Magnets in stator keep separating in very hot conditions causing a situation where the motorcycle could suddenly shut off and/or unable to power back on at stand still / idle
The worst 2005 Suzuki SV1000S problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical3
- Engine1
- Transmission1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical3
- Engine1
- Transmission1
Recalls 1
Fuel system, gasoline: storage: tank assembly
- What is wrong
- On certain california-specification model motorcycles, repeated stress from vibration can cause a crack to form in the area where the liquid/vapor separator bracket is welded inside the fuel tank. This can allow fuel leakage to occur.
- Risk
- Fuel leakage in the presence of an ignition source can result in a fire.
- Remedy
- Dealers will replace the fuel tank free of charge. The recall began on february 3, 2006. Customers may contact american suzuki at 714‑572‑1490.
Recall number 06V013000 · Recall details
What 2005 Suzuki SV1000S owners say
Most recent owner complaints, unedited.
The charging system on this motorcycle has no warning when it quits working. Since it is a fuel injected vehicle, with constantly on headlights it will run down a perfectly good battery when the charging system fails. *tr the charging system has a latent defect in the rotor. The magnets are attached with an adhesive. The amount of adhesive is minimal, leading to the release of the magnets. The attachment is poor at best from a design standpoint. The magnets need to be secured either with rivets in recesses in the metal rotor. When the magnets fall off, the charging system fails. The problem is that the vehicle quits with no warning. In my specific case it happened at rush hour, on a four lane 55 MPH road with no shoulders. Luckily I was able to get out of the way of the other vehicles or I would not be able to write this. This is a real safety issue for the rider. This charging system is the same in quite a few suzuki motorcycles. I believe it is used in all the 1000 cc v-twin engines for quite a few years. The internet is full of these issues. I have saved the rotor in the event that you want it for further analysis. As you can see it does not take many miles for it to fail. This vehicle is in excellent condition and has been very well maintained. The rotor and stator are inside the engine, there is no chance of inadvertent damage causing this.
The magnets on the flywheel came off and shattered causing the motorcycle to die.
Compare the 2005 Suzuki SV1000S
Other model years
Questions about the 2005 Suzuki SV1000S
Is the 2005 Suzuki SV1000S reliable?
Owners have filed 3 complaints about the 2005 Suzuki SV1000S, fewer than a typical SV1000S model year.
What is the most common problem with the 2005 Suzuki SV1000S?
Electrical system, with 3 complaints. Next is engine (1).
How many recalls does the 2005 Suzuki SV1000S have?
1 recall, covering fuel system, gasoline.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Suzuki SV1000S?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history