Passenger Airbag and seat are faulty. Received error message on my car “front passenger safety restraint system faulty”. Tesla is wanting to replace the airbag and passenger seat and seat belt and it will cost few thousands dollars.
2018 Tesla Model 3 airbags complaints
Page 4 of 6: complaints 71 to 100 of 144, newest first, as owners wrote them.
My car has 98,000 miles and out of warranty. When driving 10 days ago I saw a message on the screen "Front Passenger Restraint System Fault" I took the car to the Tesla Garage and was advised that it might be the air bag. They said it could cost as much as $$1,826.66. They kept the vehicle and sent a message asking me to authorise my credit card pay this amount when done. First of all I note on the Tesla Motors Club that I am not alone. Second I have to rely on Tesla being honest about this. They have their own propriety testing system so I could not take it to another mechanic. Last of all I have never experienced a failed air bag in my vehicles before and it seems that Tesla has problems and this should have been paid by them as a recall item
A defect in manufacturing causes the seat sensor (in this case: passenger) connection to fail. The connection has no retaining clip and falls out. This disables the airbag deployment calculations. Error code: RCM_a056 Telsa wants to replace seat and calibrate airbag at consumer's cost, Quoted ~$1500 I've pushed the connector back in several times over the past few years, one day it's going to hurt someone.
Front passenger seat restraint safety system fault. My car only has 40,000 miles is out of warranty. $2200+ estimate from Tesla. This safety issue happens often according to Tesla Owner sites.
Experienced safety restraint system failure on all four seats. Had them all fixed for ~$2,000. Front passenger restraint failed again next month. Know. Issue among the message boards online. Investigation into number of these repairs is likely merited.
Car displayed safety restraint system fault RCM_a094. Tesla diagnosed as rear seat buckle sensor failure. Additionally, car displays an intermittent fault RCM_a056. Tesla diagnosed this as a front passenger Occupant Classification System (OCS) sensor fault. Tesla stated the front passenger airbag would need to be replaced as the new sensor is not compatible with the older airbag. This renders the entire airbag system inoperable due to this component failure. The critical safety issue is extremely expensive as the incompatible sensor requires expensive airbag replacement. Furthermore, the safety system is prone to failure with 2 safety system faults occurring at <80k miles. Service rep stated that the 2018 model year has had issues with the airbag system that is why they updated the module. I asked for recall or replacement at Tesla cost but was denied. Facebook group discussions and search indicate others have intermittent OCS sensor failure and this is likely a defective part for that year.
Front Passenger OCS errors - Tesla work quote (via Tesla Service Bulletin, not Recall) is to replace the OCS system & front airbag - totaling $1,200 for the repair. This is extremely common error code for Tesla's "Front Passenger Safety Restraint System Fault".
I purchased the car new in 2018. About two years into owning there would be a random notification about an "rcm_a036 : passenger safety restraint system fault". I reported and was told that the seat occupancy sensor was responding to noise from my cell phone. I stopped putting the cell phone on the seat, it kept happening with increasing frequency in 2021 and 2022 and I reported it two more times and was told to keep charging cables away from the seat, and then in 2021, they added a noise filter. I was told repeatedly that the fault was caused by noise and was not a real issue. The alert occurred with increasing occurrence and today I took it in and Tesla charged $1533.16 to replace the airbag and the occupancy sensor. I thought it was unsafe for Tesla to tell me the issue is a noise-related issue when it was related to the airbag and to tell me that the issue was not actually a real fault when both the OCS sensor and the airbag needed to be replaced. I think it's absurd to have a car 6 years old with 66,530 miles have to have an airbag replaced. I thought Tesla's comments about noise were disingenuous attempts to put off the repair until after the car was out of warranty.
I'm getting an error for "Safety restraint system fault" on my Tesla Model 3. When I booked a service appointment it turns out they are wanting to charge $1,955.11 for replacing the Occupant Classification System (OCS) of the front passenger, updating the front passenger airbag, and installing a OCS filter module. This seems to be safety related and should be part of a recall. I have seen similar reports from other drivers on Reddit.
Two recent incidents/repairs related to both driver and passenger Curtain Airbag, replacement of Occupant Classification System, replacement of first row seat cushions, first row harness assembly, first row occupancy sensor, first row seat belt reminder sensor box. Total out of pocket cost of approximately $2,075!
First. the car gives Front Restraint System Fault message and Tesla fixed during warranty. No, it's out of warranty, and the car starts giving Front Passenger Restraint System Fault warning message. Regardless if it's under warranty or not, restraint system fault (I take it as seat belt) imposes safety concern and should be a recall item.
