While traveling on the highway without prior warning. The vehicle caught on fire underneath hood. The dealership is aware of the problem. Nlm
1990 Toyota 4RUNNER engine complaints
Page 2 of 2: complaints 11 to 39 of 39, newest first, as owners wrote them.
While starting engine revved a little and cooling fan exploded, piece of fan flew as far as 30 feet away, almost injuring a bystander. Fan pierced a hole in battery, allowing acid to spill onto the floor. Mechanic stated that this was a poor design in cooling fan. And a very dangerous situation.
Engine blew at 13000 miles and vehicle started hesitating and cutting off without prior warning. Dealership was aware of problem.
Vehicle was in for oil change 4 weeks prior to incident. Engine began to make a loud banging noise. Stopped at a jiffylube, and found oil very low. Filled with oil and was told that it sounds like I threw a rod, but it should be okay to get me where I was going (about 5 miles up the road). Approximately 2 miles later, white smoke began coming out the back of the vehicle, and the banging stopped. The smoke became very bad, and I was about to pull into a gas station when someone pulling out yelled to me that it was on fire (in the engine compartment). I got me and my 2 small boys out, and came home that same night to the head gasket recall notice in the mail. I immediately called toyota, who sent someone out to investigate, but they said that the investigation concluded that the cause was not known, and it was not their responsibility. I was reading more horror stories about this on your site. What can be done? My vehicle was paid for and my insurance did not cover fire. Why did it take them so long to get the head gasket recall notice to me? It appears that this was an issue for several years. I basically dropped the issue for several years figuring I was fighting a losing battle, until I discovered this site. Thanks.
Passenger's side exterior mirror would severely vibrate when traveling at 30mph or more. This caused poor visibility. Dealer notified, and was unwilling to assist on this matter. Feel free to provide any further information on this problem.
Vehicle was repaired for a recall issued by manufac. On the head gasket, but than it blewup again. Consumer also found paper in oil pan. Dealer will repair but on consumer's costs.
My toyota 4-runner blew a head gasket 10 months after purchase. I contacted both reno toyota and carson toyota. Niether dealer were helpfull in recall information. After replacing the motor, my mechanic assured me that it was a common accurance in the 4-runner to have faulty head gaskets. I then contacted carson toyota and they told me that they would fix the problem but not pay for anyone else to do so. By the time they contacted me the work was complete and a bill of over $6500 was incured. I dont believe they would have offered to fix the problem if they didn't know it existed. I can't seem to get any recall information from toyota, and I was hoping you could help. Thankyou , ron collins.
Water is being sucked into engine, and head gasket problem. There is a defect in head engine gasket. Toyota is aware of problem.
This particular type of head gasket failure (coolant leakage into the cylinder) is a known problem on the 3vz-e engine, toyota initiated a special service campaign (v06) to repair most, however the consumer's vehicle does not qualify due to the VIN # range.
Started and low speed strange noise and antifreze spewing, head gasket blown (replaced in 1998) only 42 k miles into new gasket.
Threw a rod, resulting in total engine failure. Complete oil loss blamed - cause unknown. Head gasket replaced in april of 1996. This occurred in may of 1997.
Consumer started up the car and saw a big puff of smoke. Took vehicle to a mechanic, and they said it was a blown head gasket.*ak
When trying to start vehicle after it has been running roughly, white smoke came out of engine. A technician had informed consumer that vehicle had a blown head gasket.
Toyota sent ext. Notice 03/98. Good for 12 months, up to 100k miles. Engine head gaskets did not fail in that time, but 24 mos later at only 62k miles, well under 100k. Still, toyota won't extend honoring the 1998 extension though records on your nht
Valves .low compression in one cylinder after only 25,000 miles on new valve job.
White smoke and loss of power. When parts were ordered, we were told they were unavailable in completion due to recall.
This is the 4th time the gasket has failed. Gasket was installed by a certified toyota mechanic in 1996. 3/97 white smoke poured out of the exhaust. Toyota replaced the top of the engine. 11/97 engine failed - 600miles from home, after 3 months at the dealership on 2/98 the bottom & top of the engine was replaced. Now 12/99 same problem - gasket needs to be replaced -oil blew all over the engine, the ream main seal is gone. Toyota says its our problem now.
No summary.
Truck burns a quart of oil every 15 miles. Consumer received a recall notice for new engine head gaskets. Took car to the dealer, repaired the head gasket . Then discovered a problem with the engine block. Dealer would have to send that part out. Every sincevehicle was fixed, truck has just been burning oil too fast. Consumer feeld it is unsafe to drive truck because the fear of breaking down due to lack of oil.
While driving at 35 MPH engine head gasket failed due to the coolant which got inside and ruined engine.
Toyota issues an "extended warranty" for the faulty head gaskets in 1998-1994 4runners. When the head gaskets failed they were replaced under this warranty. However, the damage casued by the faulty head gaskets is extensive. After initail replacement--toyot adealership continued to find oil fouled plugs which let to replacement of lower engine block (december 1998). Engine failed again in january 5 1999-- at which point 2 cylinder heads, camshafts, engine gasket, and knowck sensor were replaced. Engine has not operated properly since original head gasket failure-- sluggish, poor acceleration, inconsistent idling speeds... Engine has been looked at and worked on at authorized toyota dealerships 12 times to date for head gasket related engine problems. Still unresolved, for these symptoms oil gouled plugs
Put 5000 miles on used purchased vehicle and engine blew
Rod thrown, engine destroyed. Warranty head work done last october after recall possibly related. Massive oil loss sometime in last week, possibly at time of engine failure.
The consumer was driving truck, and she noticed that there was no pressure when she hit the gas pedal and she smelled fuel. Also she had a new engine put in july, the mileage was 75000 on the truck. The short block was replaced . Then the truck burst into flames. The car wa stowed to the dealer for further investigation.
Engine thermostat failed twice, engine failed due to collant leak.
Engine compartment fire, consumer was driving under normal conditons and noticed lck of resistance from the hydraulic clucth and the vehicle caught on fire in the engine compartment, the fire department was unable to find the cause of the fire.
Bolt that holds the head on the engine gaskets is broken.
The engine head is bad . Tt
Replaced engine belts.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1990 Toyota 4RUNNER?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history