Toyota RAV4 check engine light comes on

Filed Nov 3, 2026 · Engine · PA

My transmission failed, torque converter. My check engine light came on with "AWD malfunction" on the dash on 10/21/26. I had to get it towed to the closest dealership. I was told it is covered under warranty to replace and repair, the following Tuesday 10/27/2 I havd to call and ask what was going on. They then informed me the part is on back order until end of December (they do not have a date) 2026- Leaving me with no vehicle for 2 months, Krause Toyota will not let me drive the car (not state legal with a faulty transmission) and only gave me a rental for 5 days. I am now forced to pay out of pocket for however long they will have my Rav4. I have called the Brand Engagement department and they have not been very helpful. The guys in the service department at Krause are extremely rude and bothered by the fact that I had questions. I did ask about the lawsuit regarding my 2019 Rav4 faulty transmissions and they said they didn't know anything about it. Any help regarding this very frustrating matter would be helpful.

Filed Sep 15, 2026 · Engine · FL

Component: Engine — Engine Cooling System — Coolant Pump Summary: The electric water pump on my 2019 Toyota RAV4 failed prematurely at 64273 miles. The check engine light illuminated with diagnostic trouble code P26CB (Engine Coolant Pump Performance/Stuck Off). The engine coolant temperature fluctuated rapidly / coolant level dropped. The vehicle required immediate repair to avoid engine damage. This is a recurring failure pattern on 2019–2021 Toyota RAV4 and Camry vehicles equipped with the 2.5L A25A-FKS engine, where the electric water pump seizes due to an apparent defect in its plastic housing and rotor assembly. Failures are routinely reported at 30,000–60,000 miles—far below the expected service life of the component. Loss of coolant circulation creates an overheating hazard and can lead to sudden loss of propulsion and engine damage while driving. Toyota has issued technical service bulletins related to coolant seepage at the pump but has not recalled the component or extended warranty coverage, leaving owners to bear repair costs of $600–$1,300 for a premature defect-driven failure. I request the federal safety agency to evaluate this defect for a safety recall.

Filed Sep 3, 2026 · Body, Driver assistance · NC · fire

I was driving 9/3 and my left blinker light came on solid. I was not using my blinker. Within a few seconds my check engine light came on and another light. Then within 2 minutes the front left engine/tire caught fire.

Filed Aug 23, 2026 · Driver assistance, Fuel system · CO

While driving in the mountains on a hot day, the car suddenly reported numerous faults, including check engine, parking brake malfunction, pre-collision system malfunction, AWD system malfunction, and secondary collision brake system malfunction. The car lost power and forced us to pull over on the side of a dangerous mountain highway. We powered-off the car for a few minutes and started it again and were able to proceed to our nearby remote mountain destination without another loss of power, but the faults remained. The next day we were able to get the car to a nearby NAPA store to read the check engine codes, which there were only 2 of the "P0087" code. I had them clear the fault codes in order to be able to safely drive the car (~120 miles) back home. Some quick research shows a known issue and TSB for that in our exact high-altitude and high-temperature situation - Toyota T-SB-0058-22, related to a known design flaw with the ECM and fuel suction tube. Luckily, it did not throw the errors again during our drive home. I made an appointment at our local AutoNation Toyota Arapahoe for the following week. I detailed the issue and provided pictures of the errors - including the code reader display. The dealer claimed to not find any issues and refused to address/execute the TSB, stating that the code must be active and present in order for them to fix it and that my pictures were not sufficient proof. I explained that it was an unacceptable safety risk to have left the car in that state and that the issue is known to only occur in certain conditions (e.g. high-altitude, high-temperature mountain driving). Issue remains un-addressed, which is highly unacceptable and poses a serious on-going safety risk.

Filed Aug 20, 2026 · Steering · 50,000 miles · NC

The contact owns a 2022 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power, and the "Low Steering" message was displayed on the instrument panel. The check engine warning light was illuminated, the vehicle shuddered, and then stalled as the contact pulled into a parking lot. The failure had occurred on several different occasions. The contact attempted to restart the vehicle; however, the vehicle failed to return to normal operation. The vehicle was towed to a dealer where it was diagnosed with an inoperable port fuel injector. The vehicle was repaired; however, the failure persisted. The vehicle was taken to another dealer and was diagnosed with inoperable port fuel injectors. The contact was informed that the port fuel injectors needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.

