2022 Toyota RAV4 technical service bulletins
182 technical service bulletins and manufacturer communications cover the 2022 Toyota RAV4.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- In wet conditions, water contacting the radiator in the subject vehicles after idling for an extended...
- Technical instructions for emission noncompliance recall 26TC03
- Some customers may experience a rough running engine with a MIL ON P140018 DTC. Upon further inspection, a...
- Obsolete notice
- Obsolete notice
- Some 2018 – 2024 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System...
- Some RAV4 vehicles power seat where the automatic seat adjustment by the memory function does not work.
- Condition in which a musty odor is present
- Although the HV Floor Under Wire Harness and Rear Traction Motor Cable is covered by Toyota’s New Vehicle...
- MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) upon cold soak start up...
- The air conditioning dye injection tool kit has been developed to aid in identifying the location of air...
- Reduced engine power and/or a MIL ON condition with one or more of the following throttle body Diagnostic...
- To assist with the early detection and early resolution of audio related concerns you may be asked to...
- Some 2018 – 2024 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System...
- The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master...
- Some 2021-2025 MY Highlander HV, Sienna HV, RAV4, and RAV4 HV, may exhibit an oil leak from the area where...
- TT: Engine Oil Leak between the Lower Oil Pan and Crank Case
- Squeal/squeak noise from the front brakes with light to moderate braking.
- Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical...
- To prevent brake rotor rust from forming during transportation and storage, wheel film will be used...
- The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix...
- Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal...
- Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad...
- Some technicians may report an engine oil leak from the Engine Oil Level Sensor area
- The subject vehicles were delivered with only one (1) Smart Key on select models since October 2022 due to...
- The supply of Smart Keys available for Toyota vehicles has been temporarily limited to one (1) on select...
- Second key delivery program 23TJ01
- The table below describes the phases currently planned for the Second Key Delivery Program and the...
- Customers may experience a MIL ON, or an intermittent MIL ON condition, accompanied by DTC P140018,...
- Some 2022 model year Avalon and Avalon Hybrid, 2022 – 2024 model year Camry, Camry Hybrid, Corolla,...
- Second key delivery program
- The table describes the phases currently planned for the Second Key Delivery Program and the estimated...
- P010012 or P010014 DTC sets after driving in the rain
- Condition in which a musty odor is present
- This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for...
- Safety Recall and Service Campaign completion is an important part of our commitment to customer...
- Toyota plans to conduct Safety Recall and Service Campaign follow-up notifications to owners whose...
- Second Key Delivery Program Frequently Asked Questions
- Second Key Delivery Program
- Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal...
- Customers have expressed concerns about the performance of Qi Wireless Chargers
- DP: The subject vehicles were delivered with only one (1) Smart Key on select models since October 2022...
- This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life...
- The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master...
- DP: Although the HV Floor Under Wire Harness and Rear Traction Motor Cable is covered by Toyota?s New...
- Ti: technical instructions for customer support program 22TE09 HV floor under wire harness and rear...
- MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) upon cold soak start up...
- Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System...
- One or more of the following conditions: ?Milky/discolored engine oil
- TT: Some 2020-2022 vehicles equipped with North American Produced (NAP) A25A-FKS/FXS engines may...
- Reduced engine power and/or a MIL ON condition with one or more of the following throttle body Diagnostic...
- RL: The supply of Smart Keys available for Toyota vehicles has been temporarily limited to one (1) on...
- Ti: technical instructions for 23TJ01
- TT: Some 19CY LG DCM equipped vehicles may not be able to complete the firmware update due to not having...
- TI: TECHNICAL INSTRUCTIONS FOR CUSTOMER SUPPORT PROGRAM 22TE09 HV FLOOR UNDER WIRE HARNESS AND REAR...
- The air conditioning dye injection tool kit has been developed to aid in identifying the location of air...
- Water entry to the vehicle from the HVAC drain hose being disconnected from the air conditioning radiator...
- TT: A very small percentage of customers experience operational difficulties with some telematics features...
- Obsolete notice
- Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN...
- TT: Some 2021
- TT: This issue is currently under investigation
- MIL ON condition with one or both of the following Diagnostic Trouble Codes (DTCs) present: ?P24517F ?...
- TT: Some 2022-2024 MY vehicles equipped with the A25A engine may exhibit a leak from the engine water...
- DP: Although the high-pressure fuel pump is covered by Toyota?s New Vehicle Limited Warranty for 5 years...
- TT: Some Model Year 2018-2023 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the...
- TT: Some 2021 to 2023 MY vehicles equipped Rear Motor Generator, MGR (Q610) may experience an oil leak concern
- MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: ?P0087/P008700...
- TT: Some 2019- 2023 RAV4 HV vehicles may duplicate an abnormal noise (Growl, Humming and/or other) from...
- TT: To assist with the early detection and early resolution of audio related concerns, it may be requested...
- Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System,...
- Squeal/squeak noise from the front brakes with light to moderate braking
- TT: Some 2019- 2023 RAV4 HV vehicles may duplicate an abnormal noise (Growl, Humming and/or other) from...
- Condition in which a musty smell is present
- TT: Some MY2022-2023 vehicles equipped with A25A-FKS or A25A-FXS engines may experience a MIL on condition...
- TT: Some Model Year 2018-2022 vehicles equipped with A25A-FKS or A25A-FXS engines may experience a MIL ON...
- DP: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured...
- DP: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured...
- Ti: technical instructions for special service campaign 22TC05
- DP: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured...
- RL: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured...
- Ti: technical instructions for special service campaign 22TC05
- TT: Vehicles listed above equipped with a Denso Ten radio (Entune Audio Plus or Premium Audio) may exhibit...
- TT: Some vehicles may exhibit seat memory switch function inoperative condition if the Seating Position...
- This condition may occur when the vehicle is operated at high altitude and high temperatures; typically,...
- MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present:...
- Paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are...
- One or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or...
- This bulletin includes basic procedures for performing a rescue charge at battery on high voltage (HV)...
- This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode?...
- TT: To improve customer support of telematics connected services features, additional resources have been...
- TT: Vehicle control apps might not operate as expected at times due to preconditions (normal operating...
- Hybrid vehicles are equipped with two types of batteries: ?Hybrid vehicle (HV) battery
- TT: On some 2021-2022MY Highlander HV, RAV4 HV, RAV4 Prime and Venza models, the connector cover for the...
- Obsolete notice
- Obsolete notice
- A battery in a stored vehicle is subject to conditions that can reduce its performance and service life
- Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery
- TT: When customers have a concern about a discharged battery, no start, or general battery concern, the...
- Obsolete notice
- 2022 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat...
- Sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a...
- TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire...
- TT: Some customers may experience the inability to activate Remote Connect or Remote Connect becoming...
- POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground...
- One or more of the following conditions: ?Milky/Discolored engine oil
- Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers
- One or more of the following conditions: ?WiFi intermittently inoperative
- An initialization procedure is required to activate the Entune? 3.0 App Suite Connect for Audio, Audio...
- TT: Some 2021-2022 TMMK built vehicles with A25A-FKS/FXS engines may exhibit an oil leak from the No.2 Oil...
- Sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a...
- TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera,...
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Toyota RAV4?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history