Front passenger airbag and Seat sensor issues. The safety of front seat passenger was at risk due to faulty airbag or sensor. Tesla did confirmed that an alert was trigger on the car an they proceeded to replaced the airbag and sensor. Tesla verified the equipment after the repairs were done and everything since to be fine. We did get a warning on or around Feb 5th, 2024 and that when we proceeded to contact Tesla service and make an appointment. The reason for this complain is that we ended up paying for airbag and seat sensor repairs which should have been covered by Tesla since these parts are obviously defective. Please see uploaded documents for more details.
The contact owns a 2018 Tesla Model 3. The contact stated that while starting the vehicle, the message "Front Passenger Safety Restraint System Fault" was displayed. The local Tesla Service center was notified of the failure and informed the contact the front passenger's side seat and air bag needed to be replaced; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 47,000.
I have three potential safety hazards to report. Tesla has advised that there is no recall for any of these. 1) The car issued an alert that says "Front Passenger Safety System Fault." This seems like the most serious. 2) The horn malfunctions and does not work at safe level 3) The driver's side mirror does not consistently extend out preventing the driver from adequately using the mirror for driving.
the airbag light shows
Front Passenger Safety Restraint System Fault. My airbags are faulty and I'm having to replace them at full price. Ive never hit anything and never been in an accident.
There is an ongoing issue with Tesla's seat sensors that give an error screen while driving. Tesla seems to be systematically charging a standard $1.5K repair to replace a $100 sensor harness, but they're charging so much because they claim an airbag replacement is required (for an extra $1.2K) as part of the new sensor/wire harness installation. From a quick google search, it seems this is a pretty widespread issue that MANY Model 3/Y owners are encountering as their car ages-- with many noting that they were able to self-service the issue with buying the required harness and replacing it themselves. I wanted to bring awareness that to this issue and Tesla's poor and systematic way of overcharging customers to fix a widespread defect in their car seat design.
Airbag failed at 60k miles requiring a replacement. This is a known- safety issue, Tesla has corrected this problem in later cars, and Tesla should issue a recall to correct. I have error codes RCM_a015 and RCM_a014
My car went out of warranty for seat related issues in December of this past year 2023. I don't even have 26K miles on my car therefore not a heavy driver. This week I experienced an error RCM_a021, front left safety restraint system fault, which I've researched has affected many others and appears to clearly be a safety flaw. The service team mentioned this isn't covered. My airbag light doesn't go off and is constantly on, my seats no longer save the seat setting (which occurred a couple of months ago but I didn't think about it).This is a safety hazard should I get into an accident. There were no previous warning issues prior to this warning error which occurred this week. According to Tesla, if the airbag light remains lit, schedule a service appointment immediately and do not drive. The service team mentioned the seat harness is faulty remotely and according to what they can see. I have not had them look visually yet though. They do not cover the repair for this as it's out of warranty. There's even a bulletin posted on this issue/repair by the federal safety agency therefore is known problem. [XXX] I'm unable to upload any files. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
When driver seat adjusted to end positions (e.g all the way up/down/forward/backward), it causes an error message stating “Front left safety restraint system fault” & and airbag failure icon would appear. This usually cause by the wire harness being pinched or stretched. The error message may come and go based on the position of the seat, and occurs more frequently as time goes by. I am concern that the airbag or other safety restraint system may fail to engage when the message pops up. Tesla community has reported similar failure.
My Model 3 began giving an RCM_a056 error indicating a fault with the front passenger safety restraint system. When I scheduled service for this fault at Tesla, they advised that the front passenger airbag and occupant sensor for the right/front seat needed to be replaced. Research into this issue revealed at it is a common issue. Other owners reported Tesla covering the cost of this repair (indicating they know this is a manufacturer defect in a major safety system and not a one-off issue.) Unfortunately, Tesla refused to repair this issue without payment, insisting that my SRS warranty had expired. I believe this is a manufacturer defect in a critical safety system that should be investigated for a possible recall.
I had a seat weight sensor error. Took into repair and the replaced sensor and then informed me they need to replace airbag because it’s not compatible with the new sensor. Then was told that it would cost $1100 more than estimate to replace an airbag that is in working condition. Tesla purposely replaced sensor that was not compatible with the way they built the car and expect consumer to pay for it.
