I would like to document my concern regarding the failure of the charcoal canister in my 2002 toyota corolla. This seems to be a common problem and I have seen quite a few people complain about the same on the internet. Regardless, I feel that a part so non descriptive shouldn't cost over $500 to replace. Secondly toyota motor company insist that the part would be covered for a recurring failure only if it is replaced at the dealer, where the costs are 2/3rds more than a normal service shop such as midas. Toyota should not advertise on reliability if parts fail at 50000 mark and that to becomes so expensive to replace (including labor). I see this is a wide spread problem and I would appreciate if there a recall is initiated on this part and replacements done by the manufacturer.
2002 Toyota Corolla engine complaints
Page 2 of 2: complaints 11 to 24 of 24, newest first, as owners wrote them.
2002 toyota corolla - car just stops running, symptoms like timing chain failure. Car stalls and will not die while driving. Dangerous driving condition.
I am the first owner of my toyota corolla, which has 74,000 mile on it now. The car has been well maintained. However, there are some unexpected problems with the car. After I bought the car three and half years (march 2005), the check engine light went on and it was diagnosed that the evaporation system had malfunction and the charcoal canister and vacuum switch needed to be replaced. I had spent more than $600.00 to have this done. At that time I did not complain too much. However, the same thing happened again in november 2007, I had to spend another $600.00 to replace canister and valve again (after two and half years later). I believe that the two charcoal canisters had very bad quality!
Engine malfunction dash indicator came on. First toyota dealer replaced spark plugs after discussion and said drive car for few days. Warning light came on next day. Second toyota dealer ran full diagnostics and got code p1346. Advised vvti cam needed to be replaced and possible timing chain. Minimum cost just over $1000. I asked if there was a service bulletins on this. They said no. There is. Now what step should I take?
Tl*the contact owns a 2002 toyota corolla. The engine is burning oil and there is no evidence of a leak. The mechanic stated that the failure is the engine. The mechanic put an oil stabilizer in the car to maintain the failure. The current and failures were mileage 73784.
Tl * - in october 2006, the contact took her 2002 toyota corolla to a repair shop because she was hearing a noise coming from the engine area. The vehicle had an odometer reading of 61, 313 miles. The dealer told the contact that there was no oil on the dip stick. The contact stated that she did not see an oil leak around her vehicle. The contact was also told she would need a new motor for the vehicle due to oil starvation, and that there was a sludge buildup in the motor. The contact stated she had taken the vehicle in for an oil change in june 2006, at which point the vehicle had an odometer reading of 56, 860 miles. The contact stated she also told the dealer about a grinding noise she was hearing. The dealer told her they could not duplicate the grinding noise. The contact would hear the noise when the vehicle reached speeds of 20-50 MPH. The contact stated there were no warning signs when the noise occurred. The warranty dept has told the contact they will not cover the failure due to vehicle neglect. The vehicle is at the toyota dealership. The contact has all of her repair orders for the vehicle.
I took my 2002 toyota corolla le in for an emissions test and failed. I was told that the repair would cost above $500 because the charcoal canister on my emissions control system had failed and I need to replace it. After researching this problem on the internet and speaking with my mechanic I found that this was a very common problem with corollas. I was also told that the reason for the failure is that the canister is set at an angle and it allows engine gases to liquefy and cause failure. I am upset because this car has fewer that 65000 mile on it and this is a major part failure. Please look into this for me and all the other people who have had this obvious vehicle defect. Thank you.