Filed Aug 17, 2026 · Electrical, Engine · MA

2021 Toyota RAV4 (gas model) has experienced a sudden, unexpected engine stall/shutdown on a public road. The incident occurred while shifting into Drive after backing up in reverse. The engine immediately died without any prior dashboard warning lights or mechanical symptoms. The information screen displayed a message stating "Put Car in Park" or "Shift into Park." The vehicle safely restarted immediately after shifting back into Park and pressing the ignition button. This intermittent stall has happened three times under the exact same directional shifting conditions over the last 1.5 years, creating a high-risk scenario for a rear-end collision in active traffic. After previous incident (one year ago) when the engine stopped when shifting from reverse to drive, I took it to Toyota service. Dealership diagnostics could not previously replicate the issue due to its intermittent nature and the absence of a permanent check engine code. checked battery and performed health check.

Filed Jun 25, 2026 · Driver assistance, Electrical · 189,000 miles · AZ

The contact owns a 2015 Toyota Rav4. The contact stated that the radio was inoperable. The contact stated that the gauges failed to properly operate. While driving 65 MPH, the vehicle lost power steering functionality. Additionally, the rearview camera image was reversed before becoming inoperable. The ABS, AWD, and engine warning lights were illuminated. The vehicle was taken to an independent mechanic, and an undisclosed fuse was replaced. The mechanic made the contact aware of the federal safety agency Campaign Number: 15V144000 (Steering). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and scheduled an appointment with the dealer for the recall repair of the federal safety agency Campaign Number: 23V734000 (Electrical System). The failure mileage was approximately 189,000.

Filed Jun 15, 2026 · Electrical, Engine · VA

UNKNOWN - On XXX, at just 7,741 miles, my 2025 Toyota RAV4 XLE Premium AWD (VIN: [XXX]) suffered a catastrophic and life-threatening complete mechanical and hydraulic transmission failure. The vehicle completely lost forward propulsion when placed in Drive mode, rendering it entirely immobile. When placed in Reverse gear, the transmission violently over-pressurized, causing the vehicle to suddenly surge and jump uncontrollably. Simultaneously, the dashboard displayed 6 critical safety system failures: 1. Check Engine — electronic control malfunction 2. Vehicle Stability Control System (VSC/TRAC) malfunction 3. Secondary Collision Brake System malfunction 4. Pre-Collision System malfunction 5. Parking Brake System malfunction 6. Advanced Ultrasonic Detecting and Ranging System malfunction Ourisman Toyota Chantilly (RO# XXX) has confirmed complete transmission failure. Fault codes found: P28167F — Pressure Control Solenoid H Actuator Stuck Off, P08BA7F — Pressure Control Solenoid L Actuator Stuck Off. Estimated repair cost: $11,347.42. While this failure fortunately occurred on a local road, had it occurred while merging onto I-66 or I-95 at highway speeds, it would have inevitably caused a catastrophic high-speed collision. This represents an extreme manufacturing defect and life-threatening safety hazard. Toyota Corporate Cases opened: #XXX (original case) and #XXX (full replacement request). I am requesting full vehicle replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 2, 2026 · Electrical · MS

My car has shut off for a second time without warning. This time was in a busy chic [XXX] drive through line in [XXX] . The car read “low power steering” and the battery and engine light came on. These have both been checked before in addition to the alternator and they cannot find an issue. I am having it taken back to the dealership tomorrow for further investigation. Given I purchased this vehicle with a little over 19k miles and the car now only has 22k miles on it. It should not have any significant issues such as cutting off while driving on the interstate or while sitting in a busy drive through lane waiting for food. Now I am wondering if the previous owner traded it in for this issue. I will say, both incidences it has been raining and the first time I could have been hit by oncoming traffic due to low visibility and I am wondering if heavy rain has something to do with this. The car has not been through any significant puddles or left out in the rain. It sits in the garage when not in use and has only been used as a work commute vehicle. Something is wrong. They need a recall! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 29, 2026 · Engine · RI

TSB T-SB-0010-24 P0303 code 163,000 miles Toyota denied goodwill assistance Cost: $2,549.65 Check engine light came on with vehicle hesitation on acceleration almost caused to stall with reduced power while driving , the dealership diagnosed the issue as TSB T-SB-0010-24 with cylinder #3 misfire requiring exhaust valve lash adjuster to be replaced. Contacted Toyota corporate to request help with goodwill or discount , was denied , was told they couldn't help no reason given .This issue is a well know Toyota RAV4 defect and even though they claim it only happens when is cold this happened to my SUV at 60*F. Please help.