Tl* the contact owns a 2008 toyota rav4. While driving various low speeds, the steering wheel made a loud clunking noise and there was abnormal movement in the steering column. A dealer was not notified. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 107,600.
2008 Toyota RAV4 steering complaints
Page 2 of 4: complaints 11 to 40 of 73, newest first, as owners wrote them.
Steering intermediate shaft worn out : making clunking noise when turning either way also when reversing car toyota technician found this defect/issue
Very bad clunking / popping sound when I back up and turn my wheels. Seems to happen mostly when I first drive the SUV in the morning. Only has 96,000 miles on it.
I was driving my 2008 rav 4 and I made a turn & all of a sudden my steering wheel literally became free floating. I can move the steering wheel 8 to 12 inches up and down with no resistance. I can also move it 6 to 8 inches left to right with no resistance. It's not guided in any way, you can move it around in a large circular motion. I was able to still steer somewhat. The column still seems to be attached to something. When you do steer, it makes a horrible popping sound. The dealership said: a frame weld did give out for the steering column assembly. The steering column assembly is everything between the wheel and the intermediate shaft. The steering assembly is mounted to the instrument panel reinforcement bar. This is a large bar that runs the length of your dashboard. This bar has a few welded mounts on it that allow you to bolt the steering column assembly into, it is these welds which failed. The air duct on the drivers side fell onto my feet/pedals while I was driving. Luckily it didnt get caught behind my pedals. I soft drive approx 8000-9000 miles a year. I've had no accidents. Toyota is charging me $2200 to replace this & will not coer the costs. This is a major safety issue & I did reserch & this has happened numerous times! Check it out here: http://www.rav4world.com/forums/99-4-3-mechanical/115306-steering-assembly-frame-weld-broke.html
Tl* the contact owns a 2008 toyota rav4. While pulling out of the driveway, the steering wheel started to make a clicking sound and the check engine and ESC warning indicators illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the power steering assist motor needed replacement. The dealer was not contacted. The manufacturer was notified of the failure and provided case number: 1709132080. The vehicle was not repaired. The approximate failure mileage was 39,800. Updated 11/02/17*lj consumer stated the vsc light comes on and check engine. Now that the intermediate shaft does not work correct the cruise control does not work. Updated 7/17/18
Tl* the contact owned a 2008 toyota rav4. While driving 40 MPH, the steering seized and the vehicle crashed into a building. The air bags did not deploy. The vehicle was towed and deemed a total loss. The occupant sustained left and right broken arms, stitches, and a broken rotator cuff. Medical attention was received at west chester medical center. A police report was filed. The local dealer and manufacturer were not contacted. The failure mileage was 116,000. *ln
I bought my toyota with 47316 miles, no warranty. At 49000 miles my power steering lite started intermittently coming on, at 60000 miles it comes on all the time . Took the vechile to local toyota, was told by one gentleman he has seen this recently. Couldn't fix it as they have no programs for the issue. Told me to call toyota, they may help me with this high price issue. Talk to two different employees at main number. I was told they wouldn't do anything since, I have not had toyota do my maintenance. I explained to them, I have not had it long. But I have years of previous owners toyota maintenance. Said it's not in my name, I can't control the steering wheel when the p/s light is on. Can take up to 16 true to get it off. Toyota reset it , code came right back. This car is not broke in .this is not right the cost we pay for this. Hope someone makes them make there issues right size
Tl* the contact owns a 2008 toyota rav4. While the vehicle was being operated, an abnormal noise could be heard. The contact went to an independent mechanic who diagnosed that there was a steering column failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the dealer. The failure mileage was 59,000. Updated 06/23/17*lj
"takata recall" I had a wreck march 8, 2017 and I could not control the steering wheel and landed in some heavy bushes on a off ramp. When to the hospital with neck problems and put a report into my insurance. The car was in motion when the steering problem happen. On I-5 58 south bound off ramp near intersection with nw morgan street, grants pass, oregon happen so fast could not break.
