2003 Toyota 4RUNNER fuel system complaints

Filed Nov 7, 2003 · Fuel system · FL

I purchased a brand new sports edition 2003 4 runner in july of 2003. There is a sulfur smell emanating from the vehicle at all times. When I complained to toyota I was told the odor was caused by the gas I use. I have never had this problem before and toyota just washes their hands of it. I was given a paper which purports to be a technical service bulletin. It states: feb 24 2003 - some owners of toyota vehicles may experience a sulfur like or rotten egg odor from the exhaust system. Sulfur is a natural component of crude oil from which gasoline is refined and the amount of sulfur can be decreased through the refining process. The amount of sulfur in fuel sold in california is regulated; however, gasoline sold in other states can have a higher sulfur content. Sulfur content also varies considerably between gasoline brands and locations. Applicable vehicles all models repair procedure : a sulfur odor emitted from the vehicles tailpipe does not necessarily indicate there is an issue with the vehicles running condition but is most likely directly related to the fuel. If vehicles is exhibiting an excessive sulfur odor the following checks should be performed if the mil light is on check for dtc's and repair as necessary information trouble is found after performing the above check recommend the customer try a different source of fuel. Replacement of oxygen sensors, air/fuel ratio sensors or catalytic converters will not reduce the odor and therefore not be considered for warranty (sounds like a cop-out to me) toyota should look for a solution.

Filed Jun 30, 2003 · Fuel system · CA

Consumer received recall 03v146000. Called the dealer to arrange an appointment for repairs. Dealer stated we didn't have that part yet and we didn't know anything about that recall.

Filed Jun 16, 2003 · Fuel system · KY

The consumer contacted the dealer to make an appointment for a recall # 03v146000 repairs concerning fuel pulsation damper. Consumer went for the appointment on may 27,2003 and the parts were not available. Dealer was suppose to call when the parts became available. As of today the parts were not available.