2003 Toyota Corolla transmission problems

Filed Oct 13, 2020 · Transmission · PR

Hi, I am from puerto rico. I have a toyota corolla 2003 1.8l, type s. The transmission of my car is manual and it is making an internal noise that has been increasing little by little. The noise is similar to a ball bearing when damaged. For the current price in the market, the mechanic recommended me to change the transmission for another used one that is in good condition. I have always maintained my car and I am surprised that a manual transmission car is failing. This model has present problems in the trasmition? Thanks, lisa hernandez

Filed May 18, 2017 · Brakes, Transmission · 90,000 miles · PA

Rear wheel bearings failure (safety defect) -- 2003 toyota corolla. Excerpts from my e-mail to toyota motor sales, u.s.a. Inc. Follow: "the local toyota dealership has recently recommended replacing the rear hub axle bearings due to a humming noise, at a cost of over $1,000.00. This recommendation has floored me as this type of repair for a vehicle with only 90,000 miles does not seem to be consistent with the quality standards promulgated by toyota motor corporation. Apparently, this problem is widespread as a technical service bulletin (the federal safety agency #10015608) was issued." the toyota customer experience center subsequently acknowledged the rear wheel bearings issue addressed in my e-mail above, creating case # 1703301220. Despite toyota having issued technical service bulletin #00105 on this very matter, the toyota representative at the customer center clearly stated in a subsequent phone call there is no warranty coverage, no customer notification, and no-recall issued. After contacting the toyota customer experience center, I was reluctant to replace the rear wheel bearings for almost $1,000.00 if the only issue was with humming which blended in with normal road noise. But the mechanics at the local toyota dealerships subsequently warned me that failure to have the rear wheel bearings replaced meant I was driving a car with a serious safety hazard with a significant probability of wheel failure (I.e. The bearing(s) could completely fail at any time and cause the rear wheel to fall off the car). I then authorized the local dealership in april 2017 to replace the wheel bearings (at my expense). One cannot but wonder how many accidents or incidents in connection with rear wheel bearings have occurred with toyota corollas for drivers who unknowingly drive their vehicles with rear wheel bearings that have been compromised or failed.

Filed May 5, 2015 · Transmission · 139,000 miles · CA

Original transmission was replaced at 124,000 miles, and only 3 years later, and 25,000 miles later, it now needs another transmission. Not the dependability I was expecting. In both instances, the same thing occurred; although it went out on me a lot faster the second time around. I heard a grinding sound every time I accelerated, until it finally went out on me and locked up both times. The first time I was on a side street, and it happened while I was approaching red light (and only reverse worked, so I was able to reverse it into a gas station nearby). The second time was a bit more scary (and I'm pissed off about this even more, now that I'm reading everyone else's story, because I could've been in a major accident). I was driving 65 MPH down the freeway (in the 3rd lane in) when all of a sudden my car bucked (jerked back) on me. I immediately got off the freeway within 5-7 seconds (thank god I was able to), when all of a sudden it completely froze/seized/locked up on me and proceeded to skid out about 15 feet along the side of the freeway only a second or two after getting off. The more I think about it, the more I am thankful that I was able to get over so quickly or it could've been disastrous. Nevertheless, I just got it towed to the local toyota dealership, and am looking forward to what they have to say. I am printing out all the links/forums/articles that I have found about this very specific problem with this very specific year and model (with only manual transmissions have you). Not sure what they will do about (my guess is they'll say tough luck and tell me it's going to cost me $3600, and then I'll have to have it towed to another place that can do it with a rebuilt transmission for $2000), but I'm going to give it a try. It really angers me that they can allow this problem to persist and put people's lives in danger.

Filed Mar 27, 2015 · Engine, Transmission · 126,857 miles · MN

In 9/2007 the transmission and clutch went out on my manual 2003 corolla. Conveniently, it was beyond the warranty period. I spent a significant amount of $ repairing. Again, in march 2015 the transmission and clutch are going out on my manual vehicle. After researching, I found numerous owners experiencing the same problems. There is a serious defect in the 2003 manual corolla that was apparently fixed in the 2004 version. I have contacted toyota several times. They will do nothing. They told me to email the federal safety agency and your agency would determine a recall. Please, please, please put this problem on the recall list. I (and numerous other owners) have been stranded along the highway and it is not safe!

