2026 Toyota Grand Highlander: sunroof shattered

Filed Nov 5, 2026 · Body · TX

Rear moonroof glass shattered spontaneously, no object impact

Filed Sep 29, 2026 · Brakes, Seat belts · PA

June, July and August multiple occurrences of Electronic Parking Brake and Drive Engagement Failure intermittently occurring. The Automatic electronic park brake fails to release from Park to Drive or Park to Reverse while drivers seatbelt is fastened, all door closed, vehicle on level ground. Vehicle behaves as if it's still in Park and revs RPM with gas pedal pressed without movement. Vehicle may abruptly lunge once engagement finally occurs after vehicle on/off & multiple Park to Drive manually placed. Seatbelt of driver has stated that the drivers seatbelt is not buckled when it is and all doors are closed. Display on the info display states that driver door is open when it's closed and that seatbelt is unfastened, when it is fastened. Push start button intermittently fails like it has a dead battery. Button is pressed at appropriate length to start but sputters or hesitate before finally starting with sometimes multiple attempts. Excessive wind noise due to roof seal being raised. Roof weather stripping was lifted/separated. There was no full replacement of this issue on September 17th at a local dealer but rather a quick fix of refitting the molding. I stated that is not the appropriate fix due to the actual factory seal stating it cannot be reused once compromised. Today, September 29th, the back panoramic sunroof exploded going down the highway with no other external impact and was stated as a possible occurrence after a seal is not replaced appropriately. It is note in my Toyota case management file as well. Overhead console electrical failure had been fixed may 28, 2026 after purchase in March brand new. The drivers overhead light failed and all cabin lights surged when pressed. Driver door lock and key fob malfunction in June 27. The drivers door locked with the key fob still inside vehicle at center console. Toyota app indicates vehicle was unlocked. Driver door would not unlock by app. Had to crawl through the passenger side to manually unlock.

Filed May 4, 2026 · CA

Moon roof exploded while driving on highway. This is most likely due the to temperate glass used for the moon roof. No collision happened, no debris flying from somewhere else hit the glass, there was no cause for it shatter, the glass just exploded almost causing my family to get injured from glass shards falling down. Thankfully the cover was there and the moon roof wasn’t open.

Filed Apr 21, 2026 · TX

My 2026 Toyota Grand Highlander Hybrid sunroof shattered spontaneously while driving - no impact, no prior damage. I was driving at 20-25 mph on a feeder way, approaching a signal

Filed Apr 21, 2026 · Body · TX

While driving at approximately 20-25 mph, the panoramic sunroof glass of my vehicle suddenly shattered without any warning. There was no impact from road debris, no visible chip, and no prior damage to the glass. The glass appeared to explode outward, creating a loud noise and causing shattered glass to fall inside the vehicle. This created a dangerous situation that could have led to driver distraction or injury. Safety Concern: This incident poses a serious safety risk. Sudden shattering of the sunroof while driving can: Distract the driver and lead to loss of control Cause injury from falling or flying glass Create hazardous driving conditions, especially at highway speeds Dealer Response: I reported the issue to a Toyota dealership, but they denied warranty coverage, stating it was not covered without providing evidence of impact damage. Additional Notes: There was no visible point of impact, which suggests a possible stress fracture or manufacturing defect rather than external damage. Request: I request that the federal safety agency investigate this issue as a potential defect, as spontaneous sunroof glass failure while driving presents a significant safety hazard.

Filed Feb 16, 2026 · Body · TX

We were going down the highway in our brand new Grand Highlander yesterday (3500 miles, 3 months old) and it was like a bomb had gone off. The panoramic sunroof exploded up and out. Glass started falling on my daughter whom was in the middle seat. My husband had to quickly pull off the highway to safety. I have never experienced anything like this and it was extremely scary. Obviously there is a defect that needs to be addressed.