I have 106.700 miles on my car and I start hear clicking and knocking noises inside on my rack and pinion when my car is not in motion and I turn my wheel I hear this noise also when ii hit potholes I feel something loose in my steering wheel as far as im searchig many people of toyota rav4 owners having same problem, toyota should make this as a recall
When turning the steering wheel a loud banging noise comes from the steering column. It feels very unsafe and scarey to drive. Was told it is the steering and that toyota is very aware of the issue with this year car, however since nobody has died yet it is not being recalled. The steering is sometimes unreliable and I never know if it will steer where I want it to or not. I am affraid to drive it, toyota tells me its safe. I am not willing to be the first one to die because of toyota greed to not recall and fix this huge safety issue. When car is in motion at low and high speeds turning any degree either way
Tl* the contact owns a 2008 toyota rav4. While operating the vehicle and turning the steering wheel in either direction, the steering column made a clicking noise. The vehicle was taken to an independent mechanic who diagnosed that the steering column was faulty. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.
1st issue was repeated recall over lower arm suspension bar that was permanently glued, to remedy safety concern. Now intermediate steering arm is bad, and problems w car swaying, and tires feeling wobbly. Being told toyota will not cover expenses to repair related suspension issue. $750.00 car has only 53,000 miles... Many other rav4 owners w same problem. Afraid to drive.
There are have been 6 recalls to date since we purchased 2008 rav4. Most recently, seatbelts were deemed unsafe in the rear, where we harness our children's carseats. This was in april 2016, and we have yet to be contacted about a remedy. Please let me know if there is anything I can do to push for a fix to this situation. We are frustrated that this car is a lemon, but not according to law, since the recalls are rolled out over the course of the last 6-8 years.
Clunk in steering wheel when turning to the left or right.
I hear a " thud noise " whenever I turn the steering wheel left or right, especially when getting in and out of a parking space.
Vehicle developed a clunk noise that could be heard and felt throughout the vehicle, especially in the steering system and especially during slow speed operation. The problem began in 8/2015 at ~45,000 miles. Vehicle also developed a loose feel in the steering and would pull to the right under hard acceleration. By 1/2016, the problem got noticeably worse. I then took the vehicle to a local auto repair shop for diagnosis/repair. After an hour or so of checking the entire suspension and steering system, the problem was diagnosed as a bad "steering intermediate shaft". The local shop owner stated he had replaced several of these same steering shafts on other rav4s around the same vintage (2006-2010). I contacted my local toyota dealership and the service agent also stated they had "several" incidents with this vintage of rav4s and steering shaft problems but there was no recall and since the vehicle was out of the warranty period, toyota would not cover the repairs. I then looked online to see if any other owners had the same problem and was shocked to see how many others have had the same issue with rav4s of the same vintage and had similar results with local toyota dealers. I believe this is a serious safety concern as eventually the steering shaft and/or shaft u-joint knuckles could fail due to this poor design and cause loss of control (steering) of the vehicle. Toyota does not seem to be taking this seriously, hopefully the federal safety agency will.
2008 rav 4 has less than 60k miles. Was experiencing a clunking noise when turning left or right at low speeds. Took my vehicle into the dealership and was told it needs a new steering shaft at a cost to me of $688. Upon researching this issue I have discovered that it has been an issue with this make, year and model for a long time. Would like to see a recall generated for this as toyota owners should not have to bear the cost of faulty manufacturing.
Having just exited I-95, I was turning the steering wheel to the right to pull up to the curb at the philadelphia airport to pick up a passenger. Upon doing so, the steering column made a loud pop or clunk sound, and the steering wheel immediately lurched approximately 6-8" to the left - and nearly out of my hands - almost causing me to crash into the crowd at the curb. After this sound occurred, the steering wheel (as in a previous complaint in 2013) was still operational, however was able to move approximately 6 - 9" up, down, right, or left while still remaining operable. Upon taking the vehicle to the toyota dealership, I was asked if I had been in a front-end collision (answer, "never"), as a factory weld had failed that keeps the steering column attached to a safety rod in the dash. Repairs are expected to run approximately $3,700. Matter has been sent to toyota corporate, however no word has come back. It appears as if I will be responsible for the full repair cost, despite failure in factory weld. Apparently no fail-safes are in place should this weld fail, such that a very dangerous situation arises, especially if this had happened three minutes earlier when I was in very heavy interstate traffic, instead of just having exited, and moving at 10 MPH or less.
