2025 Toyota Grand Highlander engine problems

Filed Sep 28, 2026 · Engine · TX

Engine temperature overheated during long idle on an out of town event. The vehicle put in park and engine running in idle with AC running. Vehicle coolant temp reach high mark in the red area. Vehicle temp alarm gave a warning to shutdown. I estimated the car idle time 40 min due to traffic accident ahead. The incident occurred on 9/11/26. The car was taken to dealer 9/17/26 for checkup/diagnose the issue. Dealer stated, they could not duplicate the issue. But they did my find the vehicle computer log, the engine registered high temp.

Filed Sep 21, 2026 · Engine · 15,000 miles · WI

The contact owned a 2025 Toyota Grand Highlander. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with radiator failure. The contact was informed that there was a hole in the radiator. The contact was informed that the radiator needed to be replaced. The vehicle was repaired. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 15,000.

Filed Sep 18, 2026 · Engine · OK

A piece of road debris/rock struck the radiator/heat exchangers in my 2025 Toyota Grand Highlander Hybrid that immediately damaged the radiator/heat exchangers to result in coolant leakage and sudden loss of propulsion and terminated the engine from moving and required a tow to a Toyota dealer and thus a replacement of the heat exchanger/radiator. It came apparent from their experience that the design of the front-end grill has large, open apertures and no protective screen between the grill and the vehicle’s heat exchangers. Had to file an insurance claim under comprehensive coverage that required me paying a deductible for repairs and NOW stress in future driving experiences.

Filed Sep 14, 2026 · Engine · 15,450 miles · TN

The contact owns a 2025 Toyota Grand Highlander. The contact stated that while driving 70 MPH, the air conditioner failed to operate. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the condenser had failed and needed to be replaced. The dealer informed the contact that the front grille had large open apertures and no protective screen between the grille or the heat exchangers. The vehicle was repaired. The contact stated that the failure was associated with the federal safety agency Investigation: DP26006 (Engine and Engine Cooling). The manufacturer was made aware of the failure by telephone, and a case was opened. The failure mileage was approximately 15,450.

Filed Sep 8, 2026 · Engine · 14,300 miles · MT

The contact owns a 2025 Toyota Grand Highlander. The contact stated that while driving approximately 35 MPH, another vehicle struck a rock, and the rock went through the front grille of the vehicle and punctured the inverter radiator, causing a coolant leak and a loss of motive power. The message "Hybrid System Malfunction" was displayed following the loss of motive power. The vehicle was towed to a dealer, where it was diagnosed and determined that the inverter radiator had sustained a puncture and needed to be replaced. The vehicle was repaired. The contact associated the failure with the federal safety agency Action Number: DP26006 (Engine and Engine Cooling). The failure mileage was approximately 14,300.

Filed Aug 25, 2026 · Acceleration, Engine · PA

I continuously have issues accelerating from stop in my max hybrid. the issue is particularly worse when it is warm out. I press the gas and the RPMs drop really low and I barely move through the intersection for a few seconds. Once it finally registers after a number of seconds, the RPMs rev up over 4000. It is very dangerous trying to proceed through an intersection and the car basically stalls when I press the gas. It especially concerns me that I have my child in the car with me and I worry when it is going to act up. I know others have experienced this issue and there was a TSB for 2024 models that had this issue. I have a 2025 and experience this issue. I have had toyota look at it and they said they cant do the TSB since it's bot for my VIN. A solution needs to be found for the the safety of myself and others.

Filed Aug 4, 2026 · Electrical, Engine · PA

Rodent damage to plant based wiring to Engine Harness A and valve vacuum hose. Cost $1700 and 2 repairs.

Filed Jul 15, 2026 · Engine · MI

This vehicle has just over 18,000 miles on it and is 14 months old. It has a manufacturer design defect that allows small stones or birds to hit and puncture the air conditioning condenser. It is a known defect and Toyota refuses to warranty their product, forcing the consumer to pay out of pocket $1,500-$1,700 for repairs. Oddly, the sister Lexus vehicle has a screen over the condenser to prevent this.

Filed Jul 15, 2026 · Acceleration, Engine · FL

After coming to a complete stop at a stop sign or stop light, then trying to go, the vehicle will stall. It will not go when given gas. The first time it happened, I was at a busy intersection with oncoming traffic coming towards me with the pedal to the floor, nothing would happen for 5-10 seconds. It was terrifying. Thank god the car coming towards us went around in time. It then happened again in my neighborhood a week later. Thankfully that time I wasn’t in traffic. I have noted that it seems to happen when very hot outside (Florida July summer) and air is on full blast. Also seems to be happening only during the first trip of the day, within the first 5-10 minutes of said trip. The dealership has not been able to recreate this to see for themselves. I think it would have to be with them overnight and they start it/drive it for the first time that day. It has now happened a total of 3 times since I’ve been driving it (2.5 months). I have 3 children and very worried I will get t-boned one day when it stalls next. I love my car so much so it’s heartbreaking that I have to drive it in fear. No lights/warnings/messages when this happens.

Filed Jul 14, 2026 · Electrical, Engine · NM

Radiator issue summer of 2025, when in back to back traffic at low speeds my vehicle overheated at a stand still took vehicle in to dealership with no real answers. The following summer 2026 same scenario but the engine was smoking. Took into dealership and they stated the connection for the radiator fan was disconnected which meant it was not colling the engine. A month later the AC is blowing hot air when AC is set to the coolest setting, scheduled another appt with dealership likely another radiator issue. Fuel gauge inaccuracy. Manual states 17 gallon tank capacity but my car states empty and can only fill the tank with 14 to 15 gallons. Dealership had no help and stated it does that to protect the hybrid engine. Transmission shifting issues, in the summer hotter temperatures I notice at times the transmission has difficulty shifting in lower gears and really revs up the RPMs to shift sometimes. At times the the transmission shift is jerky or harsh when going speeds form 20- 40 mph.