2022 Tesla Model 3 brakes problems

Filed Oct 24, 2026 · Brakes, Steering · AZ · crash · 2 injuries

In a rented 2022 TESLA MODEL 3 entering a right veering on-ramp, the vehicle failed to respond to driver steering inputs at normal speed. I released the accelerator and there was no degenerative braking. I applied brakes, but the ABS was violently shaking without stopping and I noticed something illuminate on the computer screen. Unable to turn the steering wheel at all, we made severe impact with the left guardrail injuring both my wife([XXX]) and I. The Steering Assist Reduced warning light remained illuminated after the accident and I took a picture. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 6, 2026 · Airbags, Brakes · CO

"Subject vehicle (2022 Tesla Model 3, VIN: [XXX]) was deployed for commercial rideshare passenger transportation by fleet operator Hertz/Uber with active catastrophic life-safety system failures. Onboard Tesla Service Mode telemetry confirmed: (1) Restraints Control Module (RCM) is powered OFF with status 00, leaving primary front and knee airbags and seatbelt pretensioners completely inoperative during public commercial transit; (2) Master Cylinder Hydraulic Brake Pressure telemetry is registered as 'Unavailable' under iBooster (IBST) and Electronic Stability Program (ESP); (3) Steering torque calibration offsets of -97 Nm and -14° angular pulling bias were applied to compensate for structural suspension collision damage; (4) Active diagnostic trouble code VCFRONT_a611 radiator heat rejection failure causing severe battery and powertrain thermal throttling; and (5) Non-functional windshield wipers and blocked camera sensors violating FMVSS 104 and FMVSS 208." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 3, 2025 · Brakes, Driver assistance · CA

Tesla Model 3 while using the “FSD” or auto pilot mode will do what’s called “phantom breaking” with its emergency breaking system. This is very scary and has almost caused more accidents than preventing them in my experience. Tesla had not addressed or fixed this issue even with their constant software updates. How is this FSD considered legal I wonder.

Filed Aug 9, 2025 · Brakes, Driver assistance · CA · crash

I pulled up to a red light in a protected left turn lane. My car is set to use regenerative braking and hold/not roll once stopped. I felt my car roll forward a bit, which shouldn't happen when these settings are on. I quickly checked my rearview mirror, assuming someone had hit me from behind to cause me to roll forward. No one was behind me. I hit my brake and the car suddenly accelerated at full throttle speed, I would guess, into the intersection, despite the light being red for me. I quickly glanced down at my foot to confirm that it was on the brake pedal and it definitely was. I continued to repeatedly push the brake pedal down to no avail. I was steering and tried to navigate my way through 4 lanes of moving traffic because they had a green light. I hit the front end of a car, which didn't slow my car at all. I went on to hit another car's front end, which didn't slow my car at all either. My car then charged out of control to hit the curb on the opposite side of the street facing traffic. Hitting the curb stopped my car finally. I noticed that the airbags on the right side of my car were deployed. Components that failed/malfunctioned: brakes, fuel/propulsion system, speed control, automatic emergency braking, collision warning/avoidance, traffic signal detection Tesla Insurance has deemed the car a total loss. I also reported the malfunction to their Vehicle Support but haven't gotten the report or the data report from the car that I requested yet. I was told that the report would be complete by 8/7/25. The car was placed on a hold for the investigation, so it should be available for inspection. I do have the dashcam videos and photos of my car, if needed. This incident was terrifying because I had zero control of my vehicle due to the sudden unintended acceleration (SUA). I see on the internet that SUA is a problem with Tesla that has been reported repeatedly. It is a miracle that no one was hurt or killed. Tesla needs to address this immediately!

Filed Jun 17, 2025 · Brakes, Driver assistance · IL

I was traveling northbound on [XXX} in Sugar Grove, IL with the traffic aware cruise control on. As I passed under [XXX] the car braked heavily for no reason. No cars in the area...thankfully. I could have easily been rear-ended. It has done this on more than one occasion at this location. I filed a "bug-report" via the right hand button on the steering wheel. I was also traveling [XXX] near Lasalle-Peru with the cruise control on at about 80 mph when the vehicle suddenly braked heavily. No cars around at all. The moment was extremely frightening. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 11, 2025 · Brakes, Driver assistance · CA

When the vehicle is set to regenerative braking mode, lifting off the accelerator pedal causes the car to decelerate significantly. However, in many cases, the brake lights do not illuminate during this process. This could potentially create a safety risk, as drivers behind may not realize the car is slowing down and may not respond in time. tesla

