2003 Toyota 4RUNNER steering problems

Filed Aug 24, 2022 · Steering, Suspension · NJ

There is severe rust on the frame, the rear is listing by 3/4 of an inch due to suspension rust, parts of the frame are perforated and lots of rust can fall out of drain holes when tapped. I am unable to steer the truck due to the intermediate steering column rust. The Tacoma was recalled for the same reason, I am assuming the 4runner has not been recalled because it was manufactured in greater numbers, and therefore more costly to repair, the danger of the severe rust is the same in both vehicles.

Filed Jul 18, 2022 · Steering, Suspension · MI

Stabilizer bar connecting the axle to the frame rusted off. I was driving only 25-30mph at the time, luckily. The vehicle swayed violently almost causing an accident and nearly forcing me off the bridge I happened to driving over. Very fortunate no one was hurt and nothing was damaged from the incident. You can imagine the tragedy if that had happened on the highway driving 75mph! Major accident, innocent lives damaged or lost. This is a very dangerous vehicle not only to the driver and passengers but also to anybody that happened to be innocently in the path of an out of control Toyota 4runner. Toyota Please fix this, for your safety and everyone else on the highway. People should be warned!!

Filed Jul 18, 2022 · Steering, Suspension · MI

Stabilizer bar connected to the frame rusted off,back passenger side! Causing the vehicle to sway uncontrollably, due to the low rate of speed, I was able to regain control of my vehicle and not drive off the bridge I was driving over at the time or crash into another vehicle. The engine runs great, everything works, the vehicle still looks good but the frame is rusting out from underneath it! Toyota Needs To Make It Right!

Filed Sep 18, 2021 · Body, Steering · NH

Vehicle frame and suspension components are completely rusting out. Having issues with the corroded steering column lower shaft not allowing the vehicle to turn properly.

Filed Aug 30, 2021 · Body, Steering · MI

At the end of June 2021, while driving I experienced a loud clunk and grinding noise, with reduced control of steering and brakes on my 4Runner. I took the 4Runner to a Goodyear Automotive Service Center on Woodward Avenue in Royal Oak, Michigan, who told me that the vehicle was not driveable due to severe rust damage of the frame that resulted in a broken sway bar. I thought I should take it to the closest Toyota dealership in Troy, Michigan for advice and they responded that the vehicle was beyond repair and that a new frame would cost around $20,000. I could not leave my car there, and risked driving it home, where it has been parked ever since.

Filed Jun 16, 2021 · Brakes, Steering · NY

Frame is rotted out and brake lines attached to the frame as well as every suspension component. Car failed inspection deemed unsafe to drive. This problem has been addressed for Tacoma, tundra and sequoia but not 4runner. These frames have the same issue as those and needs to be repaired by Toyota due to lack of rust and corrosion protection. There’s no reason 4runner should be overlooked for the same issue as the other full frame trucks.

Filed Mar 17, 2021 · Steering, Suspension · 98,000 miles · RI

Loud noise while driving. Upon inspection, excessive rust and corrosion to frame of vehicle found. Holes in frame larger than 2 inches.

Filed Oct 15, 2020 · Body, Steering · 142,000 miles · NC

Frame is almost completely rusted out even thought the rest of the car is in good shape. I am afraid to let my son even drive the car. I read about the girl that died from the axle coming loose and part of the frame that holds the axle is in horrible shape. Toyota should be required to add these vehicles to the frame recall...

Filed Dec 23, 2019 · Body, Steering · 159,000 miles · NJ

Excessive frame and undercarriage rust. I have owned several other cars over 30-40+ years and this 03 4runner has the worst rust. Instead of simple surface rust, this rust has affected frame welds, suspension mounting points, tow and lift points. Rusting pace is extremely fast moving. There appears to be only a simple layer of thin paint, with no undercoating anywhere. This 4runner was serviced regularly, motor is running great, body and interior are in great condition. This was a gift from grandpa to grandson, but I am concerned of safety and at this point recommending only local, under 35mph travel only. Probably scrap the car soon as not much to do but replace frame. Very disappointed with misled condition, outside/inside/motor perfect, but frame rotting away. My family and friends have purchased toyotas with little incident, but I won't buy or recommended knowing they have a life of ~10yrs.

Filed Jul 1, 2019 · Steering, Suspension · 200,000 miles · NJ

Frame has extreme and rusting and has been reinforced by welding new steel support frames