On june 8, 2010, my wife and I were traveling in our 2005 ///tiffin(allegro bay) motorhome when the brakes overheated and we lost all brakes. This was the first time that we experienced brake failure. Bergey's garage in franconia, pa., transported our vehicle to their facility and repaired the calipers on both rear brakes plus other collateral damage. Pictures were taken and they contacted workhorse custom chassis in troy, mi to find out what they would cover since a safety recall notice 50901 c was issued.
The worst 2005 Tiffin Allegro Bay problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes2
- Steering1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes2
- Steering1
Recalls 5
Service brakes, hydraulic
- What is wrong
- Navistar is recalling certain model year my 2001-2008 workhorse w20, w21 and w22 chassis and certain model year 2009 through 2011 monaco rv admiral, arista, monarch, and riptide recreational vehicles equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.
- Risk
- The temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
- Remedy
- Workhorse dealers will replace all four bosch brake caliper assemblies free of charge. The safety recall began on september 16, 2010. Owners may contact workhorse at 1‑877‑246‑7731.
Recall number 09V110000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- Tiffin is recalling 3,507 my 2004-2007 allegro, allegro bay and allero bus, my 2004-2005 phaeton and my 2005-2007 zephyr motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- Release of coolant under certain conditions could ignite and result in a fire.
- Remedy
- Tiffin will be working with dometic in order to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or tiffin at 256‑356‑8661.
Recall number 08V509000 · Recall details
Electrical system
- What is wrong
- Certain motor homes built on workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard no. 101, controls and displays, and no. 105, hydraulic and electric brake systems. If the brake fail input falls below a voltage of 1.5v, the brake failure lamp and alarm will be activated. Also activation of the ABS telltale when the ABS is not properly functioning does not always occur.
- Risk
- At night the instrument cluster lights may fail and the driver may not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash.
- Remedy
- Tiffin is working with workhorse to contact the owners and remedy this campaign . Workhorse will reprogram the instrument panel cluster free of charge. Owners may contact workhorse at 1‑877‑246‑7731 or tiffin at 1‑256‑356‑0205.
Recall number 06V142000 · Recall details
Electrical system
- What is wrong
- On certain motor homes containing a 50 amp transfer switch built by intellitec, the material used for the wire lugs was changed from nickel plated to copper lugs. The copper lugs are softer than the nickel plated and do not retain the torque of the screw that clamps the wire connector.
- Risk
- When the torque is relaxed, the lugs can become loose resulting in excessive heat within the connected wire that could result in a fire.
- Remedy
- Dealers will replace the changeover box. The recall began on july 21, 2005. Owners may contact tiffin at 1‑256‑356‑8661.
Recall number 05V307000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- On certain recreational vehicles, the washer/dryer in the rear of the motor home can move.
- Risk
- A vehicle occupant could be injured if the washer/dryer moved.
- Remedy
- Tiffin has provided the owners with a repair kit and installation instructions. The recall began on january 7, 2005. Owners may contact tiffin at 1‑256‑356‑0205.
Recall number 05V145000 · Recall details
See all 5 recalls for the 2005 Tiffin Allegro Bay
Defect investigations
Potential movement of washer/dryer
In january 2005, tiffin issued a service bulletin (unnumbered) entitled ?service bulletin for potential movement of washer/dryer.?the bulletin addressed the possibility that the washer and dryer could move unexpectedly while the motorhome is being driven.during discussions with tiffin, odi learned that two incidents had been reported where the washer and dryer fell or tipped over into the living space.on april 7th, 2005, tiffin notified odi that after further review, they had decided that this issue should be resolved by conducting a safety recall campaign and subsequently filed safety recall 05v‑145 (copy attached). Tiffan will be installing a kit that prevents the movement of the washer and dryer assembly. This action resolves the issues raised by this investigation. This investigation is closed.
PE05014
Technical service bulletins for the 2005 Tiffin Allegro Bay 7
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This was a letter to our dealers we sent out when we first heard of the Kidde fire extinguisher recall,...
- Tiffin motorhomes: TSB contains notification of owner letter
- Rv: instructions on how to install the charge solenoid wiring in a rv or vehicle
- Tiffin motorhomes: TSB contains notification of owner letter
- Tiffin motorhomes: TSB contains notification of owner letter
- Tiffin motorhomes: there is a potential problem with the water heater by pass in your unit
- Tiffin motorhomes service campaign: switch box grounding lug
What 2005 Tiffin Allegro Bay owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 2005 tiffin allegro bay motor home. He received recall notice #09v110000( component: service brakes, hydraulic) stating that the dealers will inspect and replace the necessary components of the ABS system; however, the remedy was not available. The owners will be notified by mail when parts are available, and they can contact workhorse for assistance. He called workhorse at least six times and was repeatedly advised by a representative that they do not have the parts. The vehicle has not been repaired. The failure mileage was 16,000.
Dt: consumer states that while making a left turn steering locked up. He then disconnected the steering device, which was located under the motor home. This caused the steering to free up, and he took the vehicle to the dealer, and the consumer was told the device had been taken back to blue ox . There was a machining problem on a piston or a cylinder which caused it to seize up.
Compare the 2005 Tiffin Allegro Bay
Other model years
Questions about the 2005 Tiffin Allegro Bay
Is the 2005 Tiffin Allegro Bay reliable?
Owners have filed 3 complaints about the 2005 Tiffin Allegro Bay, close to a typical Allegro Bay model year.
What is the most common problem with the 2005 Tiffin Allegro Bay?
Brakes, with 2 complaints. Next is steering (1).
How many recalls does the 2005 Tiffin Allegro Bay have?
5 recalls, covering service brakes, hydraulic, equipment and electrical system.
Was there a recall on the 2005 Tiffin Allegro Bay brakes?
Yes, 1 recall: 09V110000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Tiffin Allegro Bay?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history