Filed May 4, 2025 · Acceleration, Brakes · CA · crash

Wy wife and I drove our Tesla Model 3 from Palo Alto, CA to San Francisco downtown, to meet friends. I was the driver, and my wife sat on the passenger seat. The weather was clear, and the pavement was dry. I did not engage auto-pilot features during the entire trip. The car condition was normal with no signs of error or warning. I made a right turn onto [XXX] from [XXX] Shortly after I completed the turn, the car unexpectedly lost control. Without any prior warnings, it suddenly veered into the center divider, snapped a tree, dashed towards oncoming traffic on the other side of [XXX] , and finally stopped on [XXX] , labelled as location A on the attached drawing. Everything happened so quickly: I could not control the steering wheel, and I applied the brakes in vain. The vehicle seized control, no matter how hard I tried to stop it. I regained control of the vehicle at the intersection of [XXX] and [XXX] , and was able to park the car at location A. We were very fortunate and blessed that we did not hit people at the bus stop, that there were no cars in front of us, that the opposite traffic on [XXX] was stopped by a red light, and that the traffic was light on [XXX] Without such luck, my wife and I, and probably others, would have been seriously injured, if not worse. Because [XXX] is one-way, we decided to move the vehicle to [XXX] , and parked at location B in the drawing. I called 911 and spoke to a female dispatcher. She asked us to remain at location B and wait for police officers to arrive. We waited there for almost 3 hours, but no police arrived. The dashboard display indicated that we had a flat tire(s). We called mobile tire services. After their inspection, most of our tires were alright, except the rim of the front-left wheel was badly bent, as you can see in the attached photo. The mobile tire service staff was skilled enough to carefully patch the damage and said it should be OK to drive back to Palo Alto. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5

Filed May 3, 2025 · Acceleration, Brakes · NV

If you are on a hill and you accidently press both the brake an accelerator, the car will fall to neutral and free roll. In whatever direction is downhill. I have big feet. Happened again to me, I bumped the brake pedal (but not enough to apply the brakes to stop) when attempting to pull forwards slowly and my car beeped with the "both pedals detected pressed" alert. and then it free rolled backwards (because I was on an uphill). THIS WILL CAUSE AN ACCIDENT BECAUSE THE CAR IS NOT SUPPOSED TO FREE ROLL BACKWARDS WHEN IN DRIVE, THIS IS A SAFETY PROBLEM. It has been 4 years now, and no action has been taken to adress this software defect. a NORMAL gas car does NOT do this. If you bump the brake in a normal gas car, IT DOES NOT FREE ROLL IN ANY DIRECTION. This is a tesla software problem that tesla needs to promptly fix ASAP!!!!!

Filed Jan 8, 2025 · Acceleration, Brakes · OR

I'm not quite sure what component was affected, some module of some sort got water in or near it that wasn't supposed to. It is available for inspection. Yes my safety and others was out at risk. Yes the problem was fixed by service center supposedly. Yes the car has been inspected by the manufacturer. There were no warnings. What happened was on 12/29 I was driving the car and out of absolutely nowhere a bunch of warnings came up including loss of ABS, any and all safety features. And more importantly lost usage of brakes almost entirely when car came to a stop it was grinding and shakey. This problem all arises due to teslas negligence when it came to installing a new windshield on the vehicle. As stated in messages below, they made a mistake while installing my windshield that caused this major issue to arise. They have offered nothing as a solution but saying that their error is supposedly fixed.

Filed Jan 5, 2025 · Acceleration, Brakes · CA · crash · 1 injury

the federal safety agency Vehicle Safety Complaint •Vehicle Information: •Make: Tesla •Model: Model 3 •Year: 2022 •Summary of Incident: On November 28,2024, I experienced an incident involving my 2022 Tesla Model 3 while it was stationary just outside my garage. I accidentally pressed the accelerator pedal instead of the brake. The car surged forward and crashed into the back wall of my garage. Despite Tesla’s advertised safety features, such as Collision Avoidance Assist and Automatic Emergency Braking (AEB), none of these systems intervened or activated during the incident. I expected the safety systems to detect the garage wall and mitigate the collision, but they failed to respond. Additionally, Tesla’s Obstacle-Aware Acceleration system did not seem to function as intended to limit acceleration in this scenario. •Injuries or Property Damage: There were minor injuries to passenger, but the vehicle and the garage sustained significant damage. •Steps Taken Post-Incident: I have contacted Tesla to request an analysis of the vehicle’s event data logs to determine why the safety features did not activate. I am waiting for their response. •Concern: I am filing this report because I believe this may indicate a potential safety issue with Tesla’s collision prevention systems in low-speed scenarios involving stationary obstacles. This raises concerns about the reliability of these features in real-world situations, particularly for drivers who may accidentally press the accelerator. •Supporting Information: If needed, I can provide photographs of the damage, repair estimates, and additional details.