Tl* the contact owns a 2008 suzuki vl800tk8. The contact stated that the vehicle was experiencing the same failure as indicated in a recall for the electrical system. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The vehicle was not included in the recall, although the vehicle experienced the same failures listed in the recall. The federal safety agency campaign number was unknown. The failure mileage was 11,000. ..updated 06/08/16 *bf the consumer stated the battery would die for no apparent reason. The battery was replaced. However, the problem continued.
The worst 2008 Suzuki VL800 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical2
- Fuel system1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical2
- Fuel system1
Recalls 1
Electrical system: alternator/generator/regulator
- What is wrong
- Suzuki is recalling certain model year 2008 through 2010 motorcycles manufactured from july 2007 through september 2009, equipped with regulator/rectifier assemblies, suzuki part numbers 32800-41f11, 32800-15h10, 32800-05h11, 32800-41g10, 32800-15h00, 32800-18h00, 32800-05g10, 32800-10g10, 32800-05h20, or 32800-06g01. Some regulator/rectifier assemblies were produced with insufficient adhesion between the power module (circuit board) and the rectifier case that contains a heat sink to dissipate heat. Due to insufficient adhesion, heat generated on the power module circuit board can cause the circuit board to deform, and lift of the case.
- Risk
- This condition causes excessive heat on the circuit board and uncontrolled electric current output, which can result in insufficient charging current being provided to the motorcycle battery. This can cause discharge of the battery and can lead to engine stalling and/or a no-start condition. Engine stalling while riding can increase the risk of a crash.
- Remedy
- Suzuki will notify owners and suzuki distributors will replace the regulator/rectifier with an improved part free of charge. The safety recall began on march 2, 2011. Owners may contact suzuki at 1‑714‑572‑1490.
Recall number 11V108000 · Recall details
What 2008 Suzuki VL800 owners say
Most recent owner complaints, unedited.
Tl*the contact owns a 2008 suzuki boulevard m109r vl800 motorcycle. The contact stated that when the fuel tank was low on fuel, the vehicle would stall sporadically. The fuel tank was not empty and the vehicle would often fail to restart unless the fuel tank was full to capacity. The vehicle was taken to an authorized dealer where they were unable to diagnose or repair the failure. The vehicle was not repaired. The failure mileage was 3,000.
Suzuki safety recall campaign (rectifier assemblies) I took my motorcycle in to the dealer for this safety recall assuming they would be able to take care of it quickly. The bike has now been in their shop going on three weeks waiting for the recall part to be replaced. Suzuki is being very slow to provide their dealers with this part. They(the dealer) have no idea when they will get the parts. This in turn means that I do not have use of my bike. Suzuki needs to make these recall parts available to their deals as soon as possible.
Compare the 2008 Suzuki VL800
Other model years
Questions about the 2008 Suzuki VL800
Is the 2008 Suzuki VL800 reliable?
Owners have filed 3 complaints about the 2008 Suzuki VL800, close to a typical VL800 model year.
What is the most common problem with the 2008 Suzuki VL800?
Electrical system, with 2 complaints. Next is fuel system (1).
How many recalls does the 2008 Suzuki VL800 have?
1 recall, covering electrical system.
Was there a recall on the 2008 Suzuki VL800 electrical?
Yes, 1 recall: 11V108000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Suzuki VL800?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history