaching vehicles from the rear this is a serious problem that could result in death from a rear end collision and appears to be a common problem with this vehicle. Something needs to be done about this and the dealers have no explanation for this failure. This has been an on going problem from july of 2012 to the current date of 2/4/2013.
Tl*the contact owns a 1999 suzuki grand vitara. The contact stated that when starting the vehicle, she would hear a loud squeaking noise. Also when she made turns at low speeds, the noise gets louder. The vehicle was inspected by several independent mechanics and they were unable to diagnose the failure. The failure mileage was approximately 98,000. The VIN was unavailable.
Consumer expresses discontent regarding recall from suzuki corporation *tgw the consumer stated he received a recall letter stating it was the second notice, but he never received the first notice. The consumer was told the repairs would need to be performed by trained mechanic which was 80 miles away.
Tl*the contact owns a 1999 suzuki grand vitara. The contact stated that the brakes made a grinding noise and the brake adjustment pin in the rear driver side wheel was loose. The spring that held the wheel in place failed, which allowed it to move freely inside the brake drum. The spring flipped up and caused the brake shoe, drum, and braking kit to fail. Prior to the failure, aamco inspected the rear and front brakes and stated that they were 50% worn. The contact placed the wheel back on the vehicle and drove approximately six blocks when he heard the noise. The contact took the vehicle back to aamco because the grinding noise became very loud. Aamco stated that the failure was not caused by the inspection. The contact called suzuki's customer service line to find out if the failure was common. Suzuki stated that no one could talk to their technical department unless they were a dealer. The contact notified the suzuki dealer so that they could call the manufacturer. The purchase date was unknown. The current and failure mileages were 31,734.
When I brake my car pulls to one side and loses control. It is like it is on ice and one time it spun around, even thought I was going slow. My car is regularly maintained.
Dt*: the contact stated the airbag light is constantly illuminated. The dealership has replaced the airbag system module twice, but the problem returned. The windshield wipers were inoperative. Updated 06/19/06.
Vehicle suddenly and unexpectedly loses complete engine power at highway speeds and vehicle speed rapidly drops to under 10 MPH. Engine runs very rough and there is no response when depressing accelerator pedal. Must immediately pull over (if possible) as vehicle is not drivable. After waiting several minutes, engine operation returns to normal but power loss will usually reoccur anytime as quickly as within the next several minutes or as long as a day or two. Engine power loss may last as little as a minute or two or for several minutes and check engine light comes on.
Consumer complaint regarding there no longer being a suzuki dealer in his area and can not get recall work done. *ts *the consumer requested that suzuki could make arrangements for the installation of the safety recall. The consumer would have to drive 120 miles in order to have the vehicle repaired.
Compare the 1999 Suzuki Grand Vitara
Other model years
199920002001200220032004200520062007200820092010201120122013
Questions about the 1999 Suzuki Grand Vitara
Is the 1999 Suzuki Grand Vitara reliable?
Owners have filed 108 complaints about the 1999 Suzuki Grand Vitara, 5.4 times a typical Grand Vitara model year.
What is the most common problem with the 1999 Suzuki Grand Vitara?
Fuel and propulsion system, with 24 complaints. Next is engine (20).
How many recalls does the 1999 Suzuki Grand Vitara have?
4 recalls, covering service brakes, hydraulic, fuel system, gasoline and vehicle speed control.
Was there a recall on the 1999 Suzuki Grand Vitara fuel system?
Yes, 2 recalls: 04V427000, 01V146000. Check your VIN to see if your car still needs the free repair.
What year does the Suzuki Grand Vitara have the most fuel system problems?
The Suzuki Grand Vitara model years with the most fuel system complaints are 2000 (26 complaints) and 1999 (24 complaints).
What gas mileage does the 1999 Suzuki Grand Vitara get?
Official estimates for the 1999 Suzuki Grand Vitara range from 17 to 18 mpg combined. The most efficient version (2.5L 6-cyl, RWD) gets 17 city and 19-20 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Suzuki Grand Vitara?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history