2015 Toyota RAV4 transmission problems

Filed Jun 27, 2025 · Brakes, Electrical · AZ

The battery is off . It does not work. The car does not start. It looks like the battery is not properly installed. I just left my car at the Toyota dealership in June 12 for maintenance services, for brake fluid and flush etc including the replacement of a battery mounting hardware however it does not look right. The car started to go off and today it does not start at all. Please advice Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 18, 2024 · Transmission · PA

Transmission shudder between approximately 25-40 mph. Toyota had a recall on some of the 2013-2015 RAV4 for this problem by the vin number. Car shakes and it has stopped running once at a red light

Filed Jan 18, 2024 · Transmission · 112,000 miles · OH

The contact owns a 2015 Toyota Rav4. The contact stated while driving 40 MPH and attempting to accelerate, the vehicle started to hesitate. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was repaired, but the dealer informed the contact that if the failure reoccurred, the transmission would need to be replaced. The manufacturer was not notified of the failure. The failure mileage was 112,000.

Filed Aug 10, 2023 · Transmission · NC

Toyota dealer in the area says transmission fluid does not need to be serviced unless we tow trailer and etc. Well the transmission broke down and we need to put a remanufactured one. This could be fatal incident if vehicle quits on busy highway.

Filed Aug 3, 2023 · Transmission · CT

Ever since I purchased it, it had a shudder between 20-50 miles. Called the dealer, they said it was normal with these cars. 6 years after and still making shudder noise just louder now and it bothers my ears. Took it in for a diagnostic at the same dealer I bought it and they said it’s not a torque converter issue (a bulletin was issued), but a transmission issue and it will cost $6.100 to repair.

Filed Jul 5, 2023 · Transmission · CO

While driving on the interstate the transmission stopped working. There was no indication that anything was wrong with the transmission. It was working fine and suddenly would not engage in any gear. This was a new OE transmission replaced six months ago for the same issue, with less than 9,000 miles on the new unit. I had to coast from the middle lane to the side of the interstate in heavy traffic.

Filed Jul 5, 2023 · Transmission · CO

Transmission stopped working while driving in traffic. There was no indication that anything was wrong with the transmission. It worked fine one minute and the next it would not engage in any gear.

Filed May 23, 2023 · Transmission · 120,000 miles · IL

The contact owns a 2015 Toyota Rav4. The contact stated that while driving at speeds between 20-30 MPH the vehicle had experienced a severe shutter and vibration coming from the rear end and the vehicle would not properly accelerate. The vehicle was taken to the local dealer who diagnosed that the torque converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 120,000

Filed Feb 16, 2023 · Transmission · AZ

At 100,000 miles my 2015 RAV4 started experience intermittent shuttering during aacceleration when car is shifting gears. It feels like driving over a rumble strip. I read about the ZH1 torque converter extended warranty for 2013-2015 Toyota RAV4 models. This has been a frequent enough issue that Toyota has extended the warranty up to 8 years or 150,000 miles, in which they will replace the torque corverter and ECM at no charge. I called Toyota Customer Care and gave my VIN number. According to Toyota, my car is not covered under the warranty becuae my car was built in May 2015 and the warranty only covers RAV4s built through Nov 2014. In their extended warranty bulletin, Toyota claims the RAV4s that aren't covered have different software logic. I have called Toyota back to find out what is different about my car's software logic, but they claim they do not know and to ask the dealer. Today I took my car into the dealer to have it diagnosed. Sure enough, the torque converter is locking up and I need to have the torque converter clutch replaced and ECM reprogrammed. The dealer said they dont know the difference between the software logic. The dealer recommends i call Toyota Customer Care back and ask to speak to a field representative, who should know that information. So far, Toyota has not been helpful in answering my question, but I am planning to get to the bottom of this. I have read that many other RAV4 owners are experiencing the same issue, where Toyota claims they are not covered because the car was built outside of the designated window. I don't think the issue was corrected properly in the later toyotas and that is why others are experiencing the same problem. This is a safety concern. The ststor clutch will cause the torque converter not to work as efficiently, driving down your gas mileage. In some extreme cases, the convertor may violently self-destruct. https://www.rav4world.com/threads/2013-2015-rav4-torque-converter-shudder-warranty-extension.311617/

Filed Nov 30, 2022 · Transmission · VT

Toyota poorly designed the torque converter for this vehicle leading to future transmission failure prematurely! I have had two torque converters replaced due to them failing!!! A torque converter when it fails pushes metal shavings into the transmission leading to transmission failure most manufacturers when a converter fails they check the transmission and if there is shavings they replace it. I had my torque converter replaced under a a special program through Toyota but it only covered the torque converter and no additional parts. I had to have my axle replaced twice and my seal after torque converter replacement covered by the dealership not even Toyota warranty under the torque converter recall or special program. I have complained about my transmission since day one of owning the vehicle originally told it was normal operation down the road Toyota admitted to the torque converter issue but does not cover the transmission even though if the torque converter fails or is faulty it is destroying the transmission and the transmission should be covered. My vehicle Not only financed through Toyota financial service only at Toyota with Toyota and they offer no customer assistance it is almost $8000 just to replace the transmission, which should be covered and recalled under the torque converter failure. I would love to keep this car for its lifetime but 80,000 miles to 130,000 miles I have driven it with a failing transmission and torque converter Toyota will not replace the torque converter again it is an expired coverage at this point now that it has been done. I wish they would stand behind our customers a little better. My 2015 Chevy Silverado is in the shop now for torque converter failure & they are replacing the transmission along with the torque converter because they know the torque converter causes transmission failure it's covered by Chevy! I made a case with Toyota & Better Business Bureau trying to get a even some form of assistance DENIED by Toyota