2002 Toyota Sequoia fuel system problems

Filed Jul 20, 2022 · Fuel system, Steering · NJ

Rack and pinion rusted out and had to be replaced. It cracked in the middle of the highway and left me inching to safety. Never fully recovered 186k, frame is fully rusted and will not pass inspection due to faulty oxygen sensors and excessive rust and corrosion. Will need to replace exhaust to input a new sensor at 4k Vechicle is fully operable and functional but cannot pass inspection without the safety of rust treatment or replacement It’s a great vechicle but unfortunate that the 2002 series is left out of the recall . There are a lot of early generations that have these issues and although the trucks are reliable and have a long life , are undriveable because they can’t pass inspection. Please consider extended the rust recall to 2001-2003 Sequoias. This was my grandfathers truck and really would like to keep his memory in the family and drive my grandfathers truck as it still runs perfectly but has on going issues with rust and frame issues . There was an extended warranty for 2002 Sequoias that expired in 2014. This is a point where most Sequioas weren’t experiencing this issue. Dealership or recall will not honor and denied any claim for rust It is unfortunate because I am now disabled and love my Sequoia so much and was hoping to drive to appointments and gain my health back. It has become more than I am able to afford to fix an entire frame of the vehicle. It’s evident that early generations all that his issue but has not been honored for repair. I’ve repaired things over the years with hopes to pass inspection and now have insight as to what the real issue is. The excessive rust and damage to the frame.

Filed Dec 3, 2014 · Acceleration, Engine · 196,000 miles · TN

Vehicle makes a sputtering noise at acceleration and coasting speed. Even at stop. Sounds like a misfire and thud at some points. Causes a loss in power and jerk.

Filed Dec 3, 2014 · Brakes, Engine · 196,000 miles · TN

At stop and starting to accelerate vehicle hesitates while trying to go into intersection. Stalls for a few seconds vsc light comes on and once system gains control it lets me actually accelerate and proceed. Dangerous due to oncoming traffic and the hesitation time of not knowing how long until I regain control.

Filed Apr 10, 2013 · Acceleration, Electrical · 181,878 miles · KS

Driving at 75mph and inexplicably lost vehicle speed. Engine was running but would not respond to foot feed, I.e. Press down on accelerator and little to no increase in rpms from idle. Dealer replaced throttle position sensor.

Filed Dec 10, 2011 · Acceleration, Driver assistance · 188,750 miles · OH

Vsc light, trac off light and check engine light all came on at the same time. I took vehicle to autozone and they checked the computer with the result error 5 cylinder misfire, for the check engine light, the other 2 warning lights they could not give me any advice on.

Filed May 27, 2010 · Engine, Fuel system · CA

My 2002 toyota sequoia has stalled 3 times while driving & each time I was towed to my mechanic at 1437 aviation blvd. Redondo bch. Ca. 90278(lexology) 310‑379‑0543. It happened twice while driving on main streets with my child in the car & once on the freeway. The first time was june 6,2008 second time jan.20, 2009 & third time aug.28,2009.

Filed Mar 31, 2010 · Fuel system · 48,000 miles · CA

Spoke with mr. Richard newman-service manager at frontier toyota in california on 3/13/10 regarding recent issues with the gas tank sensor on our 2002 toyota sequoia. We have a phantom problem with the fuel gauge reading no gas while our mileage counter indicates large mileage leaps taken while not driving hardly any mileage. This problem has been sporadic over the several months. Mr. Newman stated toyota has been of this problem with this make and model year for several years and when we told him that toyota refused to fix it when we first brought it to their attention when it first occurred and we were told it would cost approximately $600.00 to remove the tank and fix the problem. Mr.newman was asked by us why toyota never issued a recall or notice for this particular make and model. His response was that he was only aware that this problem has always exisited for this 2002 sequioa and advised us to contact your agency with regards to another electronic problem exisiting with another toyota product. This is distressful to drive such a vehicle to find it suddendly indicating it is out of gas and ticking off huge amounts of mileage not traveled and we can not duplicate this problem on demand.

Filed Apr 4, 2009 · Acceleration, Brakes · 90,000 miles · SD

While driving a 2002 toyota sequoia sr5 2 wheel drive SUV near the end of march 2009, the trac off, vsc trac, brake and ABS warning lights simultaneously came on. I was traveling approximately 55 MPH on a dry road at night in heavy traffic. I moved off the highway to check the manual which emphasized the possible seriousness of each light. It said to contact a toyota dealer. I called earnhardt toyota in mesa arizona who finally worked on the vehicle several days later for the vsc/trac/brake/ABS problem, and a front brake vibration/pulsation. No help on the pulsation problem since I was told I needed to turn the rotors again. On the vehicle stability control/traction control/anti-lock braking system/brake warning lights, the service associate offered that it was a "common" problem, could be caused by a loose gas cap or an expensive computer (in the thousands of dollars). He sated that no "codes" were set other than a "low voltage" which could be caused by a bad battery or corroded connection. I cleaned the battery terminals completely, checked the battery, and made sure the gas cap was tight. The warning lights now come on at some point every time I drive the sequoia. Earnhardt toyota told me it should not affect the actual braking systems. How do they know that? Being told of a false continuous or intermittent safety warning light can lull one into a questionable sense of safety. These lights and safety systems need to work reliably without having toyota just say they know about this common problem. Does it affect actual vehicle stability control and emergency braking? On numerous internet sites, I find this same problem is mentioned frequently. Also a large number of complaints are on file now with the federal safety agency. I rely on the warning lights and their underlying systems to work as advertised, but toyota now makes me doubt that reliance. Does there have to be a large "body count" for the federal safety agency to order a recall to fix this well known safety problem?

Filed Dec 29, 2004 · Fuel system · GA

I have toyota sequoia 2002 - the dealership replace a fuel sensor and now thee vehicle get about 6 miles per gallon.

Filed Sep 25, 2002 · Fuel system · AL

Consumer states, while driving the vehicle at any speed smell strong chemical fumes into the passenger compartment intermittently. Dealer has been notified. Please provide further information