I had the timing chain replaced at approximately 100,000 miles under warranty. It had to be replaced at approximately 200,000 miles. The timing chain failed at approximately 210,000 miles and stopped running while being driven. The timing chain should not need to be replaced so often and I have heard of similar complaints on various web sites and from other sources.
The worst 2006 Suzuki XL7 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Airbags10
- Steering5
- Brakes3
- Electrical3
- Engine3
- Transmission3
- Suspension2
- Acceleration1
- Body1
- Driver assistance1
- Fuel system1
- Locks1
- Seats1
- Tires1
Specific symptoms reported on the 2006 Suzuki XL7
Recalls 2
Steering: hydraulic power assist: pump
- What is wrong
- Suzuki is recalling certain model year model year 2006 grand vitara and model year 2005-2006 xl-7 vehicles. The tension adjuster pulley for the drive belt that operates the power steering pump and air conditioner compressor (if equipped) has an outer portion that is made of plastic. Repeated heat stress can cause the plastic material to deteriorate and pieces of the pulley can break off.
- Risk
- Broken pieces of the pulley can get caught between the pulley and the drive belt, causing the drive belt to come off and resulting in the driver needing increased effort to steer the vehicle increasing the risk of a crash.
- Remedy
- Dealers will replace the power steering pump drive belt tension adjuster pulley free of charge. The safety recall began on june 28, 2010. Owners may contact suzuki at 1‑800‑934‑0934.
Recall number 10V250000 · Recall details
Service brakes, hydraulic: foundation components: disc: rotor
- What is wrong
- On certain sport utility vehicles equipped with 16-inch wheels, the front brake discs may break under severe driving conditions. The breakage can occur in conditions where the vehicle is driven on a regular basis on extremely steep paved down-slopes while continuously applying the brakes.
- Risk
- The front brakes may become inoperative and the vehicle may pull to one side. This could result in a crash without prior warning.
- Remedy
- Dealers will replace the front brake discs on these vehicles. The recall began on november 10, 2005. These vehicles are located on st. Thomas island (virgin islands). Owners may contact suzuki del caribe at 787‑622‑0600.
Recall number 05V452000 · Recall details
Technical service bulletins for the 2006 Suzuki XL7 3
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 2006 Suzuki XL7 owners say
Most recent owner complaints, unedited.
I went out to start my vehicle one morning. After turning the ignition on, the airbag light on the instrument cluster came on, and at the same time the passenger airbag notification light started flashing on the center console. The vehicle was stationary. After calling the local dealership who works on suzukis here, I was told this is a very common problem with this m/m/y of vehicle, and that the repair is between $1.5k-$2k. My vehicle is not old, abused, nor has it been in an accident. With the miles at approx 61,000... Why is there a safety issue regarding my airbag system? After digging around online, I found that this m/m/y vehicle does, in fact, have a large complaint against it regarding the airbag system. Most specifically the exact issue I am having. In light of the massive airbag recall issue, one would assume safety is of utmost importance. I think this issue needs to be addressed.
I was driving my children home and I heard a thudding in the engine like something was breaking. The air conditioner went hot instantly and I tried to change lanes to pull to a stop to look at it. When I stopped and tried to turn the corner, I found it very difficult to steer. I couldn't turn properly and was turning wide into the other lane because of this. My 4 wheel drive went into motion and now I have to click the button to be able to reverse or steer properly (so that I'm not on the 4 wheel drive setting) but the light for the 2 wheel drive blinks. My brake light and check engine light are on.
Suzuki has not provided information about their vehicles for the air bag recall. As a 71 year old, weighing only 90 pounds, I am concerned about the air bags in my car. Since suzuki pulled their auto unit out of the us a few years ago, those of us who purchased a suzuki have been left hanging high and dry.
The fuse that goes to the fuel injectors keeps blowing, it only blows half of the fuse, every few weeks, the car won't start and the fuse has to be replaced.
When slowing down to turn , brakes would not work at all, had to pull the emergency brake to stop. My young son was in the car, this could have ended badly.
Front passenger airbag light comes on when the seat is empty and the seat belt is not buckled. The light constantly flashes and beeps.
One day when I go to start my car when I turn the key, a static noise comes from where the key goes. Vehicle started but while driving, would loose power and act like it is going to cut off.
When getting on the interstate, car suddenly lost speed but RPM's kept going up, could not go over 40, when pulled over, put in park but engine kept revving up.
I was driving down the highway and without warning my back axle came off. I was able to safely move my vehicle over to the right shoulder. I had been traveling with my family the sparks caused the vehicle to caught on fire. I took the truck to the body shop and no one could give me a explanation as to why the axle came off. My truck is currently being repaired, this has cost me unforeseen experiences for car rentals and missing work to get my vehicle repaired.
Compare the 2006 Suzuki XL7
Other model years
Questions about the 2006 Suzuki XL7
Is the 2006 Suzuki XL7 reliable?
Owners have filed 28 complaints about the 2006 Suzuki XL7, close to a typical XL7 model year.
What is the 2006 Suzuki XL7 year score?
The 2006 Suzuki XL7 scores 65 out of 100 (average). The score compares it with the other model years of the Suzuki XL7: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2006 Suzuki XL7?
Airbags, with 10 complaints, typically around 60,294 miles. Next is steering (5).
How many recalls does the 2006 Suzuki XL7 have?
2 recalls, covering steering and service brakes, hydraulic.
What year does the Suzuki XL7 have bad airbags?
The Suzuki XL7 model years with the most airbags complaints are 2007 (28 complaints), 2004 (27 complaints) and 2006 (10 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Suzuki XL7?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history