On october 5 and 6, 2015 my 2008 toyota rav4 was in for service at piercey toyota in milpitas to replace all four tires, front/back brakes and front shock absorbers, a total of $2,000. On october 8, 2015, while I was driving my car back from stanford lucile packard over dumbarton bridge, I have noticed that my brakes would not engage and I could not slow down my car. Just before this event, the ABS, vsc, and slip warning lights all came on. The brake pedal felt very stiff and I was not able to do any repetitive pumping of the brake. I called 911 and requested assistance. When the front traffic came to a hold I had to use my emergency brake and my entire car slipped to the left. We almost got hit by the bus behind us. Some good samaritans saw what happened and helped me to get my car off the road. That day, my 9 yrs. Old son and I could have been killed. I request that toyota investigates/recalls the brake light switch circuit that has malfunctioned. Piercey toyota in milpitas investigated the incident on 10/09/15. They found c1249 open stop light switch circuit, c1223 ABS system malfunction, my vehicle had intermittent brake light switch circuit malfunction. Piercey toyota replaced brake light switch assembly.
I have a 2008 rav4. In 2010, I experienced a "clunking" or "thunking" sensation in the steering column on low speed turns. The dealer determined that a faulty intermediate steering shaft was the cause and replaced it. The same problem occurred again in 2012 and the dealer replaced the intermediate steering shaft again. In 2015, I had steering problems which had a similar feel (a "thunk" or "clunk" feeling when turning). This time the dealer determined that the steering rack and related parts needed to be replaced and charged me $2,400 for the repair.
Upon starting the vehicle and attempting to go in reverse, the power steering became difficult to turn. Had it towed to my mechanic and was told the electric steering control module and steering column motor assembly had to be replaced. Total cost was $3,300. This is becoming a common complaint and, considering the cost involved, should be thoroughly reviewed by the federal safety agency.
Tl* the contact owns a 2008 toyota rav4. While the vehicle was being serviced, it was discovered that the vehicle had a fractured steering rod. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was 89,901.
Clunking noise when turning the steering wheel.
We recently took our rav4 in for recall work. The service department decided to do a complimentary inspection on my rav4. We were told that the power steering pump needed to be replaced. It had never been a problem before. Now, the power steering pump is squealing on tighter than regular corner turning. I researched this issue on the internet. The disturbing, more constant compliant is that the power steering on my year, make and model will fail intermittently and then suddenly fail. This is a very serious issue since most of the drivers on the road are used to power steering and may not know what to do if the power steering should suddenly fail while driving. I want to make it clear that I am not blaming the dealership or the service department. They gave us a heads-up on what we had no idea was about to become a problem. The power steering pump problem is a serious issue, the rav4 is a family car for the most part.
Makes a clunking sound when I turn and I feel a "bump" in the steering wheel. I was charged $594.45 at the dealership for the repair replace the intermediate steering shaft. After searching online, I found that there are many complaints about this problem. Please enforce a vehicle recall for this problem.
Power steering became difficult,dealer replaced steering column. Problem with sensor located at column. Cost to me $1260.00.
Clunking noise from steering shaft that is both audible and felt through steering wheel. Occurs turning both left and right, going forward or reverse, but not when driving straight.
Requested steering shaft replacement during inspection (need attention soon). Thought that was odd. Went online and appears to be a problem with toyota vehicles. Called toyota 800 331-4331, they didn't care. Thought I file a complaint to get it recalled.
After being told I needed a steering intermediate shaft, I started investigating on the internet and come to realize there are hundreds of complaints on this issue dating back to 2007. When steering I hear a cracking sound and feel that it is a defect. All of the rav 4's are having the same problem, and this can really cause injury.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Toyota RAV4?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history