1994 Toyota Corolla fuel system problems

Filed Sep 28, 2013 · Fuel system · 155,000 miles · FL

In july 2013, I started smelling gasoline as I was driving to work. Smell got stronger and more noticeable after gassing the car up. Then the smell became more noticeable day by day. Even just sitting in the car or as you walked past it. Car did not have to be on and you would still smell it. There were no noticeable leaks until recently. I thought it was oil at first but then I figured it could be gasoline. Had someone look at it and they noticed a crack in the gas tank that seemed to be blown outwards. I'm going to have it fixed but if this is a common problem then this should be considered a manufacturers defect and toyota should pay for the parts & labor.

Filed Aug 29, 2011 · Fuel system · 307,097 miles · RI

Tl* the contact owns a 1994 toyota corolla. The contact stated the heat shield was removed from the fuel tank and what was found underneath the heat shield was a bubble which was located on the outside of the fuel tank, which was where the gas leak was coming from. It appeared there was a defect in the fuel tank. If the fuel tank was damaged, t hen there would have been an inward dent in the tank, which was not the case. The failure mileage was 307,097. Updated 11/10/11*lj updated 06/13/12

Filed Nov 21, 2008 · Fuel system · 108,837 miles · CA

I have had to replace the gas tank on my car twice. The first time the toyota dealer replaced the original gas tank. The new replacement toyota gas tank developed cracks above the exhaust pipe within three years from the date that it was replaced. These cracks were not causes by external wear, abrasions or debris, but rather appeared as a fissure in the metal of the tank. In both cases, due to the location of the leaks above the exhaust pipe, gasoline was dripping onto the exhaust pipe shield, which is very hot and risks fire. Despite the defective part, the toyota dealer would not replace it without charging me for the full cost of a 3rd gas tank plus labor.

Filed Oct 12, 2006 · Fuel system · 205,531 miles · PR

Dt*: the contact stated while parked, a smell of gasoline was present around the vehicle. Upon self inspection, the contact noticed that the gas tank located on the rear passenger side was leaking fuel. This was the 2nd time, fuel had leaked from the gas tank. The vehicle was taken to the an independent repair shop in 10/05 for the same problem, and the fuel tank was replaced. The dealer and manufacturer were not notified.

Filed Dec 1, 2003 · Fuel system · 120,000 miles · TX

The gas tank developed crack/leak directly over the exhaust heatshield. The leak is in a location totally protected from any road debris impact, there are also no signs of trauma. The leak was located after smelling raw fuel, seeing a drop on the rear exhaust heatshield then removing that heatshield. Only then was the leak location visible.

Filed Oct 1, 2003 · Fuel system · CO

My 1994 corolla wagon developed a leak in the gas tank in september of 2002. I took it to my mechanic (import motors service inc, 303‑422‑9654, sepp or mike.) and they installed a new fuel tank which carried a warranty of 12,000 miles or 12 months. I was responsible financially for both the part and labor. In april of 2003 the new tank developed a leak in the same area as the original, above the heat shield of the exhaust. Luckily no fire occurred. That second tank was covered by the warranty so I had a third tank put in and it lasted six months before developing a leak in the same area again. I have just had a fourth tank put in and only have 2000 more miles on the original warranty from the first replacement tank, then I will have to pay for a new tank as well as the labor if this one leaks. I was responsible for paying for the labor on the third and fourth tanks. Thankfully import motors gave me a sympathy discount on the last job, but this is getting to be expensive. Toyota has said there is no problem with their tanks when we tried to address it with them over the internet, this is hard to believe. Check out complaints oid id numbers: 878860 and 755159. What is up with toyota's replacement gas tanks and do they pose a fire and seafty risk? Sincerely, edd hamilton

Filed Dec 1, 2001 · Fuel system · FL

Noticed an odor of gas from the vehicle. Checked the vehicle and found fuel oozing from bottom of fuel tank. Location of leak was in an area protected from debris above the heat shield of the exhaust pipe. No physcal damage to tank noticed. Possible fire hazard.

Filed Jan 23, 2001 · Fuel system · TX

Fuel tank developed a leak. Consumer could smell gas, and pressure forced almost all the gas out, it dripped onto exhaust heat shield, could have caused a fire. Had a new gas tank put in. In august 1999, new gas tank developed a leak, dripping on exhaust shield. *ak consumer states that in both instances, the gas tank showed bubbles in themetal hull and cracks developed at the most severe bubbles allowing fuel to leak out.

Filed Nov 2, 1999 · Fuel system · CA

The fuel tank cracked causing a fuel leak which may have resulted in a fire. Dealer cannot determine the problem.

Filed Mar 16, 1995 · Fuel system · PA · fire

Notice white smoke, fuel on the ground, fire in rear of the engine, possible fuel leak. Tt