Filed Dec 22, 2014 · Transmission · 16,000 miles · MD · crash

I was stopped at a red light. When it turned green I started to accelerate and turn the transmission blew. Subsequently, I was read ended. I started to do research and found that the 2003 toyota corolla has excessive transmission issues.

Filed Nov 18, 2014 · Transmission · 150,112 miles · NY · crash

I was driving down freeway at 55mph and without any warning transmission made loud noise and then locked up, since car is front wheel drive I had no steering as front wheels locked up. Car then started to go into a spin, but I was able to fight the wheel and steer car to side of road. It was only by luck that there were no other cars or tractor trailers along side or in back of me, after all said and done with towing cost and having to rent a car for work, I am out $645.00 and still no car! I had two transmission repair shops look at car, both said the same thing that some part came loose in transmission and destroyed it, it would need to be completely replace at a cost of $2700 -$3300 in the meantime I started doing research on that transmission and what I was told by the repair shops and from my own research it is very clear that the #toyota corolla and other models that used that manual transmission have had the very same problems. Please demand a recall !!!

Filed Sep 4, 2014 · Transmission · 114,104 miles · CA

I am the original owner of a 2003 toyota corolla s with a manual transmission. In november 2011, the bearings in my transmission failed on a long trip at just over 93,000 miles. The failure in the bearings destroyed the transmission and disabled my car on the freeway. I had it towed to an auto shop where I purchased a brand new transmission from the local toyota service center. It was installed, as well as a new clutch. I reported this incident on your website previously. This last month, my transmission began to grind going into 3rd gear. I bought it in to my local mechanic and found out the transmission is failing. It will either need to be rebuilt or replaced. The transmission is not even 3 years old and has just about 21,000 miles on it. Toyota will not warranty it. Their coverage is for one year, unlimited mileage. A new car with a new transmission is covered for 5 years/60,000 miles. There is no reason this transmission should have failed. I take excellent care of my car and had hoped to drive it for 20+ years. I have had routine service performed on it and mostly drive my car on long trips as I ride to work most days. A simple google search shows that these issues I have had with my car are very common for my model car with a manual transmission. Toyota will not do anything about it simply because the overwhelming majority of cars they sell in the us are automatics so issues with manuals can be ignored. They need to be held accountable for producing a transmission that can't even hold up to an industry standard warranty. Transmission failures are dangerous is it is unacceptable that toyota continues to get away with not coming up with a repair that prevents this from happening.

Filed Nov 25, 2013 · Transmission · 62,000 miles · NY

Tl* the contact owns a 2003 toyota corolla. The contact stated that the gear selector light would not illuminate and he was unable to determine what position the gear selector was in. The vehicle was not repaired. The contacted informed the manufacturer of the defect. The failure mileage was 62,000.

Filed Sep 19, 2013 · Transmission · 121,900 miles · OR

The c-59 five speed manual transmissions in the 2003 corolla model year, both corolla and matrix, are known to be prone to early bearing failure, due apparently to a faulty batch of bearings. I was driving on a freeway when I first heard bearing noise from my transmission. I took it to a transmission shop that confirmed the noise was from one or more bearings in the transmission and offered me a choice of replacing just the bearings, a full transmission rebuild, or a new transmission. Should the bearing have failed on the highway and blown up my transmission, I could easily have lost control of the vehicle resulting in a nasty accident. Toyota refuses to do a recall, but there are dozens if not hundreds of anecdotal reports of this exact scenario scattered online. The earliest symptoms are a grinding or whirring noise coming from the transmission (or more generally, from the engine compartment). If the faulty bearings are not replaced, they will eventually grenade (shatter and act as shrapnel, destroying your transmission) and you'll need a new transmission. My vehicle has been maintained by toyota dealers for its entire life, save a single oil change while on a road trip. There is no reason a manual transmission should fail this early in its life. I've never raced it or abused it any way.

Filed Aug 18, 2013 · Transmission · 91,000 miles · IL

At just over 91000 miles my very well maintained 2003 corolla with a manual transmission had a complete transmission failure at highway speeds. While accelerating the transmission suddenly made a loud grinding noise followed by a "thud" and completely locked up on me. I ended up stuck on a busy highway with my two young boys in the back seat. In researching this problem I have found that it is a well documented occurrence with this specific year and model of toyota corolla. Ultimately I will be putting in a new transmission in from a different model of toyota and trading the car in with the hope that this will not happen to the next owner.