2018 Toyota Highlander engine problems

Filed Oct 26, 2026 · Engine, Transmission · MD

While driving, my vehicle experienced a severe and sudden failure of the Aisin UA80F 8-speed automatic transmission. The transmission exhibits erratic and hard shifting, severe hesitation, and a dangerous delay in acceleration when trying to merge into traffic or accelerate from a complete stop. Frequently, the engine revs high, but the transmission fails to engage the gear promptly, resulting in a sudden, violent lurch forward when it finally catches. Furthermore, the vehicle intermittently loses motive power entirely while in motion, forcing me to coast to the side of the road. A loud, high-pitched whining noise is audible from the transmission assembly, and diagnostic checks indicate internal mechanical overheating and premature component wear.

Filed Oct 24, 2026 · Engine · PA

The UA80 transmission on my 2018 Toyota Highlander Limited AWD began the "death whine" at 110,000 miles. Brought it directly to a Toyota dealer and was told the transmission needed full replacement. Seems to be very common with these transmissions and there's a service bulletin that's advertised from Toyota (our VIN number was not covered despite the exact same issue described to a T).

Filed Oct 18, 2026 · Engine, Transmission · PA

My transmission had to be replaced at 30,000 miles and a year and two weeks later it needs replaced again at 42000 miles. Toyota will only cover 1/2 the replacement the second time and nothing the first.

Filed Jul 16, 2026 · Acceleration, Engine · TX

While driving my 2018 Toyota Highlander Limited, the check engine light began flashing off and on. I was near an exit and drove off the freeway. I could feel the car (near the gas pedal) start shaking, then the power went down quickly... as I was trying to find a safe place to go. The farther I drove, there was less power until the car was going about 2 miles an hour. The check light continued flashing as I pulled into a parking lot. This was very scary as I'm sure the car would have just stopped on the freeway if I had not been near an exit as it just simply had no power left. (The check engine light has been on over a year and I took it to three different mechanics. Not one could fix it. This car wiped out my savings and now sits at a Toyota dealership)!

Filed Jul 10, 2026 · Engine, Fuel system · NY

I just got my vehicle inspected and successfully passed with no codes on 07/07/2026. Today 07/10/2026 as I was driving to work my vehicle began to jerk/ jitter and when into limp mode. I took it to a shop to have the codes checked on it and they said it was something to do with the transmission and they don’t specialize in that type of work. My vehicle has less than 45400 miles on it and been maintained regularly. I was told this was a common issue with these vehicles. I don’t know where to go to get this serviced. I called around to local shops with no luck at getting someone to fix or look at the cause of it.

Filed Mar 1, 2025 · Engine · IL

Engine cam tower oil leak due to the manufacturer's inadequate assembly of the engine parts. The mating surfaces were not adequately prepared and/or application of a contaminated sealant did not adhere to the surfaces creating a small oil leak that eventually became larger and finally noticed. The Car Care Nut automotive shop performed this repair and documented in the video: [XXX] The 2018 engine (3.5L DOHC V6 D-4S Engine with Dual VVT-i Direct Shift) with 52,500 miles has by now (2024) developed a large oil leak coming from the cam tower seal, and requires replacement. I'm the original owner with the car always being garaged and maintained by the book at the dealer. Toyota of America is refusing any assistance with the defective engine component even though it is under the 60,000 miles powertrain warranty, but past the 60 months warranty period. The leak likely has been there since leaving the factory floor, but was not noticeable until after five years of use. Leaking engine oil on hot components of the engine bay may result in smoke, burning odor, and even fires. This vehicle has a concurrent vehicle safety complaint the federal safety agency ID Number: 11611353 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 11, 2024 · Engine · AZ

Wife was driving and out of nowhere axle to the transfer case broke leaving her stranded in the middle of the road. Seems like transmission had been a common issue in these vehicles around the same year

Filed Nov 24, 2024 · Brakes, Engine · MS

My husband took my car from the carport and parked it in the driveway near the water hose to wash the car. When he finished, it would not start. The message “Braking Power Low” , “STOP in a Safe Place”, “ See Owner’s Manual”showed up. Of course, we could not find anything in the large owner’s manual concerning that! I checked with my VIN to see if mine was included in the recall regarding this same matter, but it was NOT, just as all other Toyota Highlander 2018 owners who complained were told!!! We will find out tomorrow and pray it won’t be a lot of money. We have a Thanksgiving trip planned to see our grandchildren. Today is Sunday and we planned to leave on Tuesday. I shudder to think what could have happened if it suddenly stopped on [XXX] with all the holiday traffic. My husband was looking to buy a car after the first of the year and was going to buy a Toyota. After this, he has reconsidered. Toyota needs to see all these complaints and how many were not included in the recall!!! Something’s not right! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 6, 2024 · Electrical, Engine · PA

While driving the car at approximately 40 mphs the car suddenly jolted and stopped moving. Luckily no one was behind and I pulled over also noticing check engine light came on. I immediately called Toyota and was able to drive it to them. I spent $140 diagnosis fees for them to say it was ignition coil B. After replacing the coil the light and same problems continued. We took the car to another mechanic, spent $600 diagnosis fees to find out it is the ECM. We then contacted the Toyota dealer asking about previous recalls that were on the ECM for 2018 Toyota Highlanders which is our car. They stated our car based off the VIN has no recalls. How could this recall be for 2018 Toyota Highlanders but not for our 2018 Toyota Highlander with the same issues? Our car only has 80,000 miles.

Filed Oct 1, 2024 · Engine, Transmission · OH

The 2018 Toyota Highlander has less than 100K miles on it and has been diagnosed with an $11K repair for essentially a new engine! The dealership (Coughlin Toyota, Heath OH) has said it needs cylinder head assembly for $10,684.20. The error message we are getting is a "Check Engine" light "Take Vehicle to Dealership" and the AWD/ Traction Control shuts off. When searching online forums, there are MANY people experiencing the same problem, apparently a well know issue with Toyota (not just Highlanders). We have only owned this vehicle for a few years and believe this is a manufacturer error that desperately needs investigated. Please.