A few weeks back my car's check engine light came one (this was when the mileage was around 40,500). Since it was out of warranty so I took it to a aaa certified repair shop for investigation. I later came to know that the engine light was due to charcoal canister failure. Since the charcoal canister can only be obtained from the dealer so I later inquired about the repair cost. The total repair estimate was told to me around $480 which prompted me to search the web about similar repair issues. I came across several similar complaints related to charcoal canister for many toyota vehicles. I have always taken the car to the local toyota dealer for regular oil-changes,etc. I was alarmed that such an important part of the car would fail just a couple thousand miles after the warranty expiration. So I called the toyota assistance at 800‑331‑4331 on 6/3/2005 (reference # [xxx]). I was told that the dealer would contact me some time within the next 3-4 days but that never happened. Upon calling the toyota assistance center today again (6/16/05) I came to know that the dealer had never bothered calling me and had instead just left a notification in the electronic system that the regional center had refused to provide any information in this regard. My other car in the household is around 70,000 mi and it had never had any such problem. I would appreciate if the toyota looks into the charcoal canister failure issues more seriously and provides relief in that regard. A part of such importance and cost should not fail within such low miles. I have contacted the wisconsin department of agricultural,trade and consumer protection in this regard as well. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Changed design from timing chain to belt 2 months after release. Bolt attaching timing chain sprocket to cam shaft overtightened at factory causing thousands of dollars of damage to cam timing chain and sprocket and several other parts, and leaving me stranded in a national forest 45 miles from nearest services with no cell phone reception.
Vehicle was going about 45 MPH when all of a sudden the engine stalled unexpectedly. Vehicle was then towed to a repair shop, and results showed that the timing chain bolt was too tight, which bent the valve, and totally ruined other engine parts. Vehicle was then towed to a dealer for repairs.
I am writing regarding an issue with my 2002 toyota corolla. I recently had to replace an emissions control device in my car, a charcoal canister due to it being clogged. I am concerned that this may be a wide-spread problem because on the day that I had my car repaired, I met another person at the toyota service station with the same issue and who also had a 2002 toyota corolla. However, fortunately for her she was still under warranty so she did not have to pay for the repair. The warranty for this part is 3 years or 36,000 miles. Unfortunately for me, I was at the 38,000 mark on mileage and so I was out of warranty. Before I had the car fixed, I contacted toyota customer assistance center at 800‑331‑4331 (reference #: 200309021930) and after a bit of back and forth, they informed me that they would good will the part to me since I was right out of warranty, but I would have to pay for the labor. As a side to this story, toyota north in mt. Kisco (where I purchased my car) labor fee to replace this part is a $90 diagnostic fee plus 1.5 hours labor adding to a total of about $225. After shopping around, I found that toyota city in mamaroneck (located within the same county as toyota north) labor fee for the same job is $90 total. Obviously, I opted to go to toyota city to have the part replaced. My concern is how many clogged charcoal canisters had to be replaced in the 2002 model of a toyota corolla. I did contact the u. S. Department of transportation, the federal safety agency and filed a report regarding the failure on this part and hope that others would do the same. Overall, I don't think people are aware that they can file a report on this type of vehicle part, as they do not think it is related to a safety concern. I would like to get the message out to all toyota owners that it is very important to file a report on any auto part that fails regardless of the fact that it is covered under the manufacturer's warranty.
While driving, the engine light illuminated on the dashboard. *jb dealership wouldn't service vehicle without any appointment. When the consumer took the vehicle for service, she was informed vehicle was out of warranty because of the mileage. The defective part. The dealer "good willed" the part since the vehicle was just outside of warranty and the consumer just had to pay for the labor. *ph
"there is an off gassing of chemical in vehicle that is causing an irritation to consumer respiratory system".
Purchased car on 9-4-2001, no smell at all. Fuel pump goes bad and is replaced after 20 days owning car at 300 miles. After pump replacement I noticed very bad rotten egg smell. Took it to dealer for diagnostics and said nothing wrong with car, but it could be the fuel. It was advised to use 5 different fuels. Fill tank 3 times using each fuel until the car burns the gas that does not smell. They all smell and people as myself are getting sick riding in the car. The small happens at least twice a day with no set time. Some orders are light in smell then a strong smell that will force you out of the car. I have asked many owners of the same type of car who get gas at the same station I do if there car smells and everyone said no. I have contacted the dealer and a district tech from new york, and they have told me that they will not look at the car anymore and we have to go to arbitration. There phone no. Is 310- 618 4000. Something does not add up. Only one visit, the car still stinks, I feel sick driving it , no second visit to dealer, field tech brushing me off , and go to arbitration after one dealer visit. I want this investigated by your department , and I think it also my be time for law enforcement also .
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Toyota Corolla?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history