2020 Tesla Model X steering problems

Filed Jan 23, 2026 · Steering, Suspension · CA

Making a loud squeaky noise and knocking while I turn. The noise is coming from the steering and front suspension arms I believe.

Filed Nov 28, 2025 · Steering, Suspension · AZ

My 2020 Tesla Model X experiences severe vibration, shaking, and rattling during acceleration, especially between about 20–45 mph and at higher suspension settings. The vibration is strong enough to affect steering stability and safe control of the vehicle during acceleration and lane changes. Tesla has already replaced the front half-shafts twice under warranty for this same problem, but the issue has returned again. This is a known defect documented by Tesla in Service Bulletin SB-21-39-001, which describes excessive front drive unit half-shaft vibration during acceleration and defines the repair with updated components. The latest revision of this bulletin (R3, dated January 19, 2024) explicitly adds “Customer Pay billing” instructions. Despite this, my local Tesla Service Center in Tempe, AZ (Supervisor: Lewis Holguin) refused to apply the SB-21-39-001 Customer Pay billing and instead charged full retail for the repair. On 11/28/2025, I was billed $1,694.86 out of pocket to replace both front half-shafts again (invoice shows approx. $1,046 in parts and $564 in labor). I have documentation showing that other Tesla customers with the same defect were billed only $350 under SB-21-39-001, which demonstrates that Tesla does apply a discounted bulletin rate in some cases. In my case, they refused to honor it even though this is a repeat failure of the same known defect and the prior warranty repairs did not permanently fix the problem. This is a repeat driveline/suspension defect that affects drivability and safety under acceleration. The shaking and vibration make it difficult to maintain stable vehicle control, especially during highway merging or lane changes. I am requesting that the federal safety agency investigate recurring front half-shaft failures and vibration/shudder issues on Tesla Model X vehicles and Tesla’s inconsistent handling of this known defect and service bulletin.

Filed Jun 11, 2025 · Driver assistance, Steering · NJ

This is a major safety issue --- we got an error that steering assistance was "reduced" for about 12 hours. Then on [XXX] at around [XXX], we were pulling out of a parked area (after being parked for 2 hours) -- and proceeded to increase speed on [XXX] in Newark, the car steering wheel abruptly LOCKED ITSELF - you couldn't even move the steering wheel. It just locked and shut down completely. We proceeded to do a rest (hitting two scroll buttons) to reset the system over 5-6 times. Each time it takes about 10 mins to complete. It was pure HORROR - sitting on the road with cars just passing by and honking at me behind. I had the hazard lights on, but it was a dangerous situation. I was completely STUCK and immobile. After some time, the steering wheel "magically" started working again. We've dropped the Tesla off at Springfield and they are charging us over $6,000 in damages for this. This is a SAFETY issue (we bought the car in March of 2024) and it's only been 15 months since we've had this used car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 30, 2025 · Driver assistance, Steering · TX

Steering assist reduced. It has been faulty for the past six months and auto pilot doesn’t work. Not repaired as the cost of repair is 5K.

Filed Sep 19, 2024 · Acceleration, Driver assistance · NV

Tesla updated my vehicle with FSD 12.5.2.1 and it is dangerous and should be recalled. The software is too much for my vehicles processor, it frequently freezes for as long as 10 seconds. This loses my speedometer, my signal information, and happened while merging and nearly caused me an accident. The lane keep assist has retrograded significantly, it often goes outside of the painted lines and is in danger of hitting curbs. The processor feels like it struggles to keep up, and the auto steer is unsettled and jerky as it changes its mind. Previous software worked great, Tesla is pushing the software beyond the hardwares capabilities and it’s going to cause accidents. Please stop them.

Filed Mar 25, 2024 · Driver assistance, Electrical · NV

ON [XXX], while driving my second Tesla Model X on [XXX] from Carson City back to Reno at the speed of 79 mph on Autopilot, the same sudden loud alarming situation occurred, with 1. park Assist unavailable 2. Steering assist reduced 3. Adaptive ride control degraded 4. Traction control disabled 5. Stability control disabled 6. Lane departure avoidance features unavailable 7. Automatic emergency Braking is unavailable 8. Automatic vehicle hold disabled. I drove to s stop, the car can't park but remained in neutral gear. Can't hard reset. With my prior experience 1 month ago, I changed it into Tow mode several times, finally was able to switch into Park mode then was able to do a hard reset. When I brought in to Tesla, they said it's the SAME problem, steering rack issue. Another $5300 is gone. How can I be so unlucky to be hit with same model, different year, same problem, same driving condition and almost same place on earth, and both out of warranty and I have to pay in full? There must be manufacture defect on this!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 13, 2024 · Steering, Suspension · CA

I have a 2020 Model X (23k miles) and the warranty just expired 2 months ago. It suddenly developed a loud creaking in the front end. The creaking seems to be related to the movement of the suspension, but I also notice it when I turn either direction. It’s not related to braking except to the extent that the suspension is compressed slightly with braking. From research it may be the control arms and front sway bar. Apparently this is a very common issue with the Model X per Online forums. Absolutely no reason why any of those parts should be failing for everyone unless it was faulty parts/engineering. This should definitely be investigated.

Filed Feb 13, 2024 · Steering, Suspension · MA

There were two issues that occurred within months of each other: 1) Power steering failed on several occasions– immediately following a service appointment in which the CV joint/half shafts were replaced and an alignment performed. Tesla implied that the intermediate shaft failed in pure coincidence; this is not the case: intermediate steering shaft failure after 40,000 miles with no warning and no impact is very highly unlikely. 2) suspension and steering components began to fail (Front Aft Suspension Link, as diagnosed by Tesla), causing excessive noise and wear on other vehicle components. Tesla was aware of the manufacturing defect prior to failure, but refused to cover the repairs under the warranty. Both issues caused difficulty steering and distractions while driving at both high and low speeds; losing power steering on the highway can be deadly. No warning signs appeared prior to the component failure in either instance, and "driver abuse" did not occur– though Tesla implies that with every concern. The car is set to the slowest acceleration and gentlest handling settings possible to maintain the longevity of the car's components. Independent mechanics not affiliated with Tesla Motors inspected the car and agreed that the failures were abnormal and not to be expected at such a low milage. The issues that began early into the warranty period were sudddenly no longer addressed once the warranty expired: a clear violation of the MMWA of 1975.

Filed Feb 7, 2024 · Steering, Suspension · TN

We have taken the vehicle to Tesla service center multiple times (3 or 4) for the passenger side suspension creaking. Fore and aft links replaced as well as upper control arms. Car continues to make noise and service center stating they cannot duplicate the problem - this is happening to multiple model x.

Filed Nov 27, 2023 · Steering, Suspension · VA · crash

"On August 18, 2023, I was driving at 70 mph on I-95 near the 100-mile mark using Full Self-Drive. The front driver-side suspension housing cracked, causing the bottom part of the suspension to detach. This led to the front tire striking the upper part of the wheel, resulting in a tire blowout. A piece of metal from the suspension fell onto the road and hit the rear driver-side tire, causing it to also blow out. The vehicle lost control and came to a stop on the left side of the road."