2022 Toyota RAV4 body problems

Filed Sep 22, 2026 · Body · MD

The contact owns a 2022 Toyota RAV4. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the front driver's side door. The contact inspected the vehicle and became aware that there was water in the door panel. In addition, the contact later became aware that there was water inside the passenger's side front door panel. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer, but it was not inspected. The contact was informed that the failure was not covered under warranty.

Filed Jul 7, 2026 · Body · TX

My 2022 Toyota RAV4 has experienced failures of the power door lock actuators on both front doors. Neither the driver's side nor the front passenger door consistently locks or unlocks using the key fob, interior power lock switch, or automatic locking system. This creates a significant safety concern because the doors may remain unlocked when the vehicle is parked, creating a security risk, or they may fail to unlock quickly during an emergency. In addition, occupants may believe the doors are secured when they are not. The problem has occurred on both front doors, indicating this is not an isolated component failure. The issue developed under normal use and was not caused by an accident, abuse, or modification to the vehicle. Multiple Toyota owners have reported similar failures involving door lock actuators in the same generation of vehicles, and there is pending litigation alleging Toyota has long been aware of this defect but has not issued a recall. I am submitting this complaint because I believe this defect presents a safety risk and warrants investigation by the federal safety agency

Filed May 28, 2026 · Body · 40,000 miles · NC

The contact owns a 2022 Toyota RAV4. The contact stated that while driving at various speeds during rainy weather conditions, water would leak inside the front driver-side door and puddle. The vehicle was taken to a local dealer, where it was diagnosed with a deteriorated sealant. The vehicle was repaired. In addition, the contact stated that while driving at various speeds during rainy weather conditions, water would intrude into the rear driver-side door and would accumulate inside. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to costs. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

Filed Apr 3, 2026 · Body, Electrical · CA

The driver side door lock actuator makes a long click noise. Also when I unlock my car it makes the same sound

Filed Apr 3, 2026 · Body, Electrical · CA

When I put my car on park. The driver side (left door) lock actuator makes a long click noise. Also when I press on unlock it makes that sound as well

Filed Jan 23, 2026 · Body · WI

Rear lift gate hinge bent. No known cause other than hinge may be faulty

Filed Nov 21, 2025 · Body · NJ

The Panoramic Sunroof Shattered on its Own out of nowhere. It just made loud noise. we thought it was tire, but car did not make move, looking above we saw the panoramic section of sunroof shattered. I went to dealer, they said there is a point of contact (means something has hit the roof) and they told me i have to file with insurance company. Insurance company is asking a million questions. It seems they are both passing it to each other. TO my opinion it is manufacturing flaw. very unsafe!

Filed May 30, 2025 · Body · GA

When it rains, the water goes inside the door. So I have lots of water in my door. Toyota didn’t properly seal the outside of the door.

Filed May 8, 2025 · Body · 9,512 miles · FL

The contact owns a 2022 Toyota Rav4. The contact stated that after heavy rainfall, there was a swishing sound coming from the passenger’s side rear door. The contact stated that when the vehicle was parked, the contact inspected the vehicle, and became aware of water build-up in the passenger’s side rear door. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 9,512.

Filed May 2, 2025 · Body · OK

Every time it rains our Rav 4 gets water in the back doors. It sloshes around and you have to manually pull the seal back to drain. It happens every time. my understanding is this is a known issue.