A bus driver calls in a problem to the dispatcher that the bus cut off while during the route. In august of 2001 dps purchased one hundred twenty five (125) thomas built saf-t-liners with caterpillar 3126 b engines. In 2006 prior to the engine warranty expiring we began to experience idle gear failures and approximately twenty two (22) were replaced and cover under warranty by caterpillar. However, since that time we have lost an additional twenty seven (27) out of service that is not cover under warranty with the same problem and that is still going up, and this is a daily occurrence.
The worst 2002 Thomas Built Buses Saf-T-Liner C2 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Engine1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine1
Recalls 2
Equipment
- What is wrong
- Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit:
- Risk
- In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
- Remedy
- DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1‑800‑547‑0712 or Kidde customer service at 1‑855‑262‑3540 or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
Recall number 18V083000 · Recall details
Structure: body: door: hinge and attachments
- What is wrong
- Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. Please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. Continued corrosion and pitting weakens the handle. Handles weakened by corrosion may break while trying to open the door from the exterior.
- Risk
- In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
- Remedy
- Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. Repairs will be performed by thomas built buses dealerships. The recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. Owners may contact thomas built at 336‑889‑4871.
Recall number 08V087000 · Recall details
See all 2 recalls for the 2002 Thomas Built Buses Saf-T-Liner C2
Technical service bulletins for the 2002 Thomas Built Buses Saf-T-Liner C2 133
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Revised Technical Service Letter for Series 60 and Series 50 Camshaft Timing Specifications
- Thomas Built Buses Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Thomas Built Buses Product Awareness Bulletin on RH 3 POS Switch for Electric Operated Entrance Door
- Thomas Built Bus Service Bulletin for When troubleshooting powernet issues, use the BCT-460DTNA PowerNet...
- Thomas Built Buses Product Awareness Bulletin on Lettering Changes
- Thomas Built Buses Product Awareness Bulletin on Axial Mounted Air Disc Brake Caliper for Saf-T-Liner C2
- Thomas Built Buses Product Awareness Bulletin on Hankook DH37 Drive Tire/ Spare Tire
- Thomas Built Buses Product Awareness Bulletin on Heater Hose Changes
- Thomas Built Buses Product Awareness Bulletin on National Driver’s Seat Update
- Thomas Built Buses Product Awareness Bulletin on Jouley Warranty Update
See all 133 bulletins for the 2002 Thomas Built Buses Saf-T-Liner C2
What 2002 Thomas Built Buses Saf-T-Liner C2 owners say
Most recent owner complaints, unedited.
Compare the 2002 Thomas Built Buses Saf-T-Liner C2
Other model years
Questions about the 2002 Thomas Built Buses Saf-T-Liner C2
Is the 2002 Thomas Built Buses Saf-T-Liner C2 reliable?
Owners have filed 1 complaint about the 2002 Thomas Built Buses Saf-T-Liner C2, close to a typical Saf-T-Liner C2 model year.
What is the most common problem with the 2002 Thomas Built Buses Saf-T-Liner C2?
Engine and cooling, with 1 complaint.
How many recalls does the 2002 Thomas Built Buses Saf-T-Liner C2 have?
2 recalls, covering equipment and structure.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Thomas Built Buses Saf-T-Liner C2?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history