I kept getting notifications indicating that there was a Front passenger safety restraint system fault - RCM_a056. On reaching out to Tesla service, I received an estimate for more than $2000 to fix and they appear to be replacing the seat, occupant classification system or sensor, and also Front passenger airbag. I found many instances of this issue on online forums(with different error codes) and I am worried that this may be a widespread safety issue related to the seat belts or corresponding components which may prevent them from detecting occupants or failing to prevent injury in case of a crash.
Intermittently over the past two months, the vehicle has been showing error code RCM_a056 with the accompanying message: Front passenger safety restraint system fault Service is required I reached out to Tesla and the service estimate was nearly $1500 to replace the Airbag "to maintain compatibility with Front Passenger Seat" for $942 and $414 to replace the Occupant Classification System (OCS) of Front Passenger Seat plus taxes. Basically, they want to replace the airbag and the seat sensor system. Many people on the forums have reported the same issue, which is sometimes fixed by replacing both components, just the sensor, or reseating the sensor cable. This is clearly a safety issue caused by a defect and these critical components should not fail this catastrophically in just 5+ years.
Vehicle displays alert "Passenger Safety Restraint System Fault." Tesla repaired my vehicle last year for this same alert and now it has returned. Tesla claims the Occupant Classification System and passenger airbag must now be replaced. These critical safety components should not fail only 5 years after I purchased this vehicle. Many other Tesla owners report this same issue indicating it is a safety-related defect.
Car no under warranty anymore. Front left safety restraint system failed (It looks like the cable is a little too short to accommodate the full range of the seat and ends up getting damaged) . It looks like a widespread issue on online forums.
The contact owns a 2018 Tesla Model 3. The contact stated while driving at approximately 35 MPH, the Front Passenger Safety Restraint System (FPSRS) fault warning illuminated. The contact continued driving and later contacted the manufacturer. The contact was advised by the manufacturer that he had the option to repair the Safety Restraint System by a mobile technician or the vehicle could be driven to a dealer. The vehicle had not been repaired. The contact stated that the Restraint System fault warning failure was intermittent at first but had become a recurring failure. The contact researched online and related the failure to the FPSRS wiring located under the seats, which was being damaged by the seat auto adjustment feature. The seat adjustment feature moved both seats to an upright and back position to allow ease of entry of the driver and passenger. The manufacturer had been informed of the failure. The failure mileage was approximately 58,900.
The contact owns a 2018 Tesla Model 3. The contact stated while driving at an undisclosed speed, a message was displayed alerting the driver to a passenger safety restraint fault. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular failure. The air bag warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 21V389000 (Seat Belts) but the VIN was not included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 60,000.
For the past 2-3 weeks, my vehicle has been intermittently displaying an error message that reads “Front left safety restraint system fault,” accompanied by the error code RCM_a021. This error has been appearing nearly every day and seems to indicate a malfunction in the Restraint Control Module, specifically relating to the front left safety restraint system. Importantly, the vehicle has not been in any accidents, and no recent repair work has been done that could explain the onset of this issue. This malfunction poses a significant safety risk. The front left safety restraint system, which includes crucial components like the seat belt latch sensor and the pretensioner system, is designed to protect the driver in the event of an accident. Given the critical nature of these safety features, the issue at hand could compromise the vehicle’s ability to protect its occupants, thereby placing both the driver and passengers at considerable risk. The vehicle has not been inspected or diagnosed by a Tesla dealer, an independent service center, or any other entity such as police or insurance representatives. This absence of professional evaluation further underscores the urgency for a thorough investigation into the root cause of this fault. There were no precursors or warnings prior to the appearance of this error message. The issue spontaneously manifested and has been consistently reoccurring. This lack of predictability elevates the risk associated with the fault, making it vital to investigate and resolve it expediently. The intermittent but consistent fault code RCM_a021 affecting the front left safety restraint system in my 2018 Tesla Model 3 is a significant safety concern. Given the absence of any recent repair work or incidents or recalls that could account for this problem, along with the lack of any professional diagnostic evaluation it’s my hope that the federal safety agency and Tesla take appropriate action to investigate and resolve this potential safety defect.
The front passenger seat driver occupancy system started sporadically malfunctioning and showing the "air bags disabled" warning even while the seat was occupied. This would put the passenger at risk in the event of a crash. The manufacturer's technician arrived to inspect the vehicle and upon hearing the description of the problem said it was likely that a cable in the seat's wire harness probably wore out from friction and that "it was a common issue in these vehicles". Upon examining the wire harness the technician confirmed that this was the issue, and the harness had to be replaced.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Tesla Model 3?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history