2022 Tesla Model 3 suspension problems

Filed Aug 14, 2026 · Suspension · FL

the suspension lower lateral links bushings are wearing down without much usage. my car had 31k miles and the bushings already need to be replaced. this is very dangerous.

Filed Aug 13, 2026 · Steering, Suspension · MD

I am the owner of a 2022 Tesla Model 3. The front control arms on this vehicle are defective as manufactured. From the factory, these components have demonstrated premature failure, abnormal noise, loosening, and/or separation risk that is not consistent with normal wear on a low-mileage vehicle of this age. Symptoms experienced include [describe your exact symptoms clearly and factually — examples: progressive clicking, clunking, popping, or creaking from the front suspension/wheel area; especially noticeable during low-speed turns, reverse, or over bumps; any feeling of looseness, pull, or change in handling; any actual detachment or near-detachment]. These symptoms began at approximately 75000 miles on July 27th 2026. This is not isolated wear. Front control-arm and related suspension-link failures (including lower lateral links that can detach from the subframe) have been the subject of multiple owner complaints, prior Tesla recalls (including the federal safety agency campaign 21V‑835 for improperly torqued lateral-link fasteners on certain Model 3/Y vehicles and the later 23V‑235 expansion), technical service bulletins addressing water intrusion and noise in upper control arms, and a current the federal safety agency preliminary evaluation (opened 2026) into front lower lateral-link detachment on a large population of Model 3 and Model Y vehicles. Owners report that failures can occur with little or no prior dashboard warning, only possible audible cues, and can render the vehicle undrivable or cause sudden changes in alignment and directional control. A sudden separation or failure of a front control arm/lateral link while the vehicle is in motion creates an unreasonable risk of loss of vehicle control, crash, or injury to the driver, passengers, and other road users. Because the condition appears to originate from factory assembly, design, or component durability issues rather than owner abuse or ordinary high-mileage wear, and because similar failures are widely reported across Tesla owners.

Filed Aug 7, 2026 · Driver assistance, Steering · TX

My car randomly gave me alerts that my steering alignment fault then came the following two days later Automatic Emergency Braking is unavailable Feature may be restored on next drive 20:55 | DI_a246 Automatic vehicle hold disabled Use brake pedal when stopping 20:55 | DI_a223 Traction control disabled Drive with caution 20:55 | APP_W264 Lane Departure Avoidance features unavailable Features may be restored on next drive 20:55 | DI_a222 Stability control disabled. I take my car to a mechanic and they show me that my lower control arms are damaged. Tesla is more than 2 weeks out for something that has caused my car to act completely unsafe and not normal.

Filed May 9, 2026 · Suspension · MD

Driving at low speed, the control arm became unfastened from the frame and the front driver's side wheel collapsed into the frame of the car.

Filed Apr 25, 2026 · Steering, Suspension · CA

2022 Tesla Model 3 with approximately 19,373 miles. Third-party tire shop inspection on April 25, 2026 identified visible tearing of front lower control arm bushings on BOTH sides (bilateral failure). Rubber bushing material has separated from inner metal sleeve on both left and right front lower control arms in identical pattern. No impact event or curb strike. Symmetric bilateral failure indicates manufacturing/material defect, not impact damage. Failure occurred at mileage well below the 40,000-70,000 mile range commonly cited for this known Tesla Model 3 lower control arm bushing wear pattern. Suggests accelerated failure mode that warrants investigation. Photos from third-party inspection attached. Vehicle scheduled for Tesla service center evaluation under remaining factory warranty.

Filed Aug 29, 2025 · Suspension, Wheels · NJ

I have experienced multiple tire failures on my 2022 Tesla Model 3, with at least 7 tires needing replacement due to air bubbles. These issues have occurred on both front and rear tires, and currently I have 3 more tires with visible bubbles and one tire is actually leaking air. Most of these tires failed within 2,000-6,000 miles of use, which is far below normal tire lifespan of 25,000-40,000 miles. Despite repeated service visits, no alignment or suspension inspection has ever been performed by Tesla to determine why this keeps happening. The tires are just replaced at my cost, with the problem recurring again and again. Despite the pattern, Tesla service advisors continue to blame road conditions or driving habits. I want to be clear: I actively avoid potholes, drive cautiously, and have never experienced anything like this with any previous vehicle. Something is clearly abnormal here. In addition, I have noticed strange clicking and popping noises while driving, which seem to come from the chassis or steering area. It worries me that there may be a deeper mechanical or build quality issue. The vehicle often feels unstable, and I am genuinely concerned that a failure of a suspension component, battery mounting, or other structure could lead to a fire or loss of control. No warning lights have appeared, but the pattern of repeated air bubbles showing in my tire after just driving not even 1,000 miles and abnormal noises makes the vehicle feel unsafe to operate.

Filed Jan 19, 2025 · Suspension · NJ

Front and rear suspension bushings wear and rip at very low mileage

Filed Dec 27, 2024 · Steering, Suspension · WI

At low/no speed, turning the steering wheel to the extreme left or right produces a low-end creaking noise as if something is rubbing.

Filed Oct 23, 2024 · Suspension · IL

See attached document for complaint.

Filed Oct 16, 2024 · Suspension · CO

The right front passenger side suspension started squeaking at 22586 miles. Service center replaced lower lateral links on 7/1/24. Repair did not fix the squeaking sound. Service center could not replicate the issue until a test drive with myself and a tech on 9/20/24 and made me make a third appointment for repair. On 10/16/24 the service center said the control arm was failing, but did not think it would be covered under warranty. A quick internet search turned up lawsuits, hundreds of complaints, and crashes resulting from failing control arms.